2020 BMW X5 Complaints

SERVICE BRAKES, HYDRAULIC — Filed 09/17/2026

The contact owns a 2020 BMW X5. The contact stated that while driving, the ignition switch message was displayed. The contact stated that later in the day, while driving at an undisclosed speed, the brake pedal was depressed, and the brake malfunction message displayed. The contact forcefully depressed the brake pedal to stop the vehicle. The vehicle was parked and turned off. The vehicle was restarted. The contact stated that several unknown warning lights were illuminated. The dealer was contacted by phone and made aware of the failure. The vehicle was taken to the dealer, where it was diagnosed with a brake master cylinder reservoir failure. The contact was informed that the brake master cylinder reservoir needed to be replaced. The contact referenced NHTSA Campaign Number: 21V062000 (Service Brakes, Hydraulic); however, the VIN was not associated with the recall. The manufacturer was contacted by phone, and a case was filed. The contact was informed that the failure was regular wear and tear. The failure mileage was approximately 99,000.

SUSPENSION — Filed 09/03/2025

I am reporting a severe structural safety failure on my 2020 BMW X5. While driving, the front suspension assembly suffered an abrupt mechanical failure. A subsequent inspection by an independent service facility revealed that the front control arm brackets had "burst" / fractured. This exact mechanical failure perfectly mirrors NHTSA Campaign Number 20V678000 (issued for 2020–2021 BMW X5 vehicles), which states that the weld connecting the front axle support to the right front control arm bearing bracket can fail and separate, resulting in a loss of steering control. Despite suffering from the identical, dangerous structural defect outlined in the federal recall, my specific VIN was excluded from BMW's active recall campaign. I had to pay out-of-pocket for an independent repair to make the vehicle safe to drive. I have attached the itemized mechanic's receipt explicitly stating "front control arm brackets burst" as empirical evidence. I request that the NHTSA investigate whether BMW's recall scope for this weld defect needs to be expanded to include omitted VINs.

ENGINE AND ENGINE COOLING — Filed 01/04/2026

See attached document for complaint.

STEERING,ELECTRICAL SYSTEM,ENGINE — Filed 12/31/1969

My 2020 BMW X5 sDrive40i has experienced recurring and serious electrical, shutdown, and drivability problems that have not been resolved despite BMW service and a recall-related repair. The vehicle has unexpectedly restarted after being turned off and has also failed to shut down properly. On September 6, 2026, after being parked at Costco for approximately 40–60 minutes, I returned to find the vehicle off but not secured. The brake lights were on, the windows were down even though I had left them up, and the interior systems were operating. The radio was playing an unfamiliar station, although I do not listen to the radio. I documented this on video. Later that same day at Whole Foods, after parking, turning the vehicle off, and getting out to retrieve my dogs, the vehicle appeared to still be running. Video captured the engine running for approximately one second. I shut it off and locked it, but the vehicle then unlocked itself, also captured on video. These were two separate incidents within nine days, occurring after BMW performed a recall-related repair intended to address unexpected vehicle reactivation. In addition, the vehicle has twice shut off unexpectedly while accelerating on the freeway. These incidents, combined with the unexpected restarting, failure to shut down, windows opening, and vehicle unlocking itself, create serious safety concerns. I purchased this vehicle specifically to transport my dogs. If the vehicle can unlock itself or lower the windows while I am away, my dogs could escape or be exposed to being taken. I no longer have confidence that the vehicle will remain safely shut down and secured when I leave it. The recurring nature of these failures and the fact that they have continued after BMW’s attempted repair require a thorough investigation and permanent resolution. I am requesting that BMW review the complete history and consider repurchase or replacement if the defect cannot be permanently corrected.

ENGINE — Filed 09/10/2026

I'm reporting a safety issue with BMW vehicles equipped with the B58TU engine, primarily 2019-2021 models. These vehicles have an oil pump with an internal plastic component that regulates oil pressure, and this part is fracturing in the field, causing sudden loss of oil pressure. The failure typically occurs during cold starts in low temperatures. When it fails, oil pressure becomes erratic or is lost entirely, often with little to no warning before engine damage or vehicle disablement. Warning signs, when present, include inability to measure oil level electronically, abnormal oil pressure, or sudden drivetrain malfunction warnings. These can rapidly progress to engine shutdown or severe damage from oil starvation. This creates a dangerous situation because the vehicle can become disabled without warning while driving or after startup. This is especially hazardous when cars become immobilized in traffic or during winter conditions when failures occur most frequently, leaving occupants exposed to freezing temperatures while awaiting assistance. Pump replacement requires extensive disassembly and commonly costs 6,000-8,000, assuming no engine damage. A critical concern: owners cannot determine if their vehicle has the original plastic pump or the later metal revision. BMW's VIN-based parts lookup now shows updated components even when original plastic parts remain installed, and BMW has removed the original plastic part number from dealer networks entirely. Failures are reported across multiple production years, and the scope of affected vehicles remains unclear. Because this condition causes sudden vehicle disablement without adequate warning, especially in cold weather, I believe this warrants investigation as a potential safety-related defect.

ENGINE — Filed 09/03/2026

I am reporting a safety concern involving BMW vehicles equipped with the B58 Technical Update (B58TU) engine, commonly found in model years 2019–2021. These vehicles utilize a variable-displacement engine oil pump containing an internal thermoplastic adjusting component responsible for regulating engine oil pressure. Failures have been reported in which this internal plastic component fractures, resulting in sudden loss of or instability in engine oil pressure. My own vehicle has experienced this oil pump failure. The failure is particularly concerning because it can occur during cold-start operation and appears to be more prevalent in low ambient temperatures. When the internal component fails, oil pressure regulation can become erratic or be lost entirely. The resulting loss of lubrication can lead to severe engine damage or vehicle disablement. Reported precursor symptoms include an inability to electronically measure the engine oil level, abnormal oil-pressure behavior, drivetrain malfunction warnings, and other warning messages. However, these symptoms may provide little meaningful advance warning before the vehicle becomes disabled or the engine sustains significant damage. The safety concern is not limited to the cost of the repair. A sudden loss of oil pressure can cause the vehicle to become disabled without warning while driving or shortly after startup. This presents a potential safety hazard if the vehicle loses power or becomes immobilized in active traffic. The risk is particularly concerning during cold-weather operation, when these failures appear to occur most frequently. In winter conditions, occupants of a disabled vehicle may also be exposed to freezing temperatures while waiting for roadside assistance. Replacement of the oil pump is a major repair with cost ranging $6000-8000, even when engine has not been damaged. These costs are secondary to the safety concern but demonstrate the seriousness of the defect and the potential severity.

ENGINE — Filed 08/26/2026

I am reporting a safety concern involving BMW vehicles with the B58TU engine, model years 2019-2021. These engines use a variable-displacement oil pump with an internal thermoplastic adjusting ring that regulates oil pressure. Field failures are being reported in which this component fractures, causing sudden loss or instability of oil pressure. Owners and independent shops report catastrophic engine damage within minutes, with little or no advance warning. A sudden loss of motive power at highway speed, or an engine seizure in traffic, creates a crash risk. I have not experienced a failure. I am reporting because: 1. My vehicle falls within the affected production range. 2. Owners cannot determine whether their vehicle has the original thermoplastic pump or the later metal revision. BMW issued the revised part without changing the part number, and VIN-based parts lookups reportedly return the updated component even when the original is still installed. This deprives owners of any means of assessing their own risk. 3. BMW quietly revised the design to all-metal, indicating the manufacturer identified a durability problem, yet no recall or customer notification has been issued in the United States. 4. Out-of-warranty repair requires removal of the front subframe and eight or more hours of labor. Owners report quotes near $6,000. 5. In South Korea, the Ministry of Land, Infrastructure and Transport opened a formal investigation into this same defect in XXX. BMW Korea then confirmed it is performing this repair free of charge regardless of warranty status. A foreign regulator has already found this serious enough to investigate. I request that NHTSA investigate the B58TU oil pump, determine the failure rate, and evaluate whether a safety recall is warranted. At minimum, owners should be given a reliable method of identifying which pump revision is installed in their vehicle.

ENGINE — Filed 12/15/2025

The oil level reading is failing at 16% due to an oil pump malfunction. BMW has addressed this on all 2022+ b58 engine but all prior years have the plastic failing oil pump. The had to upgrade it because it cause catastrophic failure to the engine. It creates oil pressure with plastic parts and was upgraded to all metal in 2022. There should be a recall for this part since it can cause catastrophic engine failure at any point anywhere while driving at any speed, slow, fast, speed limit. Doesn’t matter the part can fail and injure or kill people

POWER TRAIN — Filed 07/31/2026

I am on my third front differential in first in 2023, one in 2025 and now one in 2026. All M50I have this issue but the X5 M model does not.

UNKNOWN OR OTHER — Filed 07/07/2026

The A/C evaporator coil failed on my 2020 BMX X5 S40i prior to 27,564 miles. It was taken into the local dealer for evaluation at a cost of $811.33 and UV dye was added with refrigerant, which escaped over a 2 week period. The final diagnosis after a further two weeks and at a cost of $301.38, later confirmed that the evaporator coil needed to be replaced. The BMW Dealer quoted $6,686.35 for the replacement. BMW USA refused to comp or co-op the repair. From my research I see that this is a common failure across a large segment of the BMW range and that a conservative minimum of 771,000 BMW vehicles could be affected and that the cost to cure each vehicle ranges between $4,000 & $8,000. I was very surprised to hear that the was no NHTSA recall nor Class Action Law Suit given the potential number of cases and huge expense to cure

VISIBILITY — Filed 08/03/2026

This vehicle has AC problem it’s blowing hot air. It has evaporator leaking. I called multiple shops and they said this problem is very popular for the X5 2019 to 2023 in my car is 2020. Please recall the Evaporator Core problem. It is too dangerous to drive in the car without AC and is too expensive to Have the Evaporator Core replacement.

ENGINE — Filed 08/03/2026

My 2019 BMW X5 (G05) equipped with the B58 Technical Update (B58TU) engine has experienced a failure / is showing early signs of failure of the engine oil pump assembly.Beginning with the B58TU engine, BMW utilized a variable-displacement oil pump that contains a thermoplastic/plastic internal adjusting ring. This plastic component degrades under normal operating temperatures, resulting in a sudden mechanical failure of the pump. This failure leads to a sudden drop in engine oil pressure, vehicle disablement without sufficient warning, or an inability for the iDrive infotainment system to complete an electronic oil level measurement.A sudden loss of engine lubrication while driving presents a severe safety hazard, capable of immobilizing the vehicle in active traffic. BMW has updated this exact pump part number to utilize all-metal internal carriers on later production runs, but refuses to cover the cost for early out-of-warranty models. I am requesting that the NHTSA open a safety defect investigation into the early B58TU oil pump assembly to force a mandatory safety recall.

POWER TRAIN,UNKNOWN OR OTHER,ENGINE — Filed 07/20/2026

It’s a common issue between 2019-2020 where the oil pump which came from factory has plastic impellers which crack/disintegrate causing catastrophic failure to the engine disabling the vehicle the only warning signs before this happens is you cant read oil level and or the car prompts with a warning low oil messages if untreated the car will have catastrophic engine failure with little to no warning the car was mass produced and this is a common issue therefore should be recalled

ENGINE — Filed 06/28/2026

Low oil pressure light came on during interstate drive. Later analysis at dealership revealed this is related to faulty oil pump with plastic parts in B58 engine.

ENGINE — Filed 09/09/2025

I replaced my starter prior to a recall that was issued. After the recall, I submitted a claim for reimbursement and the check was issued. Bmw of North American has not updated the recall information associated with my vin. I am this unable to list my vehicle on any rental platform as it is showing a status of an open recall for the starter. The repair was done in September, 2025 and I was reimbursed 3 weeks ago.

UNKNOWN OR OTHER — Filed 04/15/2026

The AC system blowed hot air. There's must be a problem with this model because my friend also have the 2021 BMW X5 and its AC also have problem. We're suffering from this due to Manufacturing defect.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE — Filed 01/12/2026

While driving through west Los Angeles, the vehicle suddenly began emitting white smoke from the engine compartment. There were no prior warning lights, messages, or symptoms indicating a problem. The smoke quickly intensified and turned dark. Thick smoke filled the air, and the cockpit, with the smell of toxic fumes. I safely maneuvered to the shoulder and exited the vehicle with my passenger. Flames erupted from the front of the vehicle. We called 911, which dispatched the fire department. The LAFD responded, cutting open the hood in order to extinguish the fire. The vehicle was towed to a yard following the incident. The vehicle and its contents were declared a total loss.   BWM North America dispatched a technician to inspect the vehicle. After inspection, the manufacturer indicated that the starter was the source of the fire. At the time of the incident, the vehicle was subject to a safety recall related to the starter with no remedy available. The failure occurred without warning. Both occupants were exposed to heavy smoke.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE — Filed 05/14/2025

I own a 2020 BMX X5 S40i. Car was parked and turned off. When I tried to turn the car ON, the car refused to start and smoke and fire smell started coming from engine compartment. I opened the hood and could smell a burning smell. Waited for smell to disappear and tried starting the car again. Car would not start and burning smell appeared again. Got a warning on the dashboard that engine compartment was overheated and car would be ready to start after 180 seconds. Called AAA to jump start car and same behaviour was observed and car refused to start. Technician also stated that battery was completely dead. Took car to dealer and replaced main and start/ stop battery. Car still would not start. On inspection dealer observed started mechanism was shorted and needed to be replaced. After replacement, car starts fine without burning smell. Going through recall database, this issue with fire hazard from starter assembly is documented for my make, model and year but when I enter the VIN number it doesnt apply to ny vehicle VIN number. 4 year old child and me were occupants of the vehicle when burning incident happened originally.

AIR BAGS,SEAT BELTS — Filed 03/17/2025

The contact owned a 2020 BMW X5. The contact stated while the contact's mother was driving at an undisclosed speed, another vehicle attempted to make a left turn and crashed head-on into the front driver and passenger side of the vehicle. The driver's air bag did not deploy. During the impact, the driver's head hit the windshield causing it to crack. The police and paramedics arrived on the scene. The contact and the contact's mother were transported to the local medical center. The contact's mother was treated for a severe concussion and severe cuts and bruises. In addition, the contact's mother had broken glass in her hands which was removed. The contact sustained cuts and bruises. The contact's mother received additional testing because of the impact of the steering wheel on the chest, however the test results were negative. A police report was filed, however, the information was unavailable. In addition, the police officer inspected the vehicle and noticed the driver's seat belt had a lot of play, which could have contributed to the contact's mother's head injury. The vehicle was towed to the local tow yard and condemned as a total loss. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,327.

UNKNOWN OR OTHER — Filed 02/22/2025

A few months ago there was a recall on my car (some problem with starter engine) and after few month I started the engine by pressing the brake pedal and pressing the start button. But the engine did not start, I saw smoke from under the hood, then I opened the hood and saw fire near the engine on the right (driver's) side. People in the parking lot helped put out the fire with a fire extinguisher while I called 911 for fire department, they came and recorded it (fire slip -[XXX]), [XXX}., Houston, Texas, 77043 (place where it happened). I have pictures and videos this incident. We were afraid that we would die in this car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM,ENGINE — Filed 02/02/2025

The car caught on fire spontaneously when it was parked and locked. The fire started approximately 5 minutes after it was driven for 20 minutes. The fire started under the hood. There was light smoke to begin with which got worse after around 13 minutes and then flames started spewing out at the opening between the hood and the windshield. The car was fully engulfed in flames 5 minutes later with flames going as high as 2 floors. It was finally extinguished by the fire department. The car is currently with my insurance company in their tow yard.

FIRERELATED — Filed 09/25/2023

The contact owned a 2020 BMW X5. The contact stated that she parked the vehicle in her garage. No warning light was illuminated. The contact entered her home and 15 minutes later, a neighbor knocked on the door, alerting her that the garage had caught fire. When the contact opened the garage door, she saw flames. The contact called 911 and evacuated her family. There were no injuries sustained. The police and fire departments arrived on the scene, and the firefighters extinguished the fire. The fire destroyed all three vehicles in the garage and engulfed the residence. Police and fire department reports were filed. The vehicle was towed to the tow yard. The insurance company deemed the vehicle totaled. The contact later became aware of NHTSA Campaign Number: 24V576000 (Electrical System, Engine And Engine Cooling) associated with the VIN. The manufacturer was not made aware of the failure. The failure mileage was unknown.

VEHICLE SPEED CONTROL — Filed 04/23/2024

I was parking the car in a parking lot. I had my foot completely off of the gas pedal while allowing the car to roll forward into a parking spot. The car suddenly accelerates and I could not slam on the brakes fast enough to prevent damage. This was the 3rd time this type of incident occurred in this car.

POWER TRAIN,UNKNOWN OR OTHER,SERVICE BRAKES — Filed 10/31/2022

WHILE PARKING THE VEHICLE IN A HEAD-ON PARKING SPOT, THE CAR SUDDENLY ACCELERATED WITHOUT WARNING AND HIT A WALL. THE CAR THEN WENT INTO REVERSE AND SPED UP RAPIDLY UNTIL IT HIT A CONCRETE PATIO ON THE OTHER SIDE OF THE PARKING LOT. THE BRAKE PEDAL WAS DEPRESSED WITH SUBSTANTIAL FORCE THE ENTIRE TIME THE VEHICLE WAS MOVING BUT THE VEHICLE WOULD NOT STOP MOVING. THE BRAKES DID NOT ENGAGE. I DO NOT RECALL HOW THE CAR WENT FROM DRIVE TO REVERSE. FORTUNATELY, THERE WERE NO PEOPLE OR CARS IN THE PARKING LOT AT THE TIME OF THE INCIDENT. THE AUTO BODY SHOP THAT CURRENTLY HAS POSSESSION OF THE VEHICLE COULD NOT FIND ANYTHING WRONG WITH THE COMPUTER/ELECTRICAL SYSTEMS IN THE VEHICLE NOR WERE THEY ABLE TO RECREATE THE INCIDENT. I DO NOT KNOW HOW THOROUGH THEY LOOKED FOR PROBLEMS. BMW HAS BEEN NOTIFIED AND HOPEFULLY THEY WILL SEND A CREW TO INVESTIGATE. THE CAR IS CURRENTLY AT THE AUTO BODY SHOP BUT MY INSURANCE GOMPANY, GEICO, WILL HAVE THE CAR TOWED TO ONE OF THEIR FACILITIES IN A COUPLE OF DAYS. THE CAR HAS BEEN DEEMED A TOTAL LOSS DUE TO ALL OF THE DAMAGE. I HAVE BEEN HAVING ELECTRONICS ISSUES WITH THE CAR SINCE PURCHASE IN JUNE 2020, HOWEVER, THEY HAVE BEEN RELATED TO THE ENTERTAINMENT AND COMMUNICATION SYSTEMS. IN HINDSIGHT, I REALIZE THAT I HAD TWO OTHER INSTANCES IN THE PAST WITH SUDDEN ACCELERATION WITH THIS CAR. I THOUGHT NOTHING OF IT AT THE TIME BUT THEY MAY BE RELATED TO THIS LATEST INCIDENT.

ELECTRICAL SYSTEM,ENGINE — Filed 12/09/2021

Grievance/Complaint for 2020 X5 BMW Firer December 9, 2021 (49 days Owner) I was on my way to work, and I stopped at the local Bank of America drive through. While on my way, I received two (2) malfunction message saying the same thing, “ Scam Likely 1-470-781-9727; (Check Control) Vehicle key missing, Close message; Vehicle key not available or malfunctioning. Drive-ready mode cannot be started. See Driver’s Manual for further information.” (This was the message/malfunction.) I took a picture and call my salesperson, Mr. Preston at BMW of Gwinnett Place and informed him that the key was in the cup, so I tried to place it on the dashboard. I did not understand why I received a malfunction message the key missing because the car would not go anywhere without a key, however, he asked me to send the picture to him and I did. As I was getting out my X5, I began to have anxiety and became traumatized (praying, crying, yelling etc.) at this point, thinking my X5 is going to catch a fire and blow up the bank. I went into the Bank to alert them of the X5 smoking so that they can evacuate if needed. I went back to my X5 to gather as much as I could of my Christmas gifts and other Items quickly. At that time another lady was standing on the side walk and asked if she could help me removed the items from my X5.I was hysterical, and my hand was bleeding from grabbing items out the X5. My safety and others was at risk. The X5 could have been in my garage on firer and my house and family could have died and lost everything; The seat belt could have locked with me in it and I could have died. The bank ATM drive through could have blown up and all the customers could have been injured.BMW of North America insisted that I fill on my insurance because the the engineers did an observation investigation and did not see any fault of manufacture or electrical issue.The vehicle is now under the investigation of my insurance and I have not been notified of the cause at this time.