2022 BMW X5 Complaints

ELECTRICAL SYSTEM — Filed 05/01/2026

The contact owns a 2022 BMW X5. The contact stated that the vehicle failed to start immediately or hesitated while starting. The messages "Goodbye" and "Pre-ventilation" were displayed. The contact attempted to start the vehicle several times before the vehicle was able to start. The contact related the failure to the starter. The manufacturer was notified of the failure by phone. The failure mileage was approximately 40,000.

POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 09/21/2026

Starter stops working randomly and has trouble starting sometimes. This may be an issue when in traffic or at a light when the start stop feature could possibly not engage. Vehicle only has 40k miles. I took the vehicle to the dealer today and they said it is a known issue at BMW.

ELECTRICAL SYSTEM — Filed 12/01/2025

The contact owns a 2022 BMW X5. The contact stated that while attempting to start the vehicle, the vehicle hesitated while starting. The vehicle was jump-started. The vehicle was taken to an independent mechanic to be diagnosed, and the contact was informed that the starter needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 43,709.

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE — Filed 03/22/2026

xDrive all-wheel-drive has made the car slow down unexpectedly and produce a shudder, especially in slow corners and under gentle acceleration. The vehicle has also rapidly accelerated upon entering or exiting a freeway on ramp.

POWER TRAIN — Filed 09/02/2026

Front differentials failed at 31k miles. Potential for the car to lock up or break down in highway. Problem was confirmed by independent shop.

STEERING,POWER TRAIN,ENGINE — Filed 08/24/2026

Description of the Complaint: I own a 2022 BMW X5 (VIN: [XXX], current mileage: approximately 39,500 miles as of 08/24/2026) equipped with the B58TU engine, which uses a plastic oil pump (part number 11418646454) rather than a metal one. I have not yet experienced an actual failure, but I am reporting this as a precautionary safety concern based on the following: 1. On BMW's official parts reference site (RealOEM.com), the oil pump for my specific vehicle is flagged with an "Attention! Observe PuMA measure 65494813" notice, indicating BMW's own internal system has identified a known issue requiring special observation for this part. 2. I have learned that BMW Korea has acknowledged this plastic oil pump issue following a government investigation, and has committed to a full free repair program for affected vehicles in Korea. 3. I am aware of multiple reports and complaints from other B58TU engine owners in the United States regarding this same plastic oil pump issue. 4. Given that the oil pump is a critical component for engine lubrication, a failure of this part while driving — particularly during highway or long-distance travel — could pose a serious safety risk, including sudden loss of engine oil pressure and potential engine seizure at speed. I am filing this report to bring this issue to NHTSA's attention before an actual failure occurs, and to request that this be considered as part of any pattern analysis regarding B58TU engine oil pump defects in the United States. - **Year:** 2022 - **Make:** BMW - **Model:** X5 - **VIN:** [XXX] - **Mileage:** 39,500 - **Component:** Engine and Engine Cooling (or "Engine Oil System" if listed separately) - **Attachments:** RealOEM.com INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SUSPENSION,UNKNOWN OR OTHER — Filed 07/11/2025

-The component that is failing is the Transfer case which is shuddering and jerking. Yes, available for inspection. -UNKNOWN because I take the vehicle to the dealership service immediately when the issue presents due to concern, and to avoid further damage to the vehicle or delay and risk issue to the safety of myself and others -Yes, the problem has been reproduced and confirmed by dealerships multiple documented occasions. -Yes, by the manufacturer. This is a documented issue per SIB for BMW North America -Symptoms of the problem has shown prior to the failure each time in the presentation of the Shudder and Jerking. *Will be able to upload/provide service invoice images/documentation once I request and receive from dealership

POWER TRAIN,UNKNOWN OR OTHER — Filed 08/04/2026

My 2022 BMW X5 is having the transfer case star to fail. Where the symptoms currently are at is the car has a shudder in certain situations. I can feel it when maneuvering at slow speeds and I can feel it at times at speed or when on a steep hill. I bought the extended warranty for the car and the maintenance package for the vehicle. I'm at 68k miles and the shudder started before that but I am still covered under extended warranty. I have had all maintenance done on the vehicle at the local BMW dealership including all tire needs and have always replaced tires as necessary and number of tires at a time they suggest. When I took it in as the vehicle is reporting needing brakes 2 weeks ago, I mentioned the shudder and asked about tire tread on the 2 front tires. They came back with that the tires were fine in spec with the back 2 but that shudder is the transfer case. The dealer also then mentioned a couple things: - They now recommend changing the fluid in the transfer case by 60k miles due to amount of failures they are seeing (my X5 was in the dealership multiple times before an after 60k and it was never recommended). - that since it is not in the recommended maintenance for the xdrive4.0i that the car would not alert to have it changed and therefore BMW would not cover changing the fluid under the UltimateCare (service maintenance plan they sold me). That the transfer case was meant to be a for life fluid. - I asked what happens next if the fluid is not changed, that it will continue to degrade and once it fully gives out the vehicle will become inoperable - I asked does the fluid change save the transfercase and they said it seems to help many vehicles and the shudder disappears but for some it does not. - I then asked would the BMW Extended Warranty purchased cover it if it fully failed or the fluid change did not solve the shudder and I was told maybe fully, partially or not at all. Ext Warranty brochure says it is covered at platinum level I hav

POWER TRAIN — Filed 08/11/2025

The contact owns a 2022 BMW X5. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the rear of the vehicle. There was no warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the transfer case fluid needed to be replaced three separate times. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed again and determined that the transfer case fluid needed to be replaced. The transfer case fluid was replaced; however, the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 38,000.

POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 08/06/2026

The high-voltage battery system (this is a plug-in hybrid) began intermittently displaying a "battery not properly charging" warning approximately 6 months ago; the issue would resolve after plugging in and charging. On July 14, 2026, while driving, the vehicle displayed a "critical battery failure - pull over immediately and drive slowly" warning. The driver pulled over and shut off the vehicle; the warning cleared and the car appeared to drive normally afterward. This warning recurred several times over the following weeks under the same pattern. On August 6, 2026, the same critical battery failure warning appeared while driving; this time steering feel and drivetrain response were abnormal, and the air conditioning and several electronic features stopped working. Our safety, and the safety of other drivers on the road, was put at risk by the sudden loss of full vehicle control while in motion. The vehicle has been at an authorized BMW dealership for inspection since August 7, 2026; a full diagnosis is pending. Dealer service staff independently remarked that two other BMW X-series plug-in hybrids came in that same morning with the identical warning and symptoms, suggesting this may be a widespread component defect rather than an isolated issue.

POWER TRAIN — Filed 08/01/2024

Over the last approximately 20,000 miles or so I've noticed a studder/shaking of the vehicle when turning and/or accelerating at slow speeds, in particular, while the car is cold (not warmed up). I change the transfer case fluid about 5,000 miles ago and the problem did not resolve. I now see that there is a class action lawsuit against BMW for known failure of the transfer case. I would like my problem noted for the record and hopefully action by BMW.

POWER TRAIN — Filed 06/01/2026

I own a 2022 BMW X5 xDrive45e that has developed a drivetrain shudder during slow-speed, tight turns while lightly accelerating, such as when maneuvering in parking lots or making U-turns. The vibration is consistently reproducible under these conditions and is felt through the vehicle during the turn. The vehicle otherwise drives normally at higher speeds. After researching the issue, I found that many other owners have reported substantially similar symptoms involving the transfer case on BMW xDrive vehicles. My independent BMW repair shop has recommended a transfer case fluid service as the first corrective action based on the known nature of this problem. I am having that service performed and will retain all repair documentation. I am submitting this complaint because this appears to be a recurring issue affecting multiple vehicles. If the condition worsens, it could lead to drivetrain binding during low-speed maneuvers and may affect safe vehicle operation. I request that NHTSA investigate whether this is a broader defect requiring manufacturer action. I will update this complaint if the repair does not resolve the condition or if additional diagnosis identifies an internal transfer case failure.

UNKNOWN OR OTHER — Filed 06/28/2026

1. What component/system failed, and is it available for inspection? The HVAC (heating/ventilation/air-conditioning) system — specifically the A/C evaporator and its condensate drainage — in my 2022 BMW X5 (G05). It emits a recurring musty/vinegar-like odor, consistent with microbial contamination on the evaporator. The system remains installed in the vehicle and is available for inspection upon request. 2. How was safety put at risk? The odor indicates mold/microbial growth in the cabin air supply, which is a respiratory air-quality concern for the driver and passengers . A strong odor on start-up is also a distraction that draws my attention away from driving . BMW's own bulletin attributes the odor to microbial contamination on the evaporator. 3. Reproduced/confirmed by a dealer or service center? I recently scheduled a service for next Wednesday. 4. Inspected by manufacturer, police, insurance, or others? Not yet escalated to BMW corporate (no PUMA/TSARA technical case opened). Not inspected by police or insurance. 5. Warning lamps/messages/symptoms, and when they first appeared? No warning lamp or dashboard message is associated with this condition [true — odor triggers no telltale]. The symptom is the odor itself: a musty/vinegar smell fro

STEERING,POWER TRAIN — Filed 07/08/2026

On July 8, 2026, the vehicle unexpectedly stalled while I was driving in the middle lane on the I-95 highway, creating a safety concern. There was complete loss of engine power and low power to steering. The vehicle had to be towed to BMW of Peabody, Massachusetts. The vehicle had 30850 miles during the incident. During the inspection at service centre, I was informed that the safety fuse box and 12V auxiliary battery had failed which stalled the vehicle.

LANE DEPARTURE,BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE — Filed 09/15/2025

I am writing to you as a loyal BMW owner to formally lodge a serious complaint regarding a technical safety failure in my BMW X5 and the subsequent dismissive treatment I received at an authorized service center in New York. The Incident Recently, while reversing, the Driving Assistance and Parking Assistant systems failed without warning. As a result, the vehicle collided with an object, causing damage to the rear bumper. This was not a result of driver negligence, but a direct failure of the safety technology that I trusted to protect my family. Service Center Negligence Upon visiting the service center to address this life-threatening defect, I was met with unacceptable indifference. The service advisor flatly refused to investigate the system failure, stating they would only perform a standard NYC Inspection. I was given a follow-up appointment for May 5th—forcing me to wait weeks to address a critical safety defect. Safety Concerns & Demand for Replacement As a father [XXX], I no longer feel safe operating this vehicle. The integrity of the safety modules has been compromised, and my confidence in this specific car is completely shattered. Repairing a bumper does not fix a failed safety system that could have caused a much more serious accident.And when I provide all of this evidence to BMW North America they Lay to me and asked me to take my vehicle without resolving the problem and the doesn’t care about my family safety INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER — Filed 06/21/2024

I was turning right into a parking space when the vehicle suddenly accelerated and did not stop when I removed my foot from the accelerator and tried to brake. The car continued to accelerate through a low cinder block wall and did not stop until it dropped 3-4 feet off the side of the parking lot into the sidewalk/street. Fortunately I was not hurt and there were no pedestrians or vehicles in the roadway, but my car was deemed a total loss. The collision warning didn’t come in, and airbags did not deploy. I reported the incident to BMW NAmerica, who sent an inspection team to the collision center. After 7 weeks I was told that the vehicle data recorder captured ‘an incident” but did not record any information to verify that I attempted to brake, or to otherwise provide details of the incident. I was told the inspection found no mechanical issues and the all weather floor mat (installed by the BMW dealer) was installed incorrectly and must have gotten stuck on the accelerator. Furthermore, I was told that although the mat was a BMW product, it was installed by the dealer so the manufacturer was not responsible. BMW offered me a small goodwill settlement provided I sign a non disclosure agreement, which I declined to do. I’m reporting this to ensure you have a record should you receive similar reports from others. I received no written communication from BMW detailing the safety investigation.

UNKNOWN OR OTHER,BACK OVER PREVENTION — Filed 06/02/2024

On 06-02-2024, at approximately 1430 hours, I was stopped in Traffic, because of a Red Traffic light and I was the last Vehicle in line. In less than a minute later, I was hit by another Vehicle. The other Vehicle left approximately 183' of Skid Marks on the Road and I determined that Vehicle was traveling at approximately 60 MPH, before it hit me, when I was stopped in Traffic. The damage was moderate. I have the Executive Package on my BMW X5, which has a 4 way Camera system, that records an incident, when an impact occurs. After the impact, the Camera system is to record 20 seconds before the impact, as well as 20 seconds after the impact. I was not sure how to retrieve the Video, so I had to call BMW Genius and the Employee had to walk me thru the steps to retrieve the Video. The Camera system was set up for Automatic Recording, as well as Manual Recording, but no Video of the accident was ever recorded. The only Video that was Recorded and saved, was from January 13, 2024, when I was showing my Wife, how to manually record something. According to the person who hit me, he said "I could not stop, because I had a bad Wheel" and that person also included that Statement in the Accident Report. Since the Accident, I sustained lower left Back pain, left Hip pain and upper left Leg pain in the Muscles. According to my X-Ray Images of my left Hip, the Head of the Femur Bone is flattened, due to the impact sustained following the collision. According to my Doctor, I have Bone Spurs, which causes me pain when standing, walking, sitting and Complete Hip Replacement is now required, to eliminate my pain. My Lawyer suggested that I file a complaint with the NHTSA, because the Camera system should have recorded the collision and that would have given us a clear view and understanding, on what the other Driver was doing before the collision. BMW is at fault for the Camera system, which did not record the accident, when it was set up for Automatic and Manual.

STRUCTURE — Filed 04/01/2024

Sunroof unexpected exploded. No external interfaces (rocks or debris or weather) radio off sunscreen open sunroof closed. Speed was approximately 30 mph. Took car to dealership and was told sunroof don't just explode something had to hit it. They mentioned nothing about the issues with these sunroof, complaints or investigations that has done.

AIR BAGS,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE — Filed 12/19/2023

I was pulling into a parking spot. I was riding slowly into the correct position. Immediately the car went into full acceleration. Knocked the parked car in front about 8 feet, turned and knocked another car on the side. I stood on the breaks, it went another 10 feet and engine stopped. I never heard this level of acceleration of engine ever before. The airbags for me and my passenger did not open. I think this spurious acceleration is a control system defect.

POWER TRAIN — Filed 05/04/2023

The contact owns a 2022 BMW X5. The contact stated while entering into a parking lot, the vehicle accelerated on its own without any warning, causing the contact to strike some plants in the parking lot and causing damages under the vehicle. No one was injured. A police report was filed. The dealer was contacted but did not diagnose the vehicle. The manufacturer was contacted and sent a tech to diagnose the vehicle that stated no failure was found. The failure mileage was 10,000. The VIN was not available.

ENGINE — Filed 04/27/2023

While driving I smelled a burning smell and within minutes noticed Smoke coming from under the hood. Pulled over and popped the hood and there was a fire behind the battery into the firewall area. Was out out with fire extinguisher by tow truck driver.

VEHICLE SPEED CONTROL,BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE — Filed 03/11/2023

I was trying to park my car on March 11, 2023 at noon, and I noticed a sudden uncontrolled acceleration even when my foot was off the accelerator pedal. Parking collision front sensors failed to provide an early warning, and automatic emergency brake did not engage leading to a minor collision with the vehicle parked in front. The situation occurred so rapidly that I did not have enough time to react quickly and apply brakes. I managed to apply brakes to avoid a serious incident, but it was not quick enough to even avoid this minor collision. I have reported this to BMW USA, however the car has not been inspected by a dealer or an independent service center after the incident. There were no warnings displayed prior to this incident, however I have had consistent issues pertaining to the operation of front sensors. I had BMW certified dealer inspect front sensors, and according to them the sensors do not provide an early warning as per the design but they have adjusted the sensitivity. The adjustment did not improve the situation, and I provided that feedback to the service center as well. The sensors did fail at twice prior to this incident, and the dealer inspected that as part of sensor sensitivity adjustment. I drove this vehicle to the BMW certified dealer more than twice to have the front sensors and other things inspected prior to this incident. Nevertheless, this uncontrolled acceleration is something that I have never experienced before, and I am traumatized to even drive this vehicle comfortably. All the automated systems designed to prevent or avoid collision did not engage leading me to not trust anything.

ELECTRICAL SYSTEM — Filed 03/08/2023

The contact owned a 2022 BMW X5. The contact stated that while driving at unknown speeds in self-driving mode, it crashed into the rear of a disabled Ford Utility van. The contact sustained a cracked clavicle and medical attention was provided. A police report was filed. All the air bags were deployed. There was no reported fire. The vehicle was towed to an impound yard. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 18,000. The insurance deemed the vehicle a total loss.

TIRES — Filed 07/26/2022

The Pirelli P-Zero tires that came factory equipped on my 2022 BMW X5 have experienced 3 separate sidewall failures in less than the first 20,000 miles on the vehicle. The tire sizes are staggered, 275/40r21front and 315/35r21 rear. The first instance occurred on 07/26/2022, traveling down the interstate, when both passenger side run flat tires blew out the sidewalls at approximately 15,000 miles. The sidewalls blew out to a point that the “run flat” functionality of the tire was compromised, requiring BMW to tow the vehicle to the nearest BMW dealership. At the time of the failure, a alert immediately appeared on the vehicles screen informing of the loss of tire pressure. The next incident occurred on 10/08/2022, at 19,900 miles, I was in my garage, showing my vehicle to a friend from out of town, when I noticed a large slit in the sidewall and a bulging section around the slit on my front driver’s side tire. The tire is currently still pressurized, but is not safe to continue operating.

VEHICLE SPEED CONTROL,SERVICE BRAKES — Filed 03/01/2022

The contact owns a 2022 BMW X5. The contact stated that his foot was caught on the mat and the vehicle accelerated. The contact had to engage the parking brake to stop the vehicle. There were no warning indicator lights illuminated. While the vehicle was idling in the driveway, the vehicle lunged forward, crashed into an unknown vehicle and the vehicle drove into the garage. There was no reported fire but the fire department was on the scene. There were no reported injuries. A police report was filed. The vehicle was towed to an independent mechanic. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 1,000.