2023 Chevrolet Bolt Ev Complaints

SUSPENSION — Filed 06/10/2026

While driving a 2023 Chevrolet Bolt during a turn maneuver, one of the two bolts (nearest the driver) holding the lower control arm (to the vehicle on the front driver side) sheared completely. An inspection of the joint suggests a fatigue failure likely due to inadequate factory assembly clamping force (pretension). Because the joint lacked the required factory torque, the joint interface slipped under normal operational loads, shifting cyclic shear and bending forces directly onto the bolt threads and shank—loads the fastener was not designed to carry alone—resulting in a fatigue fracture. The sudden failure of a primary front suspension control arm fastener while the vehicle is in motion is a safety hazard. It causes steering instability and risks a loss of vehicle control. The problem was confirmed and repaired by an independent service center/mechanic who replaced the control arm sub-assembly. The sub-assembly has been retained and is available for inspection upon request. The vehicle and failed component have not yet been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps, dashboard messages. We had noticed the tire was rubbing on the wheel well during certain maneuvers for months beforehand, but we thought the wheel well liner was sagging. In hindsight this was due to the control arm not being firmly held by the bolt. When the bolt sheared my wife reported hearing a loud pop, the vehicle was still drivable but unstable, as soon as we realized something was severely wrong we took it slowly to the nearest mechanic where they repaired the problem.

STEERING — Filed 09/15/2025

Steering rack failure, does not return to center most of the time. Every once in a while it will. Loud clunking in steering, started right around 36k mile warranty expiration, but I didnt know what it was so did not report it right away.

ELECTRICAL SYSTEM,VISIBILITY/WIPER,BACK OVER PREVENTION — Filed 05/01/2026

Vehicle infotainment system on 2023 Chevrolet Bolt completely stopped functioning in May of May of 2026. Screen/radio/bluetooth and associated components had no functionality, including backup camera, safety warning features, etc. Dealership confirmed that the system needed replacement entirely and was non-functional. Vehicle was not inspected by any other parties but it was confirmed by the dealership that this is a "common issue" for Chevrolet vehicles, even newer models. There were no warnings prior to the issue - the system simply did not work one day and never functioned again.

STEERING — Filed 03/31/2026

The steering has become harder to turn and will not return to center after turning a corner. When driving the steering wheel will stay in the position you have turned it to. I feel like this is dangerous and a safety risk especially at highway speeds. I have taken it to my local Chevrolet dealership and they said the rack and pinion steering is bad and needs to be replaced. $2365 parts and labor and realignment. The vehicle had 50058 miles on it when I noticed it. It now has approx. 52,500 miles on it. There were no warning lamps or safety messages.

STEERING — Filed 04/13/2026

I bought my 2023 Bolt EV new on Dec 2024. Around Jan 2025 I start hearing clicking behind the steering wheel when I turn to make parking maneuvers. By April 2025 the clicking is loud and a common occurrence. The steering no longer returns to center and it is noticeably hard to turn the steering wheel. I brought it to the dealership and was repaired under factory warranty for being a faulty part. The issue, which was a leak causing the steering rack to bind, was fixed. See the attached Chevrolet dealership documentation for further details. I have not noticed any further issues after driving for month after repairs were done.

ELECTRICAL SYSTEM,LANE DEPARTURE,FORWARD COLLISION AVOIDANCE — Filed 04/19/2026

Without any warning or physical impact, the central infotainment screen completely blanked out and suffered an irreversible hardware failure. This screen acts as the mandatory display terminal for the vehicle's rear-visibility backup camera, as well as the audio generation module for the vehicle's driver alerts. Because of this component failure, the vehicle is in direct non-compliance with Federal Motor Vehicle Safety Standards (FMVSS): 1.FMVSS 111 (Rear Visibility): The vehicle completely fails to display a rear-view image when shifted into reverse, creating an immediate blind-spot hazard for pedestrians. 2. FMVSS 101 (Controls and Displays): All critical audible safety alerts, pedestrian alerts, and driver warning chimes have been entirely silenced. The manufacturer (General Motors) and the authorized franchise dealership (F.H. Dailey Chevrolet) have acknowledged the failure and have the part on backorder, but refuse to fully cover the safety restoration under warranty or provide a temporary loaner vehicle. This forces the primary driver, a [XXX] senior citizen, to choose between total isolation or operating a hazardous, federally non-compliant vehicle. This appears to be a systemic manufacturing or design defect inherently tied to the internal HMI module architecture on the late-model Chevrolet Bolt EV platform, rather than individual wear and tear. A formal investigation is requested to mandate a safety recall and enforce full manufacturer accountability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING — Filed 05/13/2026

The steering wheel does not return to center after turning while driving the car (unlike every other car). It has been reproduced by an independent service center. There are no error codes or warnings. This is a continuous problem that always happens and makes steering the vehicle more difficult.

POWER TRAIN,ELECTRICAL SYSTEM — Filed 03/12/2026

Recurring electronic transmission shift control failure on a 2023 Chevrolet Bolt EV. The Electronic Transmission Shift Control Pushbutton Circuit Board (GM part designation K212) has failed twice within approximately 9,300 miles. First failure occurred at approximately 45,695 miles in July 2025. The dashboard displayed a malfunction indicator and a "Service Transmission" warning. Diagnostic trouble code U18D2 was set: Lost Communication with Transmission Range Selector Control Module on the Powertrain Sensor CAN Bus. The selling Chevrolet dealer replaced the K212 pushbutton circuit board and reprogrammed the HPCM2 module. Second failure occurred at approximately 54,969 miles in March 2026, only about 9,300 miles after the first repair. Same diagnostic code family, including the identical U18D2 code, plus U0076, U18C6, and U240E. The same dealer replaced the same K212 pushbutton circuit board a second time. The repair was processed under manufacturer warranty. Safety risk: when the failure occurs, communication with the transmission range selector is lost intermittently and without warning, leaving the vehicle unable to be reliably shifted into Drive, Reverse, or Park. This creates a clear hazard in traffic, parking lots, and on inclines. The failure mode is sudden and the warning lamps appear only after the malfunction has begun. The component is located beneath the center cup holder area. There is no visible waterproofing or moisture isolation around the circuit board, despite its location directly under a known liquid exposure zone. The failed component from the second repair was reportedly shipped back to GM by the dealer. The vehicle is available for inspection. The failure has been confirmed twice by an authorized Chevrolet dealer.

UNKNOWN OR OTHER — Filed 04/21/2026

I have a 2023 bolt ev. Right where the odometer it started to go black. I touched it and made it worse. Right now it is not getting bigger but I am worried it will get worse. There is about 75,000 miles, I can't tell miles without the odometer. What would cause this? How do I fix this? Would I be able to resale it like that? How much would it be to get it fixed? I need the car to last intil I can buy a Slate Automotive pickup. Please see attached picture. Thank you! Is there another way to read the miles? Thank you!

STEERING — Filed 04/06/2026

The steering sticks when making turns and does not return to center. This causes the steering to drift on the highway and reduces the ability to steer in a straight line. I have not reproduced or confirmed it with the dealer. No inspection and no warning lamps. This issue occurs for a large number of Chevrolet Bolt owners.

ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE — Filed 04/02/2026

While driving at approximately 45 mph, the regenerative braking feature of the vehicle suddenly failed, and also generated a master caution light on the dashboard display. This is the second time this has happened while driving and resulted in a sudden, alarming change in vehicle dynamics. Regenerative braking is the normal operation regime of the vehicle, with the traditional mechanical-hydraulic brake pedal available for added braking, as demonstrated by the Chevrolet dealership during a test drive and confirmed with the vehicle manual. Furthermore, the vehicle will no longer shut itself off and could pose a fire risk when stored in a garage, parking deck, other vehicles, etc. These issues happened in November 2024. The car was returned to the dealer for warranty repair. Even after extensive repairs to the electrical system, the car has repeated the alarming failure mid-drive. This indicates that there is a serious problem with the electronic and poses a serious safety risk.

STEERING — Filed 03/25/2026

Steering, Rack and Pinion is failing after 44k miles, Steering gear is binding internally

STEERING — Filed 03/16/2026

Steering wheel does not return to center, requiring driver input to do so. Force needed to turn the steering wheel continued to increase throughout the past year, getting abnormally difficult and unlike any other vehicle. Had the steering rack replaced, which corrected the problem.

STEERING — Filed 01/26/2026

Steering wheel fails to return to center after turns — potential steering gear defect 2023 Chevrolet Bolt EV steering wheel fails to return to center after completing turns, particularly at low speeds. Steering requires manual input to re-center the vehicle after every turn. No warning lights or audible alerts. The issue is not attributable to alignment, tires, or tire pressure, as I have had new OEM-spec tires installed and an alignment performed without any improvement to the steering. I brought the vehicle to the dealership to address this safety concern. They stated unable to replicate the issue and sent me away without performing repair. The dealership charged me for an alignment but provided only post-alignment figures — no before measurements, making it impossible to determine whether any corrective action was actually taken or whether the alignment was a contributing factor. This is a safety concern as it requires constant driver correction after every turn, increasing risk of overcorrection, unintended lane departure, and delayed response in emergency situations. Condition is hazardous in low-speed environments such as parking lots, intersections, on/off ramps, and residential streets where frequent turns are made and rapid corrections may be necessary. Issue is not isolated to my vehicle or model year. Owners of 2017-2019, 2022, and 2023 Chevy Bolt EVs have reported identical symptoms across multiple owner forums, with hundreds of documented complaints. Community research and independent mechanic diagnoses consistently identify the steering gear (rack and pinion) as the root cause, with internal binding cited as the failure. GM's own service manual includes a diagnostic path for "Poor Return of Steering Wheel," confirming GM is aware this condition exists. No recall or service bulletin issued addressing this widespread concern despite years of owner complaints spanning all Bolt EV model years. Request that NHTSA investigate and consider issuing a recall.

UNKNOWN OR OTHER — Filed 02/27/2026

The Chevy Bolt steering wheel has a skip track and previous track button mounted to the left-rear side of the steering wheel. These buttons often become unresponsive for extended periods of time (up to 30 minutes) when a media device is connected. When pressed, they will display an error on the instrument panel screen that says “Action Unavailable While Indexing”. Although media controls are not explicitly safety related, the frustration caused by these unresponsive buttons can cause the driver to become distracted or look for unsafe methods of adjusting the media playback that the buttons are supposed to perform.

STEERING — Filed 01/06/2026

Steering is failing at only 43,800 miles like many others. It is failing to return to center which makes it dangerous to drive, it doesn't come out of a turn. It is clicking and fails to return to center.

BACK OVER PREVENTION — Filed 12/08/2024

The backup camera is the vehicle works intermittently. In fact, due to the defect of the camera, I hit a wall as it shut off and I hit a wall. Upon bringing to the dealer to have it replaced, the dealership admitted that it was a faulty. They replaced with another faulty camera that works worse than the previous replaced one. This is a dangerous situation that will hurt someone.

VEHICLE SPEED CONTROL,SERVICE BRAKES — Filed 11/10/2024

I was approaching an intersection at a light that had turned red. I slowed down to stop but accidentally bumped into the car in front, 2 mph (approximately), no damage, not even a scratch. I put the vehicle in reverse and gently tapped the accelerator but it instantly raced backwards at full as though the accelerator pedal had been depressed to the floor. I tried to brake but it would not stop and smashed into the vehicle behind. It was scary and traumatizing. Sudden acceleration in reverse. I hope there are diagnostics that will corroborate what happened because I am certain to the highest degree that this vehicle is defective.

ELECTRICAL SYSTEM,SEATS,UNKNOWN OR OTHER — Filed 05/31/2024

I was sitting in the passenger seat of my new 2023 Chevy Bolt EV while parked at a convenience station. The vehicle was on and not hooked up to a charger. I smelled something burning and quickly thereafter I saw smoke coming from under the driver side seat. The driver exited the vehicle and looked under the seat. The driver attempted to put out the fire with his hand and the carpeting under the seat. The fire got bigger. I ran to the closest extinguisher and pulled the pin to extinguish the fire. It was out for several seconds before re-igniting again. Another round of extinguisher foam was released and the fire was put out. I reported the damage to the dealership, the car manufacturer and my insurance company. I towed it to the dealership where it has been sitting since 6/1/24. Nothing further has been done since then. The dealership refuses to assess the vehicle and to date the manufacturer has not sent any inspectors to diagnose the reason of the fire. As A matter of fact my insurance company, the dealership and the manufacturer all advised me to get and pay for my own inspection from a 3rd party inspector which I am working on scheduling now.

AIR BAGS,FORWARD COLLISION AVOIDANCE — Filed 05/16/2024

Electric pole broken onto the street and hit the car, cause severe damage to the front-left-corner on the Chevy Bolt EV 2023. The airbags did not deploy. Safety of the driver and infant was diminished greatly.

SERVICE BRAKES — Filed 07/07/2023

2023 Chevy bolt has a hand 'regenerative brake'. I was using it while driving in traffic. My speed was around 40 mph when the car in front of me abruptly stopped. The distance between us was approximately 30 ft. I immediately switched from hand brake to foot brake and the pedal felt soft and there was a delay in response to foot brake. I rear ended the vehicle in front of me causing damages to both vehicles. This had happened in August 2023. I called the manufacture to let them know what happened and they told that they will pass the information. I made a call to them in December of 2023. My vehicle was not inspected for this issue as I am not sure who can help me with this problem. There were no warning lights before the accident. Ever since the accident I have tested switching from 'hand brake' to foot brake and always feel a softer pedal and a slight delay in response. I believe this issue was a main factor for the accident as in my over 10 years of driving experience I have never had an accident before. I believe that the 'hand brake' is using electric motor while foot brake uses regular hydraulic system and they are not adjusted properly when are switched in between.

AIR BAGS,SERVICE BRAKES — Filed 12/19/2023

The contact rented a 2023 Chevrolet Bolt EV. The contact stated that while driving approximately 30 MPH the driver depressed the brake pedal but the vehicle did not stop and crashed into the rear of a second vehicle. The contact indicated that during the crash the vehicle was low on electrical charge and was being operated in the "One Pedal" mode and the the air bags did not deploy. The rear passenger seated on the passenger side sustained an injured neck which did not require medical treatment. A police report was taken at the scene and the vehicle was driven away from the scene. The cause of the failure was not determined. The rental company was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was unknown.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM — Filed 12/20/2023

Sudden rapid acceleration of car while parking vehicle on December 20, 2023 at approximately 2:00pm. The sudden rapid acceleration caused the vehicle to jump a curb and hit the base of the light pole damaging the right front of the car. Car was towed to the dealership and is currently there. If the car had not hit the base of the light pole, the car could have continued on into a driving lane possibly striking another car or pedestrian. To date , 12/31/23, the car has not been inspected to my knowledge. There was no warning lamps or messages. While reaching down to push the Park button, the engine, which is normally quiet, made a loud whirring noise and then lurched forward.

ELECTRICAL SYSTEM,AIR BAGS,STRUCTURE — Filed 11/17/2023

On 11-17-23 someone rear ended me making me lose control of the vehicle and getting off the road into the woods and eventually hitting a tree, the airbags did not deploy, the car is equipped with OnStar system from Chevrolet as a safety feature in which as soon as there is a collision I supposed to get a call from an advisor so they could call an ambulance and a towing service, it's included in my monthly payment, but that did not happen, no one called me to check on me also the braking system should have prevented me from hitting a tree, the safety system failed

EXTERIOR LIGHTING — Filed 11/28/2023

I have a 3 month old Chevy Bolt EV. I like this car. I rarely have any accidents. I am a safe driver. I was hit hard from behind driving while stopped. I was driving on a crowded freeway in Austin TX in stop and go traffic. This was a hard hit that broke the rear bumper and bent the rear frame of the car. The Chevy Bolt rear brake lights are only low on the bumper and not in the expected tail light location. There is a pattern of this accident with this car. I am concerned that this is a usual event in a car with rear brake light issues. I think the lack of visibility of the rear brake light contributed to the accident. This is out of my control. This should be fixed for safety before more accidents happen.