2024 Chevrolet Colorado Complaints

ELECTRICAL SYSTEM,STRUCTURE — Filed 09/21/2026

In July 2026, I received a message on my truck's dashboard to "Service Latch System". Neither of my passenger doors would lock. I brought it into the Hendrick Chevrolet Service center, and they told me the actuators on both passenger side doors failed. Even though the truck is only 2 years old, they said I was past the mileage on the 3-year warranty and I would need to pay out of pocket for replacing the actuators. They replaced them. Then this week, week of September 21, 2026, the driver side door locks stopped working. They are now telling me the actuators on that side have now failed and I need to pay out of pocket for it again. I am concerned there is an underlying defect in the vehicle not being addressed.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 09/11/2024

Love my 2024 Chevy Colorado and researched every aspect about it prior to purchase....accept the REQUIRED Onstar subscription to enable the handsfree "speaker button" @ RH side of steering wheel for phone, navigation, etc. I was finally made aware of a promotional that came w/ the truck by an Onstar rep that only worked for one month, which no one @ the dealer, sales rep, finance, etc told me about. Once function quits, using an Android phone, it is impossible to utilize, requiring physically handling the phone to initiate and end calls.....which is unsafe and illegal in my state. It is aggravating to me that one should have to pay 45.00 a month for a great feature that is factory installed on the steering wheel when my 2015 Ford worked for free for the entire time I owned it. As a safety item it should be free and could lead to issues for others if they opt out...distraction BAD

UNKNOWN OR OTHER — Filed 08/28/2026

I bought this vehicle late June 2026 and it is currently September 1 2026 and last week I encountered a check engine light. Its already having coolant issues. Way too early for something like this. Only 64,000 miles.

STRUCTURE — Filed 08/01/2026

The windshield cowl and trim pieces keel breaking. If I didn't keep an eye on them they would just end up flying off causing road debris or projectiles

ENGINE — Filed 08/01/2026

Engine cooling system has a known leak. It is rather expensive out of pocket and although there is now a tsb the tsb does not cover the danger of overheating an engine and being stranded on the side of the road. Also the coolant leaking causes an unseen hazard by polluting water supplies with one of the more known toxins to the water and environment.

ELECTRICAL SYSTEM,SERVICE BRAKES — Filed 08/28/2026

While driving home multiple lights,messages and sounds came on the dashboard. I stepped on the brake and there were no brakes. I put vehicle in neutral and pumped brakes a few times. I was not traveling that fast so the vehicle stopped before I hit the person in front of me. I drove 10 mpg with my hazards on to the nearest gas station. I called Chevy service and they sent a tow truck N/C to bring to the dealer.

ENGINE — Filed 07/16/2026

I was told that my vehicle has a bent exhaust valve, which has caused irreparable damage to the engine and requires a complete engine replacement. The dealership could not determine what caused the valve to bend, but they indicated that it could potentially be a manufacturing defect, although they could not confirm that. My vehicle has now been at the Chevy dealership for more than 30 days, and I was informed that there are currently no replacement engines available from the factory due to a shortage. Given that this appears to be a known parts shortage, I assume other owners of the same make and model may be experiencing similar issues, although I cannot confirm that. The vehicle has approximately 10,000 miles on it.

SERVICE BRAKES — Filed 07/07/2026

Was on a trip and on the highway home the service break lights came on. By the time we got home(less than 200 miles) the breaks where scraping the calipers. Truck only had 25,586 miles on it when they picked it up to take to the shop. Dealership had to replace the break pads, calipers and rotor on the front driver side.

SERVICE BRAKES — Filed 05/23/2024

I purchased this truck new in March of 2024, in May I was at a Starbucks drive-thru and lost all brakes. While slowing down at the window the pedal went to the floor and my dash light up like a Christmas tree. I pulled into a parking spot and shut the truck off for about 5 minutes. When I turned the truck back on the lights were gone and the truck seemed fine, so I drove home. The next day I was picking up my kids from school when in the pickup line the same issue happened. I lost my brakes, the dash lit up, and the truck started rolling forward in the pickup line. I had to push on the brake pedal as hard as I could to make the truck stop. I called the dealer and had the truck taken there. The truck was there for several days and I was told the master cylinder and brake control module were replaced. I’m reporting this now, because I saw that this is part of a larger issue being reported and I wanted my experience memorialized to help others.

ELECTRICAL SYSTEM — Filed 06/23/2026

The turn signal has an intermittent condition. When I put the right turn signal indicator on to signal a right turn, after the turn is completed and the turn signal stick returns to the off position my left turn signal with signal a left turn flashing approximately 2-3 times before turning off. I took it to the local Chevrolet dealer maintenance shop and they told me the replaced the turn signal stick, however a few days later the same problem occurred again. I have also learned online that other owners have had the same issue with their Colorado pickup trucks also.

ELECTRICAL SYSTEM,EXTERIOR LIGHTING,UNKNOWN OR OTHER — Filed 06/03/2026

The turn signal system intermittently malfunctions. When using the turn signal, the auto-cancel function sometimes activates the opposite signal, and at times the stalk does not stay engaged when attempting to signal. This creates a safety risk because surrounding drivers may receive the wrong turning/lane-change indication or no indication at all. The issue has occurred intermittently while driving and has been presented to Cox Chevrolet in Bradenton, Florida multiple times. Cox Chevrolet has verified turn-signal over-cancel and performed prior repairs/programming. However, the issue has not been entirely resolved and continues to occur intermittently. No crash or injury has occurred, but the condition creates a risk of collision during turns, merges, and lane changes

POWER TRAIN,VEHICLE SPEED CONTROL,FUEL/PROPULSION SYSTEM — Filed 06/03/2026

Vehicle intermittently lunges forward during the 2nd-to-1st downshift, even while the brakes are being applied. When this occurs, the vehicle unexpectedly accelerates or surges forward slightly, travels farther than anticipated, and feels similar to being bumped from behind. Because the condition occurs at low speeds, often in tight areas such as parking spaces, stop-and-go traffic, or before a crosswalk, it creates a risk of collision with pedestrians, vehicles, or objects. The issue has been reported to Cox Chevrolet in Bradenton, Florida multiple times, but continues to happen.

UNKNOWN OR OTHER — Filed 05/28/2026

My dog and I were headed to Home Depot on [XXX] when without any warning there was a very loud boom. My first thought was that we had been shot at. Once I gathered myself I realized the sunnroof glass had exploded. I rarely open the sunroof but do on occasion have the shade open, luckily it wasn’t open or my dog and I would have been sprayed with the glass which could have caused serious eye injury and potentially a crash. I’ve had 2 Chevy dealers tell me that is not a warranty issue that it was likely caused by a rock being thrown up. I do not believe this was the case. The closest vehicle was some 500 feet in front of us. Because it was such a violent explosion I believe it was a pressure explosion. I am also very surprised that the glass is tempered and not laminated. I have insurance so I’m not concerned with getting it repaired. I just want you to know I think it a very serious issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM,SERVICE BRAKES — Filed 11/07/2025

The contact owns a 2024 Chevrolet Colorado. The contact stated that while driving on several occasions at various speeds, and the brake pedal was depressed the pedal remained floored. The contact stated that the vehicle eventually slowed down on its own and came to a complete stop. The was towed to a dealer where it was diagnosed that the master cylinder needed to be replaced. The vehicle was repaired but the failure reoccurred a little over a month later. The vehicle was towed back to the same dealer where it was diagnosed that the battery was dead and the battery needed to be replaced. The vehicle was repaired but the failure reoccurred approximately 17 days later. The vehicle was taken to the same dealer where it was diagnosed that the drivers door wire harness needed to be replaced due to an electrical issue that killed the battery. The vehicle was repaired but the failure reoccurred approximately four months later. The vehicle was towed to the same dealer where the vehicle has yet to be diagnosed as of yet. The manufacturer notified of the failure. The failure mileage was approximately 8,400.

UNKNOWN OR OTHER — Filed 05/14/2026

Check engine light came on and the dealership said it was because the coolant was low due to the radiator hose leaking. I was told by the actual mechanic that they’ve had to do a lot of radiator hoses and that it is a known defect with the Colorados and the traverses but that GM hasn’t done a recall on them yet. That is what brings me here. My truck is only 2 years old and this shouldn’t be happening right now. Thank you for taking the time to review this and I hope GM addresses the matter promptly.

UNKNOWN OR OTHER,ENGINE — Filed 05/06/2026

The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 35k miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and then they would get to it in 7-10 days. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. You can find 1000's of examples online and if you can pull GM repair data, I'm sure you'll find 1000's more.

ENGINE — Filed 05/01/2026

Truck has 36,669 miles check engine light came on and was idling loud, after being looked at my a Chevrolet dealership came back a faulty radiator hose, and coolant was leaking. Too new of truck for this kind of problem

SERVICE BRAKES — Filed 05/02/2025

The vehicle is registered to me; my mother was the driver at the time of the failure. At ~2,963 miles, the truck developed intermittent check engine and ABS warning lights. The dealer pulled DTC C058A (brake system control module) and P25A2. Per GM bulletin PIT6012A, the battery was replaced and a brake plunger motor sensor learn was performed. The same codes returned within weeks. The dealer then diagnosed internal failure of the brake master cylinder and reservoir, documented the vehicle as "unsafe to drive," and replaced both under warranty. The truck sat at the dealer over six weeks due to a nationwide parts backorder. Repairs were completed April 4, 2025. On May 2, 2025, at ~6,500 miles, the driver was traveling downhill on a city street in the rain at roughly 20 mph. The brake pedal suddenly became hard and resistant. Despite full-force pedal pressure, the vehicle could not be stopped. It entered an intersection, struck another vehicle, then struck a tree. Front and side airbags deployed; the vehicle was totaled. The driver sustained a concussion, broken finger, and severe back and knee injuries, was transported by ambulance, and required months of concussion treatment including vestibular therapy. The hard, resistant pedal is consistent with failure of the electronic brake boost assist (eBoost) system, leaving only unassisted hydraulic braking (roughly 4–5x normal pedal force). This matches other owner reports and the class action in Barron et al. v. GM LLC, which cites defective master cylinders with a missing internal cartridge seal on the same platform. The vehicle is no longer available for inspection. The driver was concussed with significant short-term memory loss at the scene; statements in the police report may not reflect the mechanical failure. Full police report available on request (exceeds 10 MB limit).

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 03/05/2026

there have about 4 incidents where my vehicle has engaged the automatic emergency breaks while I’m driving, even though there are no cars around me close enough to cause that reaction. called 911 on most recent incident to get medical evaluation to check chest from seat belt sudden locking

AIR BAGS,SEAT BELTS — Filed 10/14/2025

The contact owns a 2024 Chevrolet Colorado. The contact stated that while his employee was driving at 55 MPH, the vehicle hit a deer, but the seat belt did not hold the driver in place. The contact stated that the driver's left side of her chest hit the steering wheel, she hit her head hit the windshield, and when the seatbelt retracted, the driver was pulled back to the seat with force. Additionally, the contact stated that the lap band of the seat belt tightened during the impact and bruised her lower stomach. The air bags did not deploy. The vehicle was knocked into the ditch, and then the vehicle was steered to the side of the road. Medical attention was needed. A police report was filed. The vehicle was taken to a dealer, where it has not been diagnosed as of yet. The manufacturer was notified of the failure. The failure mileage was approximately 14,152.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 05/16/2025

I was driving the truck and first I got a "Software Update Needed Vehicle must be parked and off" this was followed quickly be a "low tire pressure alarm" 3 times in a short distance then I got a message "Antilock brake issue do not drive over 62 MPH or vehicle may not stop" then the brakes began to randomly slam on and release and smoke began to come out of the air vents. The next alarm was "ESV Shutting down " and I lost power steering and brakes; I tried getting the vehicle off the road out of the traffic lanes and the smoke was rapidly increasing in the cab then the engine shut down and I did my best to get the truck out of the traffic lanes and flames started coming from under the hood. A man stopped to help me out of the truck and by then the engine compartment was fully involved quickly and spreading into the interior of the cab. This all happened on country roads at about 40 MPH. I went to the medical center 2 days later as I was still having problems breathing from all the smoke. This was a new truck I bought in early November and only had 6900 miles on it.

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 03/15/2025

While driving in heavy and slow moving traffic at approximately 15 mph, the vehicle in front stopped. The forward collision and automatic emergency braking failed to activate. These safety features are not a replacement for active driving attention, but if they properly function and activate, they could have prevented the rear end collision that occurred.

FORWARD COLLISION AVOIDANCE,LANE DEPARTURE — Filed 01/14/2025

1) All the sensors on the truck relating to the auto emergency breaking, pass sensors, cruise control ETC are malfunctioning, truck was at 10,000 miles at the time and brand new. 2) This feature contributed to an accident on Jan 14 2025. I could not see because of the sun and rear ended the car in front of me. 3)The DTC report on the truck came back and stated 6 errors relating to the systems and sensors to include a data memory loss. 4)Took in for servicing at the dealership and they refused to touch the issue. GM is inspecting the truck Feb 13. 5) There were warning indicators however I though it had to do with ice blockage from a snow storm. That morning I cleaned all the cameras off and did not immediately notice it and assumed it went away. It seems the the warning does not immediately come on takes approximately 1-2 minutes. There is no differentiating a software-servicing issue with a camera blockage.

SERVICE BRAKES, HYDRAULIC,FORWARD COLLISION AVOIDANCE — Filed 01/09/2025

The contact owns a 2024 Chevrolet Colorado. The contact stated while driving 10 MPH and approaching a stopped traffic, the contact stated that the sun temporarily blinded his vision of the roadway. The contact depressed the brake pedal, but the vehicle failed to respond and crashed into a stopped motorcycle, causing the motorcycle and the motorcyclist to fall to the ground. Additionally, the contact stated that the vehicle was designed with the Forward Collision Avoidance: Automatic Emergency Braking (AEB) system, which failed to engage as designed. The motorcycle rider was able to escape the scene, while the contact's vehicle continued to move forward and to drive over the rear end of the motorcycle. The motorcycle was damaged and could not be ridden. The motorcyclist sustained physical pain and received first aid from the ambulance; however, the motorcyclist declined medical assistance and was picked up by his girlfriend. The contact did not sustain any injuries. The air bags did not deploy. The check engine warning light illuminated after the crash. The contact stated that the front end and the undercarriage of the vehicle were damaged. The contact was able to drive the vehicle from the scene. A Police report was filed. The vehicle was taken to the dealer's Auto Body Shop, where an assessment of the vehicle damage was being performed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 4,700.

ELECTRICAL SYSTEM — Filed 09/18/2024

My teenage son was involved in an accident because of distraction caused by his he dashboard. Upon taking right turns with the right blinker, the LEFT blinker would subsequently illuminate for at least 4 blinks. Additionally, the CHECK ENGINE light was also illuminated. The vehicle only had less than 90miles on it. As he took a right turn at a 4 way stop, he was distracted by the left blinker and attempted to turn off the blinker manually which caused him to steer into the curb which them caused him to lose control and his a brick mailbox. $8500 worth of vehicle damage and $1500 worth of mailbox replacement damage was caused. Chevrolet dealership service dept indicated that blinker switches in new Colorados have been malfunctioning and they are replacing the blinker switches due to defect. After collision repair, I will take the truck jn to get switch replaced AND inspect why the check engine light is illuminated.