2018 BMW 3 Series Complaints

ELECTRICAL SYSTEM — Filed 06/17/2025

While driving on the highway, my vehicle unexpectedly caught fire due to no fault of my own. Upon investigation, it appears the fire originated from a short in the rear window defroster wiring, which led to significant damage in the right rear C-pillar area, headliner, rear window, and rear deck. This event was not only hazardous to my physical safety but also deeply traumatic on a personal level. As someone who suffered severe burns as a child, experiencing a fire while operating a vehicle triggered a powerful emotional response. The trauma of the incident has had a profound impact on my mental health and sense of safety. I have always trusted BMW for its engineering excellence and commitment to safety, which makes this situation even more disheartening because they refuse to fix my vehicle.

POWER TRAIN,FUEL/PROPULSION SYSTEM — Filed 03/20/2025

Car just shut off when driving at 65mph and never started back up, took it in and repair was a bad fuel pump and fuel rail line causing metal shards to go through fuel tank and injectors.

ELECTRICAL SYSTEM — Filed 06/12/2025

I smelt and saw smoke coming from the back of my vehicle. I pulled over on to the left side of [XXX] bound. Then, I jumped out of the car to check the truck. I didn't see anything, then i popped the hood and still did not see anything visible. I then went back to the trunk to check it again, and that is when I saw flames pop out from the back seat area. It was in the area where the back de-frost wires and some other wires are as well. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 05/05/2025

Was simply driving my vehicle to work. It started overheating parked it right away before it got worse as the car alerted had it towed to a shop. The shop informed me that the motor was blown in the pistons went through the motor something with the oil the mechanic and I were looking further into this and it looks like my make and model in year had some recalls about the motor overheating in the past so I would really like this looked into as this might be a recall I’m not sure what else this could be or why this would happen with such low miles

UNKNOWN OR OTHER,ENGINE — Filed 04/21/2025

My 330i 2018 bmw has a cracked in the oil housing unit. This is due to bmw putting plastic parts instead of aluminum. After researching this I found thousand of people complaining about the sane thing. The car overheats and sometimes the oil gets mixed into the coolsnt system b causes more damage. This seems to happen on cars with mileage between 60-70 on engines B46, B48 n B58z

ENGINE — Filed 03/13/2025

The contact owns a 2018 BMW 330E. The contact stated that while driving at an undisclosed speed, there was an abnormal squealing sound coming from the engine compartment, with the check engine warning light illuminated. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 55,000.

ENGINE — Filed 02/28/2025

Oil Filter Housing failed and coolant gushes all out which makes the car undrivable and risk of engine overheating and failure.

FUEL SYSTEM, DIESEL — Filed 01/19/2025

The contact owns a 2018 BMW 330I. The contact stated that while driving at various speeds, the engine overheating message was displayed on the instrument panel with the temperature gauge rising to hot(H). The vehicle was taken to an independent mechanic where the coolant reservoir was topped off however, the failure persisted. The contact then received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) which was linked to the failure. The vehicle was taken to the dealer where the recall repair was performed. The contact stated that recently the vehicle began to leak coolant. The vehicle was taken back to the dealer and the contact was informed that the manifold needed to be taken off to perform a diagnostic test. The contact was informed that the oil filter housing unit and the water pump both needed to be replaced. The manufacturer was notified of the failure and transferred the contact to the NHTSA Hotline to report the failure. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 60,150.

FUEL SYSTEM, DIESEL — Filed 01/10/2025

The contact owns a 2018 BMW 328D. The contact stated while driving 50 MPH, the vehicle started shuddering significantly. The contact was able to pull over and the check engine warning light illuminated. The vehicle was towed to the contact's workplace. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and informed the contact that there was no record of a recall on the VIN. However, the contact stated that he received notification of NHTSA Campaign Number: 21V586000 (FUEL SYSTEM, DIESEL). The vehicle remained at the workplace and had not been driven since. The approximate failure mileage was 102,000.

ENGINE — Filed 01/09/2025

The vehicle gave a warning that the engine coolant was low and to power down before it overheated. Upon taking it to the dealer, it was discovered that the oil housing unit was defective. After doing online research, this is a very common issue with this part. I had a previous vehicle with a similar issue that caused the vehicle to shut down in traffic from overheating.

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM — Filed 12/09/2024

The contact owns a 2018 BMW 330E. The contact stated while driving at 60 MPH, the vehicle hesitated, stalled, and restarted independently. The vehicle was taken to a dealer where it was diagnosed that the starter needed to be replaced.  The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number: 24V576000 (ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING), however the VIN was not included in the recall. The failure mileage was 103,000.

AIR BAGS — Filed 12/09/2024

My passenger airbag sensor malfunctioned and the repair is over two thousand dollars. The car is only 6 years old and I believe airbags should last longer than 6 years. BMW has extended warranties for airbags on some models (mine not included) for 15 years without mileage limitation. If a collision occurs, my passenger would be in extreme danger.

ENGINE — Filed 12/03/2024

On 12/03/2024, while traveling at approximately 35mph, the "top off coolant" light came on. After traveling for approximately 10 more minutes, in route to get coolant, a warning message came on the screen advising to drive cautiously to prevent engine scorching. The vehicle then began to slightly lose power while traveling on a busy road. The vehicle was then shut down and towed to BMW dealership. During the tow, it was discovered that coolant was leaking from the center area of the engine block. The manufacturers dealership service rep advised that the technicians discovered that the oil filter housing needed to be replaced. They also found that the coolant pump also needed to be replaced. The rep advised that the coolant seal on the oil filter housing had worn down and caused the coolant leak. He also advised that the coolant pump needed to be replaced, as it was also leaking. It was later discovered because the valve that the pressure propelled, hot coolant flows through in the oil filter housing is made of plastic, it often wears down and coolant leaks out heavily. The water pump is also effected by the part manufacturing issue. In addition to receiving a $4,270.42 invoice for repairs today, we just recently purchased the $199.00 BMW Vehicle Check Service from the dealership on 9/23/2024. At that time, we were advised there were no issues with the vehicle. We have sense learned that there have been multiple recalls on various BMW models for this exact same issue. However, the VIN on my vehicle has not yet been identified for recall. Had this issue gone on for mere moments more, the engine could have caught fire, and or, a catastrophic crash could have ensued, effecting any driver on the road.

FUEL/PROPULSION SYSTEM — Filed 01/12/2022

Coolant fluid exits from the expansion tank into the overflow leaving no fluid in the expansion tank. Then it causes and overflow/steam to burst out of the overflow tank. Then the coolant is low notification comes on which warrants to replace the coolant fluid. Took it to a few BMW dealers. They've did a flush, replace expansion tank, and water pump, also tested the pressure several times at 2 different BMW dealerships. I leave the dealership broker and with the same problem starting again within that week. This has been a constant issue which never seems to be fixed by any BMW dealer.

FUEL/PROPULSION SYSTEM — Filed 09/13/2024

Gas tank began leaking from top of blind flange, similar to other extended warranties (SIB 01 03 22 and SIB 01 07 22). BMW is refusing to cover my specific model year (I have sent letters requesting reimbursement and called multiple times). It created an explosion hazard in my garage. Had mechanic repair, I do not have part. Cost $2,000 for new tank that will probably develop same issue. There were no warning lamps.

UNKNOWN OR OTHER — Filed 08/12/2024

Car coolant is leaking due to a bad plastic coolant vent line. I had this issue in January 2023 where it was covered under a recall. I tried contacting the bmw dealership who fixed this recall and they stated there was no current recall. Although is the same issue again.

POWER TRAIN,FUEL/PROPULSION SYSTEM — Filed 11/01/2023

My 2018 bmw 320 stalls and cuts off when I come to a stop. Very dangerous. It has cut off in the middle of the road. I have checked online to see if this is a common issue. Other bmw owners have reported this same issue. There has been a recall on other bmw models with this same issue from 2014-2018 for fuel system and fuel pump that may cause this issue. Letters were sent out I. January of 2022. My 2018 bmw 320si has not been included in this recall for some odd reason. When car shuts off a warning message appears on screen. One message states “transmission not in park.” Or “drivetrain malfunction”. This began to happen on November 2022. I have taken my vehicle to two dealers. One was an independent repair shop and the other was a bmw service center. Both reported issues with fuel pump that would cause this problem.

FUEL/PROPULSION SYSTEM — Filed 03/24/2024

My 2018 BMW 330i has the same problem that the recall for the fuel sensor level on 2018 BMW M5! I broke down on the side of the interstate and had it towed to BMW and they said it was the fuel sensor reading more than it should and wanted to charge almost 3,000 to fix it. There are similarities to the other recalls and my vehicle should also be included in that recall. I had to pay 300.00 just for them looking at it. I found it odd the sensor would do that and my investigation has brought me here. There was no warning and I was stranded on the interstate

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE — Filed 09/01/2023

Rattling noise we’ll driving and when going over 30 mph can lose control

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE — Filed 05/01/2023

Rattling noise when accelerating

ENGINE,FUEL/PROPULSION SYSTEM — Filed 01/20/2022

On January 19, 2022 I was driving and then smoked filled inside my car and the outside engine was smoking and a light came on that said check coolant. BMW service took me in that day and they said my coolant broke. They removed it and replaced it. They did not understand how the coolant broke but I paid for the service and parts and moved forward. On November 25, 2022 I went into the same BMW service center to get a routine car service and they stated there was a recall and they would replace my coolant for free. (After I told them I paid for it ($699.63) . They insisted I replace it for free again and reach out to BMW corporate for a reimbursement of previous service. I received a call yesterday stating they would not replace it and reach out and file a report with NHTA.

ENGINE — Filed 01/18/2021

RETURNING FROM A LOCAL GROCERY STORE I DROVE INTO OUR GARAGE AND SHUT OFF THE ENGINE. IMMEDIATELY I HEARD A LOUD POP FROM THE ENGINE COMPARTMENT, LIKE FROM A FIRECRACKER, AND I SAW BLACK SMOKE COMING FROM THE HOOD AND FROM THE LEFT WHEEL WELL. I IMMEDIATELY TRIED TO RESTART THE CAR TO DRIVE OUT OF THE GARAGE. NOTHING WORKED SO I PUSHED THE CAR OUT OF THE GARAGE BY HAND AND RELEASED THE HOOD LATCH. BY NOW THE HOOD'S EXTERNAL SAFETY LATCH WAS SO HOT I COULD NOT RELEASE IT. WITH THE HOOD CLOSED, I WAS UNABLE TO EXTINGUISH THE ENGINE FIRE USING A 15 LB CO2 AND A 5 LB ABC EXTINGUISHER. THE CITY FIRE DEPARTMENT ALSO WERE UNABLE TO EXTINGUISH THE FIRE UNTIL THEY SAWED THE HOOD IN HALF. THE 2 1/2 YEAR OLD CAR WAS A TOTAL LOSS. A EXPERT FROM BMW OF NORTH AMERICA INSPECTED THE CAR REPORTING THAT WAS TOO MUCH DAMAGE TO DETERMINE THE FIRE'S CAUSE. BMW NA CALLED TO REPORT THE RESULT NOT THEIR INVESTIGATION AND SAY THAT NO WRITTEN REPORT WAS AVAILABLE, ONLY THE VERBAL VERBAL FONECON.

SERVICE BRAKES,ENGINE — Filed 07/06/2020

I WAS STOPPED AT A STOP LIGHT WITH MY FOOT ON THE BRAKE FOR ABOUT A MINUTE WHEN THE CAR SUDDENLY ACCELERATED AND LUNGED FORWARD.I APPLIED MORE PRESSURE TO THE BRAKE,ALL THE WAY TO THE FLOOR , BUT THE CAR WOULD NOT STOP. THE CAR IN FRONT OF ME IS THE ONLY THING THAT STOPPED THE CAR ,AS HE WAS STOPPED TOO. THE CAR THEN BOUNCED BACKWARD AND TURNED OFF BY ITSELF. I WAS ON A MAIN STREET AT A LIGHT. IT WAS FORTUNATE THAT ANOTHER CAR WAS STOPPED IN FRONT OF ME BECAUSE IT STOPPED THE CAR AND PREVENTED MY CAR FROM HITTING PEDESTRIANS.

VEHICLE SPEED CONTROL — Filed 01/12/2020

ACCELERATION ISSUES. I COMPLAINED TO BMW ABOUT THE ISSUE NOVEMBER 2018 FOR MY 2018 BMW. HOWEVER, BMW SAID THERE WASN'T A PROBLEM. ON SUNDAY AT AROUND 6:28 PM I WAS PULLING INTO A PARKING SPACE AT MY CHASE BANK AND THE CAR SUDDENLY STARTS ACCELERATING CAUSING ME TO HAVE A HEAD ON COLLISION WITH A PARKED CAR. MY 2015 BMW HAD THE SAME PROBLEM. I WAS IN RALPH'S PARKING LOT IN BEVERLY HILLS ABOUT TO PULL OUT WHEN SUDDENLY MY BMW ACCELERATED, AND I NEARLY KILLED TWO PEOPLE. WHEN I BOUGHT IT IN FOR SERVICE BMW REPAIRED THE PROBLEM. SOMETHING WAS CALIBRATED TO HIGH.

AIR BAGS — Filed 02/26/2018

AIRBAGS FAILED TO DEPLOY IN SERIOUS ACCIDENT CAUSING INJURY. VEHICLE WAS TRAVELING WHEN STUCK IN FRONT LEFT BUMPER BY ANOTHER VEHICLE TRAVELING APPROXIMATELY 45-50 MPH