2016 Chevrolet Malibu Complaints

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 07/19/2026

“Steering assist is reduced, drive with care” is showing up for a couple second and disappearing. When that happens my car seems to shut off and the steering wheel stiffens and pull to either the left of right side. All this happens while driving. After the 3rd time of it happening within 10min, my gas fuel level dropped but when back up to the “original” level

STEERING,WHEELS — Filed 02/27/2026

Rear steering knuckle and control arm knuckle.my car moves side to side. I have replaced everything in the rear end. I just recently bought this car.

UNKNOWN OR OTHER,SERVICE BRAKES,ENGINE — Filed 06/19/2026

Vacuum pump failure causing hard brake pedal which made near to impossible to brake safely and properly that lead to timing chain issues

SERVICE BRAKES,ENGINE — Filed 06/11/2026

The brake vacuum pump broke, causing my brakes to go rock hard and pieces fell down into the camshaft, causing engine damage

ENGINE — Filed 02/08/2026

My car started overheating on my way home. I pulled over to find that there is a hole in my lower radiator hose, which was caused by the lower radiator hose being rubbed against the belt that is turned by the water pump. I had my wife and child bring me coolant on the side of the road where I was broken down. I eventually was able to get my car to my brothers but it required multiple stops and refilling of coolant. Once we got the car jacked up and the lower radiator hose replaced, we found the bottom of the radiator is loose and is pushing the lower radiator hose against the belt that rubbed the hole into the lower radiator hose. I then had my car towed to Dan Cummins in Georgetown Kentucky, located at 1470 Cherry Blossom Way, Georgetown, KY 40324. The mechanic drove my car that I had towed to the shop which damaged the new radiator hose that I had just put on the car. Dan Cummins of Georgetown Kentucky, who is an authorized Chevrolet Dealership, was informed (by me) that some 2016 Chevy Malibu's have been recalled because of a faulty lower radiator mount causing the lower radiator hose to push against the belt which causes the lower radiator hose to get a hole and leak. Dan Cummins suggested that I report my issue because my VIN is not covered by the recall. Authorized Chevy dealer Dan Cummins also suggested that I take my car elsewhere to be repaired while refusing to cover the damage they caused to the brand new lower radiator hose that I had purchased and put on the car. I would like for my Chevy Malibu with VIN [XXX] added to the recall so that I can have my Chevy Malibu repaired by an authorized Chevy dealership at no cost to me for something I did not do or cause. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER — Filed 05/28/2026

The gear shift sometimes does read that it’s in park

FUEL/PROPULSION SYSTEM — Filed 05/26/2026

I bought this car about 10 days ago. Throat was in pain, coughed up blood, dizzy, sweaty, and shaking. There's gas all over the ground coming from front under hood smelling through the vents. Very loud smelling. Took it to Chevrolet dealership on Covington hwy Decatur GA today and had to leave it there. I still don't feel good and neither the passengers in car. Car could've caught on fire gas leaking out when put in. Never experience this ever in my life. I may have to go to the hospital my chest feel very tight and I had a chronic asthmatic and my child in the car with me that's been on a breathing machine since last night and it's now 3:35 pm next day.

UNKNOWN OR OTHER — Filed 08/09/2024

The vehicle is experiencing premature clear coat failure on the hood and roof. The affected areas show widespread oxidation, dulling, and breakdown of the clear coat, while vertical panels remain unaffected. This indicates failure limited to UV-exposed surfaces and does not appear to be normal wear. The condition is uniform across the panels and not caused by impact, chemicals, or improper maintenance. I have observed similar clear coat failure on other 2016 Chevrolet Malibu vehicles, suggesting a potential pattern or manufacturing defect affecting paint durability. The issue significantly impacts the vehicle’s exterior condition and resale value and continues to worsen over time. Photos are available documenting the condition.

SERVICE BRAKES, AIR,TRACTION CONTROL SYSTEM — Filed 08/27/2025

The contact owns a 2016 Chevrolet Malibu. The contact stated that while driving approximately at 55 MPH in a rain storm and making a right turn, the ABS and Traction Control warning lights had illuminated, and the driver suddenly lost control of the steering and crashed into a tree. During the incident the driver sustained a concussion and neck and shoulder injuries which later required medical treatment. No police report was filed. The vehicle was later towed to the local mechanic. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 144,000.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 04/28/2026

On 04/28/2026, when diagnosing a reoccurring check engine light on the vehicle at a Chevy Certified Service, the mechanic "Borescoped cylinder 4 and found significant scuffs on the cylinder wall which along with the misfires indicate a cracked piston. The big picture appears to be the piston cracked which caused excessive oil consumption and misfires. The excess oil and unburned fuel overloaded the converter causing it to fail. The engine and converter will need to be replaced." In 2017, a recall was issued by GM to mitigate Stochastic Pre-Ignition (SPI) Causing Cracked Piston (17019). Between the initial purchase of the vehicle (11/2016) and performed service required by this recall (03/10/2017), there were approximately 5000 miles driven. No engine diagnosis was performed or recommended. After the 17019 was addressed, the engine misfires continued along with reoccurring CEL. C.S.P. N182195660 Predictive Monitoring for Stochastic Pre-ignition (SPI) released in 2019 states the 1.5 L LFV engines in certain 2016 and 2017 model year Chevrolet Malibu vehicles may have a preignition condition that requires immediate repair. This condition may cause the engine to perform poorly, misfire, run rough, and/or excessively consume oil. It may also illuminate the vehicle’s service engine light. Over time, if not repaired, the condition can damage the vehicle’s pistons and engine. The VIN for this Malibu was not attached to this notice despite it having SPI recall history. On 06/2023 (after the N182195660 program ended), at 80k miles a diagnosis revealed a potential cracked cylinder with no mention of the pre-ignition condition that could cause the crack, and the only way to fix is to replace the entire engine (as per dealer recomendation). Since vehicle was out of warranty, the repair est. was nearly $10k. I firmly believe my 2016 Malibu has suffered the consequences of poor mismanagement on this recall, and am demanding mitigation from GM to fix this issue.