2020 BMW X3 Complaints

ENGINE — Filed 10/07/2026

I am reporting a safety concern involving BMW vehicles equipped with the B58 Technical Update (B58TU) engine, commonly found in model years 2019–2021. These vehicles utilize a variable-displacement engine oil pump containing an internal thermoplastic adjusting component responsible for regulating oil pressure. Field failures are increasingly being reported in which this internal component fractures, resulting in sudden loss or instability of engine oil pressure. The failure frequently occurs during cold-start operation in low ambient temperatures. When the component fails, oil pressure regulation becomes erratic or is lost entirely. In many cases, drivers receive little or no actionable warning prior to engine damage or vehicle disablement. Reported precursor symptoms include inability to electronically measure engine oil level, abnormal oil pressure behavior, or sudden drivetrain malfunction warnings. Failures may rapidly progress to engine shutdown or severe mechanical damage caused by oil starvation. Loss of lubrication can cause the vehicle to become disabled without warning while driving or shortly after startup. This creates a safety hazard, particularly when vehicles become immobilized in active traffic or during winter conditions the cold is when they fail the most, where occupants may be exposed to freezing temperatures while awaiting assistance. Replacement of the oil pump requires extensive disassembly of the vehicle and repairs commonly exceed $6,000–$8,000 for just the pump, assuming the motor is unharmed. BMW has actively removed the plastic part number out of all dealer networks. Failures have been reported across multiple production years, and affected vehicle population boundaries remain unclear. Because this condition can result in sudden vehicle disablement without adequate warning especially in the cold, I believe this issue warrants investigation as a potential safety-related defect.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER — Filed 11/07/2025

I am reporting a chronic manufacturing defect on my 2020 BMW X3 that poses an immediate electrical short-circuit and vehicle safety hazard. The passenger-side panoramic sunroof drainage system/roof structure leaks water heavily through the side panel joint of the door frame, directly saturating the front passenger floor carpet. This issue has been ongoing since I received the vehicle in 2020.The vehicle has been brought to Kelly BMW of Columbus, Ohio, at least four separate times since 2020 specifically to address this leak. Technicians have replaced outer seals and cleared tracks, but the leak persists, and on the last visit, unqualified dealership staff claimed they "could not find anything wrong. "This is a severe safety risk: BMW places the primary electronic fuse blocks and vital vehicle wiring harnesses directly underneath the front passenger floorboard carpet. Constant water logging in this exact area threatens to cause sudden, catastrophic electrical failures, component shorts, or vehicle stalling while driving. The manufacturer has failed to issue a recall for this known, widespread G01 platform defect, and dealership service centers lack the training to properly diagnose it.

FUEL SYSTEM, DIESEL,ELECTRICAL SYSTEM — Filed 06/15/2026

The contact owns a 2020 BMW X3. The contact stated that while driving 25 MPH, the message “Heat Management Module Malfunction” was displayed and the warning light was illuminated. The drive-train warning light was illuminated. Upon research, the contact became aware of NHTSA Campaign Number: 21V586000 (Fuel System, Diesel). The vehicle was previously taken to the dealer to be diagnosed, and the contact was informed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted, but no additional assistance was provided due to a prior good-faith repair being provided. The failure mileage was approximately 70,000.

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE — Filed 05/15/2026

Heat Management Module HMM is bad. BMW used a plastic part that is right up against the engine block. This HMM Heat Management Module resulted in STOPPING the vehicle completely in the middle of the freeway. I had no control. Then the car drove, then stopped again. I had NO CONTROL over the vehicle. Weeks later the Drivetrain Malfunction warning light appeared as i was driving home late at night from the ER. I took it to my BMW dealer. The diagnostic test was performed and was told the Heat Management Module HMM needed to be replaced at a cost to me of $3000. I contacted BMW USA, explained what transpired and they responded with a denial. I stopped driving the car completely after i found other complaints about BMW using an inferior part on the 3 series and the same issue about the car stopping in highway traffic without any control. I later got my BMW repaired, at the BMW dealer, as i could not afford to buy another car. I have the defective inferior part in my possession for inspection by NHTSA. BMW refuses to recall the Heat Management Module HMM and will not address the Drivetrain Malfunction warning light. I would like this to be escalated and investigated by NHTSA.gov so that others may be safe when driving please. Thank you.

ENGINE — Filed 06/22/2026

I own a 2020 BMW X3 M40i, VIN [XXX], manufactured November 2019, now at approximately 100,000 miles, equipped with the B58TU engine. My oil level sensor stopped completing measurements at approximately 45,000 miles, a known precursor to thermoplastic oil pump failure. For 55,000 miles I had no way to identify whether my vehicle contained the defective component because BMW removed the original thermoplastic part number from all dealer networks. VIN-based lookup now falsely returns updated metal component information regardless of what is physically present in the vehicle. This makes proactive identification impossible for both owners and dealers, meaning the defect cannot be remediated even by willing owners. I had no actionable path forward. On [XXX] I was driving on a Florida highway at 80 mph when a low oil pressure warning appeared. I pulled over immediately. A fault log pulled at 2:05PM showed code 1C3002. A second log pulled at 6:49PM after briefly running the engine showed three additional oil system faults including 1C2002 - engine oil pump pressure too low - indicating active progressive failure within hours. This failure occurred in 90 degree Florida summer heat, not cold weather. If NHTSA’s investigation is scoped around cold climate failures, my case demonstrates that scope is incomplete and the affected population is broader than currently documented. Carfax records confirm 18 total service records over 100,000+ miles, including 8 dealer visits between 18,000 and 50,000 miles under active CPO warranty. This vehicle has been consistently and properly maintained throughout its life. The vehicle became a safety hazard at highway speed without adequate warning. I will file a second complaint after physical inspection confirming which pump variant is actually present. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 06/16/2026

reporting a safety issue with BMW vehicles equipped with the B58TU engine, primarily 2019-2021 models. These vehicles have an oil pump with an internal plastic component that regulates oil pressure, and this part is fracturing in the field, causing sudden loss of oil pressure. The failure typically occurs during cold starts in low temperatures. When it fails, oil pressure becomes erratic or is lost entirely, often with little to no warning before engine damage or vehicle disablement. Warning signs, when present, include inability to measure oil level electronically, abnormal oil pressure, or sudden drivetrain malfunction warnings. These can rapidly progress to engine shutdown or severe damage from oil starvation. This creates a dangerous situation because the vehicle can become disabled without warning while driving or after startup. This is especially hazardous when cars become immobilized in traffic or during winter conditions when failures occur most frequently, leaving occupants exposed to freezing temperatures while awaiting assistance. Pump replacement requires extensive disassembly and commonly costs $6,000-$8,000, assuming no engine damage. A critical concern: owners cannot determine if their vehicle has the original plastic pump or the later metal revision. BMW's VIN-based parts lookup now shows updated components even when original plastic parts remain installed, and BMW has removed the original plastic part number from dealer networks entirely. Failures are reported across multiple production years, and the scope of affected vehicles remains unclear. Because this condition causes sudden vehicle disablement without adequate warning, especially in cold weather, I believe this warrants investigation as a potential safety-related defect.

ELECTRICAL SYSTEM — Filed 05/15/2026

The contact owns a 2020 BMW X3. The contact stated that while driving at an undisclosed speed, the drivetrain warning light illuminated on the instrument panel, causing the vehicle to jerk and run rough. The vehicle was taken to the dealer, where it was diagnosed with a heat management module failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 53,404.

ELECTRICAL SYSTEM,ENGINE — Filed 05/26/2026

The contact owns a 2020 BMW X3. The contact stated that after parking the vehicle and turning the engine off, approximately 10 minutes later a burning rubber odor was present inside the cablin of the vehicle and smoke was present coming from under the hood. The contact opened the hood discovered flames coming from the engine. The fire and police departments were called to the scene and the fire was extinguished the flame. During the incident the vehicle destroyed and later lowed away. A fire and police report was taken. No injuries were reported. The cause of the fire was not yet determined. The manufacturer was notified of the incident. The local dealer was not contacted. The contact was informed that the VIN was not included in the NHTSA Campaign Number: ( ). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 65,000.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM — Filed 05/16/2026

I am submitting this complaint regarding ongoing and potentially dangerous mechanical failures involving my vehicle that have repeatedly occurred despite numerous repair attempts by the dealership. Over the past year, I have taken my vehicle to the dealership more than 10 times for serious recurring issues. The problems have included: Drivetrain malfunction warnings Engine warning lights Oil leaks Smoke coming from the vehicle The vehicle unexpectedly shifting into neutral while driving Sudden loss of drivability requiring the vehicle to be towed The dealership has repeatedly stated that the issues were repaired, and at one point even provided a one-year warranty on the repair work. Despite this, the same problems have continued to occur. Most recently, the drivetrain malfunction warning and engine light returned again, smoke came from the vehicle, and the car shifted into neutral on its own, becoming completely undriveable and requiring towing. I have spent more than $10,000 on repairs related to these ongoing issues, yet the vehicle remains unreliable and unsafe. My primary concern is the safety risk posed by the drivetrain failure and the vehicle unexpectedly shifting into neutral while in operation. I am requesting that this matter be reviewed as a potential vehicle safety issue. I believe these repeated failures may present a serious risk not only to myself but potentially to other drivers as well. Thank you for your attention to this matter.

ELECTRICAL SYSTEM — Filed 03/17/2026

The contact owns a 2020 BMW X3. The contact stated while driving at an undisclosed speed, the brake pedal was released, the auto start feature failed to function as intended. The vehicle was taken to the dealer where it was diagnosed with a failed engine starter. The contact was informed that the engine starter needed to be replaced. The vehicle was not repaired. The contact referenced a recall, NHTSA Campaign Number: 25V636000 (Electrical System) however the contact's VIN was not associated. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 55,000.

UNKNOWN OR OTHER — Filed 05/02/2026

While stopped at a red light, my front sunroof panel exploded/shattered. My brother and I heard a loud bang. No object hit the sunroof. It was visible that the glass was bubbled outward. And, the 4 corners had cracking. Lucky the roof liner was closed and no glass hit us.

AIR BAGS,SEATS — Filed 03/25/2026

The heated seat element had a runway incident that caused the seat to smoke and burn a hole through multiple layers and ultimately damaging the airbag sensor mat disabling the passenger airbag system

FUEL/PROPULSION SYSTEM — Filed 04/16/2026

It has come to my attention that liquid from the Positive Crankcase Ventilation (PCV) system may leak onto the water pump electrical connector. This condition can lead to an electrical short circuit and, in rare cases, may increase the risk of a vehicle fire. This issue presents a serious safety concern for vehicle owners and others on the road. A failure of this nature, especially one that carries a fire risk, warrants immediate review and corrective action. I respectfully request that NHTSA investigate this matter and determine whether a safety recall is necessary to address this defect. The dealership noticed the leak beginning at the weep hole of the waterpump. No incident occurred this is for preventive measures and review for recall and reimbursement

LANE DEPARTURE,BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE — Filed 03/15/2026

Due to a TSB (SIB 65 12 22) wherein the roof antennae leaks water and causes a short in the telemetry module, the car does not have pedestrian warning, navigation or backup camera / cross traffic warning. The car is drivable, but compromised from a safety perspective.

ELECTRICAL SYSTEM — Filed 12/07/2025

The contact owns a 2020 BMW X3. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part to do the recall repair was not available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

ELECTRICAL SYSTEM — Filed 09/01/2025

The contact owns a 2020 BMW X3. The contact stated that upon starting the vehicle, there was an abnormal thumping sound coming from the vehicle. There was no warning light illuminated. The contact later received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The vehicle was taken to a local dealer, and the contact was informed to leave the vehicle at the dealer overnight. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The vehicle was not repaired. The failure mileage was approximately 60,000.

UNKNOWN OR OTHER — Filed 03/15/2026

I am submitting a formal safety complaint regarding a defect in my 2020 BMW X3 that has resulted in the failure of a critical emergency safety system. The vehicle displayed an error message indicating an “Emergency Call System Malfunction.” I brought the vehicle to BMW of Murrieta on March 30, 2026, for diagnosis and repair. Upon inspection, the service center determined that the Telematic Control Unit (TCU) had sustained water damage. This damage was attributed to water intrusion originating from the vehicle’s shark fin antenna. This is a known issue documented by BMW in internal Service Information Bulletin SIB 65 12 22 (dated October 5, 2022). Despite acknowledgment of this known defect, BMW declined to cover the repair costs for both the antenna-related water intrusion and the resulting damage to the TCU. This failure presents a significant safety hazard. The emergency call system is designed to automatically notify emergency services in the event of a collision. With this system inoperable, occupants may be unable to receive timely emergency assistance, increasing the risk of serious injury or death. Given that BMW is aware of this defect and its potential to disable a critical safety feature, I believe this issue warrants further investigation and should be considered for a mandatory safety recall.

ENGINE — Filed 09/23/2025

This recall was in September 2025, and for a starter issue that could cause a fire. Despite the urgency of this recall, it's now six months later, and I am still getting a response from BMW "Remedy Not available". So, in the meantime BMW advises to keep the car outside in the hot Florida sun so it doesn't burn the house down. This is a totally unacceptable situation, and I would appreciate the NHTSA following up with BMW regarding why the delay. It appears to me that BMW is dragging their feet on correcting this serious issue.

FUEL/PROPULSION SYSTEM — Filed 03/02/2026

We had an oil pump failure that was because the part was plastic, not metal.

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM — Filed 02/05/2026

Component Failed: Engine starter relay and starter motor assembly. The vehicle stalled in traffic and ignited upon a restart attempt. The vehicle is a total loss, currently held by [Insurance Co] at [Location/Lot #], and is available for inspection. Safety Risk: The driver’s life was at immediate risk. The vehicle stalled in active traffic, creating a collision hazard, followed by a rapid, uncontrollable engine fire. The driver suffered smoke inhalation and severe trauma while escaping. A delayed exit would have been fatal. Confirmed by Dealer: The failure mirrors the defect pattern in Recall 25V-636 (Starter Relay Corrosion). While the fire prevents reproduction, the vehicle had a consistent service history with no prior electrical issues. Inspected By: The vehicle was inspected by [Insurance Co] and declared a total loss. [Optional: The Fire Dept. responded under Report #[Number]]. BMW was formally notified via demand letter on [Date]. Warning Lamps/Symptoms: No prior warnings. The failure was acute. A "Drivetrain Malfunction" message appeared seconds before the stall. Smoke and flames appeared immediately upon the attempted restart.

ELECTRICAL SYSTEM — Filed 10/11/2024

The contact owned a 2020 BMW X3. The contact stated that while her husband was driving 10-15 MPH in a parking lot and attempting to make a turn, the brake pedal was depressed, but the pedal travelled down to the floor, and the vehicle failed to respond. Additionally, the steering wheel seized, and the accelerator pedal was depressed, but the pedal travelled down to the floorboard, and the vehicle failed to respond. The contact stated that the vehicle became inoperable, causing the front driver's side bumper and door of the vehicle to crash into the rear-end of an unoccupied parked vehicle, and then the front end of the vehicle crashed into the side of another occupied parked vehicle. All the air bags of the vehicle deployed. There were no injuries sustained. A police report was filed. The police report confirmed that the impacts occurred a few moments before the contact received failure notifications on the vehicle mobile app. The vehicle remained inoperable and was towed to Spitler's Collision, where it was deemed a total loss. The Chevrolet dealer where the vehicle was purchased was notified of the failure. The manufacturer was notified of the failure and sent engineers who inspected the vehicle at Spitler's Collision 8 months later. The manufacturer later informed the contact that the collisions occurred because the driver did not turn away from the other vehicles and did not depress the brake pedal as needed, which the contact stated was the description of the failure. No further assistance was provided. The manufacturer and the auto finance company deemed the vehicle a total loss. The failure mileage was 67,540.

ELECTRICAL SYSTEM,STRUCTURE,VEHICLE SPEED CONTROL — Filed 10/03/2024

The accident happened at Noon on [XXX] at the Amazon Fresh/Post office parking lot’s far right exit lane facing [XXX] The address is [XXX] . We were leaving the parking lot and I stopped at the exit lane with 2 cars in front of us. After the first car exited, the second car, a black Ford Explorer, moved forward. I released the brake slightly but my foot was still on the brake pedal. At this moment, my car suddenly accelerated and quickly approached the Explorer. I immediately pressed the brake pedal hard but was unable to stop my car and hit the back of the Explorer. The Explorer was forced out in front of the stop sign but the driver was able to turn right to park at the roadside. With my foot still firmly on the brake pedal, my car kept on accelerating into [XXX] , crossing 5 lanes of traffic until we hit the roadside curb of westbound [XXX] . The car then swerved left and hit a roadside tree, turning sideways into [XXX] middle turn lane. During this entire time, I did not press the accelerator and the car was violently shaking and jerking right and left. As the car slowed down, I was able to steer the car to the right eastbound lane of [XXX] , next to the parking lot near Bank of America’s ATM sign. After I got out of the car, I noticed the front and right sides of the body and tires were damaged including crushing, dents, and significant scratching. The problem I believe is as follows: 1.Sudden Unintended Acceleration and Control Circuit Malfunction. 2.Airbags did not deploy even though we hit a car, curb and tree. 3.Onboard Data Recorder should have the information needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 02/11/2023

The contact owned a 2020 BMW X3. The contact stated after parking her vehicle at her residence, the vehicle caught fire around the engine independently. The fire department extinguished the fire. A fire and police report were filed. The vehicle was not drivable. The contact stated no one was injured nor sought medical attention. The insurance company deemed the vehicle a total loss. The vehicle was not diagnosed. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 11,700. The consumer stated the police and fire reports have been requested and waiting to receive the reports.

ENGINE — Filed 07/26/2021

The contact owned a 2020 BMW X3. The contact stated the vehicle was stationary at a parking lot, when the front passenger informed her that there was smoke coming from under the passenger’s side hood. The contact stated a bystander attempted to extinguish the fire with a fire extinguisher but failed. The fire department arrived within 10 minutes and was able to extinguish the fire. The contact stated no one was injured nor was medical attention sought. A fire report was filed. A police officer arrived at the location and filed a police report. The vehicle was not drivable. The vehicle was towed to towing lot. The insurance company deemed the vehicle a total loss. The contact called the local dealer and left a voicemail. The manufacturer had not been informed of the failure. The failure mileage was approximately 7,000.

ENGINE — Filed 03/25/2021

TL* THE CONTACT OWNS A 2020 BMW X3. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND UNATTENDED, IT SPONTANEOUSLY CAUGHT FIRE. ADDITIONALLY, A LINCOLN MKZ PARKED ADJACENT TO THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO REPORTED INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 8,000.