2018 Chevrolet Silverado 1500 Complaints

ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE — Filed 06/24/2026

Purchased used 6/12/2026 at 188,882 miles from a franchised Chevrolet dealer. The integrated trailer brake system master fuse and passenger-side turn signal fuse were blown at delivery. When the fuses were replaced, the trailer brake system faulted and the failure disabled the ABS, traction control, and StabiliTrak (electronic stability control). Significant safety concern: with the master fuse blown/open, the vehicle displays NO warning messages of any kind — the safety-system failure is completely masked while trailer braking is inoperative. The warning cascade only appears when a good fuse is installed and the faulted circuit is energized. Separately, at approximately 12 days and ~1,700 miles after purchase, the engine began knocking and set diagnostic trouble codes; a dealer repair order dated 7/6/2026 documents the knocking complaint with no work performed. The vehicle is currently parked as unsafe to drive. No crash, injury, or fire. Reporting so the ABS/ESC failure mode — and particularly its masking behavior when the fuse is open — is on record for this VIN and vehicle line.

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE — Filed 05/24/2026

The contact owns a 2018 Chevrolet Silverado 1500. The contact stated that while driving at approximately 60 MPH with cruise control activated, the vehicle shuddered and multiple warning lights illuminated, including the check engine, check oil, fasten seatbelt, traction control, and brake warning lights. The vehicle experienced steering overcorrection and lost power. The vehicle was steered to the side of the road and slowly driven to an independent mechanic shop, where it was diagnosed that the engine needed to be replaced; however, the vehicle was not repaired. The vehicle was then taken to a dealer, where it was diagnosed that the first and second pistons and lifters needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 101,000.

POWER TRAIN,ENGINE — Filed 12/01/2025

The engine lifters and camshaft started to fail at 114,000 miles. I had to have it repaired at a dealership and it cost over $10,000. I had completed all recommended maintenance prior to the failure. 500 miles after that repair was completed, my transmission overheated and completely left me stranded on the side of the road. I had to have it repaired at a dealership which cost $$8,000

TIRES — Filed 06/27/2026

While pulling car trailer down the interstate on 6-27-26 at 70mph, my Free Country ST205/75R16 D106 10 ply trailer tire with less than 200 miles on it blew out. This was the spare for 2 years and has 9/32 tread depth on it still. I recently this spring rotated it to the LR of the trailer. Pieces of the tire blew onto and hit a passing SUV. Luckily nobody was hurt and I was able to get to the shoulder with only some fender damage. The tire was changed and with research I found the warranty was only 1 year. I was not happy with this, but moved on and bought another tire to replace it. Yesterday 7-4-26 I pulled the same trailer and upon arriving to my destination noticed another one of the tires that was purchased at the same time is separated badly all the way around and is on the verge of blowing out. This tire has been on the trailer since I bought the set of tires new, and has just under 8/32 tread left. These tires are under 3 years old, and used well under weight capacity. I keep them aired up near the max to save gas, and check them regularly. I cannot be the only one having problems if 2 out of the 5 I bought are coming apart already. Ultimately these are a safety hazard. If that had been a motorcycle beside me, or a large enough chunk flew off. Someone could have been killed. Pics available upon request.

SUSPENSION,STRUCTURE,WHEELS — Filed 06/02/2026

I was driving on the highway at about 70 mph and the passenger side lower control arm where the ball joint sits broke. It messed up the passenger fender and tire along with the steering link. It also bent the upper control arm as well. The ball joints were replaced about 6 months ago.

POWER TRAIN,UNKNOWN OR OTHER,ENGINE — Filed 05/14/2026

A known radiator issue, with microcracks in radiator is producing a leak and will require replacement. There are many examples of this online for the model years 2014-2018, and are known by the manufacturer. I am having mine replaced with 95,000 miles on my truck.

AIR BAGS,SERVICE BRAKES — Filed 09/16/2025

I am very certain that I have proof that from the dealership a Cable Dahmer and Kansas City Missouri did break work concerning the brake master cylinder booster was replaced and it still has problem which should have been under a recall and I would like to get that corrected and received my service funds back

ELECTRICAL SYSTEM — Filed 05/20/2026

The truck dies when you turn the steering wheel all the way. When that happens the steering wheel jerks and could cause a crash. This appears to be a common electrical problem that currently has no recall from the manufacturer.

SUSPENSION,POWER TRAIN,SERVICE BRAKES — Filed 08/08/2024

Vehicle was determined to be unsafe to operate per inspection performed by Mike Maroone Chevrolet on 8/26/24 immediately after I purchased from Rocky Mountain Auto Brokers in Colorado Springs on 8/8/26. It was discovered by customer immediately after sale that bank 2 catalytic converter was restricted internally (after Rocky Mountain failed to correctly diagnose and repair 3 times before and after purchase). Customer discovered emissions warranty extension and took to Maroone Chevrolet. After warranty repair inspection of vehicle determined it was not safe for customer to pick up and drive vehicle and generated a report and video showing front suspension damage so loose that could cause crash and vehicle was towed back to Rocky Mountain for repairs. Rocky Mountain has failed to provide any documentation on these repairs and many subsequent repairs including transmission replacement after many written requests. Customer cannot verify if vehicle repairs brought vehicle back to a safe condition. Almost anll repairs by Rocky Mountain has failed resulting in missing bolts, bolts falling out after transmission replacement As well as failure of many CV Axel replacements documented in their own records. Extended Warranty Company also refuses to provide documentation of transmission replacement after they supplied the part (transmission) to Rocky Mountain for installation. Customer cannot verify if in fact transmission was replaced as it was painted black. Any warranty on replaced transmission cannot be verified and they also have refused to provide documentation or serial number verifying same after many written requests. Customer would like to submit a detailed letter and safety inspection report with further info and details in addition to this online form complaint as this is a complex case and additional info will further prove up these allegations. Some documents provided by Rocky Mountain are inconsistent with customer complaints and do not reflect accurate info.

STRUCTURE — Filed 10/08/2024

rear back glass) Back glass explosion diving down interstate distraction to say the least.)chevy recalled some but not mine)just happened no inspection)no warnning

STEERING — Filed 10/27/2023

While driving my truck on [XXX] , steering locks up, unable to turn the steering wheel. Crashes into guard rail going approximately 57mph, thankfully no other vehicle involved in this matter. I was not hurt, and had seatbelt buckled and then noticed damaged on the drivers side of the truck. Which included front bumper, left headlamp assembly, left front fender, left upper control arm, damage to front and rear doors, bedside panel, rear bumper and both wheels, and tires. Gerber Collision body shop in Henderson, Ky wrote the estimate and did the repairs for approximately $16,000.00 in damage and paint. On 10/02/2023 we took this truck to Kenny Kent Chevrolet for power steering intermittently going out, and they replaced the battery, codes for low voltage to power steering module. Tested battery and found to test bad, so they replaced the battery. Checked for codes and none were found after replacement of the battery, appeared to be the point of failure at this time. That repair was $404.96, kind of strange on part availability for a electric power steering is on BACKORDER! and module is not serviced separately, and even NO RECALLS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER,SERVICE BRAKES — Filed 05/18/2023

The wheel/wheels locked up while in motion and caused vehicle to veer off road and cause the vehicle to crash. ABS light and Stability Control System warning came on prior to crash.

STEERING,AIR BAGS,SERVICE BRAKES — Filed 02/06/2023

The contact owned a 2018 Chevrolet Silverado 1500. The contact stated while driving at 80 MPH the steering wheel became stiff and the vehicle would not brake without any warning. The contact desperately pressed on the brake pedal but the vehicle would not brake, causing the contact to be struck by another vehicle on the driver's side. No one was injured and no major damage to none of the vehicles. A police report was filed. The vehicle was towed and deemed a loss. All the air bags deploy but the front driver side. The manufacturer was not unable to reach them. The failure mileage was 69,000.

POWER TRAIN — Filed 04/21/2022

Motor vehicle accident 4/21/22. Vehicle stalled hit by 18 wheeler. Several times on several occasions after that on several days vehicle stalled in interstates with multiple 18 wheelers, trucks cars almost hitting me/my vehicle each time it stalled. Now and since May 2022, the transmission completely failed and is inoperable at this time. The stalling in the middle of interstate traffic where the speed limit on 4/21/22 is 55mph & on the interstate 65mph(The vehicle coasted slowly to the side of the road & stopped changing gears to go in either direction)

STEERING,ELECTRICAL SYSTEM — Filed 05/07/2022

At a low speeds while taking a turn, the electrical system clicks off and then clicks back on after about a second. Im able to see the voltage drop while taking the turn. When this happens, the power steering goes out while taking the turn. This exact incident is consistent with the recall of the year 2014 Silverado as stated in this article https://www.zehllaw.com/another-gm-recall-800000-chevrolet-silverado-gmc-sierra-trucks-faulty-power-steering/

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES — Filed 10/28/2020

BEEN HAVING VOLTAGE ISSUES FOR A COUPLE OF DAYS WHERE MY LIGHTS DIM AND VOLT GAUGE DROPS AND RAISES WHILE DRIVING OR STATIONARY DEALER SAID IT'S NORMAL ALSO HARD DOWN SHIFTING WHILE DRIVING NOT LETTING OFF THE GAS ASSISTANT BRAKES HAVE FAILED AND CLUNK HARD SOMETIMES WHEN STOPPING OR PRESS HARD BACK AT ME THROUGH THE PEDAL AGAIN DEALER SAID IT'S NORMAL I PULLED MY TRUCK OUT FROM THE BACK OF THE HOUSE TO THE FRONT SHUT IT OFF TO GO GET READY FOR WORK A COUPLE MINUTES LATER MY DAUGHTER INFORMED ME MY TRUCK WAS OVER HEATING I WENT TO DOOR TO FIND SMOKE POURING OUT OF MY TRUCK FROM UNDER THE HOOD GRAB A FIRE EXTINGUISHER RUN OUT POP THE HOOD AND THE WHOLE PASSENGER SIDE OF COMPARTMENT IS IN FLAMES HOW DOES A VEHICLE THAT'S NOT RUNNING START ON FIRE? AWAITING MY INSURANCE COMPANY TO GET IT OUT OF HERE I IMAGINE WILL BE A TOTAL LOSS THERE ISN'T MUCH LEFT OF THE ENGINE BAY SO NOT SURE WHAT STARTED THE FIRE

ENGINE — Filed 02/07/2020

TL* THE CONTACT OWNED A 2018 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED AT THE CONTACT'S RESIDENT, THE VEHICLE SPONTANEOUSLY CAUGHT FIRE WITHOUT WARNING OR IMPACT. A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FIRE. THERE WERE NO REPORTED INJURIES. THE CONTACT CALLED J.B.A. CHEVROLET (7327 RITCHIE HWY, GLEN BURNIE, MD 21061) BUT VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS CONTACTED AS THE CONTACT WAS AWAITING A CALL BACK. THE FAILURE MILEAGE WAS 22,000.

WHEELS,UNKNOWN OR OTHER — Filed 11/09/2019

A REAR TIRE BLEW CAUSING LOSS OF CONTROL AND THE VEHICLE STRUCK A SHALE WALL ON THE SIDE OF A HIGHWAY AND SOMEONE DIED IN THE VEHICLE.

AIR BAGS — Filed 11/04/2019

TL* THE CONTACT OWNS A 2018 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT STRUCK A DEER WITHOUT WARNING. THE VEHICLE FILLED UP WITH SMOKE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT AND HIS SON SUSTAINED MINOR INJURIES TO THE CHEST AND STOMACH, AND BRUISES TO THE CHIN. MEDICAL ATTENTION WAS NOT RECEIVED. A POLICE REPORT WAS FILED. THE CONTACT MANAGED TO DRIVE THE VEHICLE BACK TO HIS RESIDENCE. PALM CHEVROLET (2300 SW COLLEGE RD, OCALA, FL 34471, (352) 629-8011) WAS CONTACTED TO SCHEDULE DIAGNOSTIC TESTING. THE FRONT BUMPER WAS DAMAGED. THE INSURANCE COMPANY WAS CONTACTED AND INFORMED THE CONTACT TO HAVE THE DEALER PROVIDE A REPAIR ESTIMATE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

SEAT BELTS — Filed 05/15/2019

DURING A MINOR INCIDENT WITH LOW IMPACT AND AT A LOW SPEED, BOTH FRONT SEAT SEATBELT PRETNESIONERS FIRED OFF, LOCKING BOTH BELTS COMPLETELY AND FILLING THE TRUCK WITH SMOKE. NO ONE WAS IN THE PASSENGER SEAT WHEN THAT ONE ENGAGED. I WAS BACKING UP IN A SHOPPING CENTER PARKING LOT SLOWLY AND DID NOT SEE A CONCRETE SLAB BEHIND ME DUE TO THE ANGLE.

AIR BAGS,SEAT BELTS — Filed 04/01/2019

TL* THE CONTACT OWNED A 2018 CHEVROLET SILVERADO 1500. WHILE DRIVING 45 MPH, THE VEHICLE WAS INVOLVED IN A CRASH AND ENDED UP IN A RIVER EMBANKMENT. THE VEHICLE WAS TOTALED AND TOWED AWAY. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELT PRETENSIONERS FAILED. THE CONTACT SUSTAINED A BROKEN BACK AND RECEIVED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 18,000.

ELECTRICAL SYSTEM,ENGINE — Filed 02/19/2019

TL* THE CONTACT OWNED A 2018 CHEVROLET SILVERADO 1500. THE CONTACT HEARD A LOUD THUD NOISE OUTSIDE HER RESIDENCE. A NEIGHBOR CALLED AND INFORMED THE CONTACT THAT HER VEHICLE WAS ON FIRE. A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE CONTACT'S INSURANCE COMPANY PLANNED TO INVESTIGATE THE FAILURE AND UPDATE THE CONTACT ON THE STATUS; HOWEVER, THE VEHICLE WAS TOTALED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS UNKNOWN.

SERVICE BRAKES — Filed 01/17/2019

IN AN ACCIDENT WHERE I WAS THE AT FAULT DRIVER, I WAS APPROACHING A STOP LIGHT AND DID NOT NOTICE THE RED LIGHT NOR THE CAR STOPPED UNTIL APPROXIMATELY THREE SECONDS BEFORE IMPACT. ONCE I RECOGNIZED WHAT WAS HAPPENING, I IMMEDIATELY SLAMMED ON THE BREAKS. I HIT THE OTHER DRIVER IN THE REAR OF HIS VEHICLE. AS STATED ABOVE, I HIT MY BREAKS ABOUT 3 SECONDS BEFORE IMPACT, BUT MY ABS DID NOT ACTIVATE; INSTEAD MY BREAKS LOCKED AND I SLID 15-30 FEET INTO THE OTHER VEHICLE. ADDITIONALLY, SINCE MY AIRBAGS DEPLOYED, A TOW TRUCK WAS REQUIRED TO TOW MY TRUCK. UPON ARRIVAL OF THE TOW, MY TRUCK WOULD NOT START, SO HE NEEDED TO PULL IT UP ONTO THE BED OF HIS TOW TRUCK WITH CHAINS. ONCE HOOKED UP, HE BEGAN TO DRAG THE TRUCK UP. THE TOW DRIVER ASKED ME IF THE TRUCK WAS 4 WHEEL DRIVE AND WHETHER I HAD BEEN DRIVING IN 4 WHEEL. I INDICATED IT DID, BUT I WAS NOT DRIVING IN 4 WHEEL MODE. I ASKED WHY HE HAD ASKED, AND HE SAID THAT IT WHILE PULLING THE TRUCK UP, ALL FOUR WHEELS WERE LOCKED. HE SAID THAT SHOULD NOT HAPPEN NORMALLY. I'M NOT SURE EXACTLY HOW THE MECHANICS OF ABS WORK, BUT I HAVE FELT ABS ENGAGE MULTIPLE TIMES AND HAVE ATTENDING DRIVERS TRAINING FOR WINTER WEATHER CONDITIONS. MY ABS DID NOT ACTIVATE; THERE WAS NO STUTTER OF THE BREAKS, ONLY A STABLE PRESS WITH NO ACTIVE RESPONSE OTHER THAN LOCKED BREAKS AND A LONG SKID.

ELECTRICAL SYSTEM — Filed 12/17/2018

PASSENGER FRONT WINDOW AUTO UP BROKE AND ALMOST COMPLETELY SEVERED A ADULT MALES RING FING TIP. IN A PARKING LOT THE WINDOW WENT UP 'USING AUTO UP'. A FRIEND WAS GETTING IN THE TRUCK AND HAD HIS FINGER UNFORTUNATELY IN THE WAY THE WINDOW DID NOT STOP AFTER COMING INTO CONTACT WITH HIS FINGER AND IT WAS ALMOST COMPLETELY SEVERED AT THE TIP.

POWER TRAIN — Filed 08/02/2018

PARKED AND SHUT OFF, DISCONNECTED TRAILER. TRUCK ROLLED BACK WHILE IN PARK. I JUMPED OUT OF WAY AND TRIED TO OPEN DOOR TO STOP. DOOR KNOCKED ME DOWN AND CONTINUED BACKWARDS DRAGGING ME. FINAL STOP OVER EDGE OF POND AGAINST TREE STUMP. HAD TOWED TO DEALER FOR INSPECTION BY CHEVY ENGINEER. 2 WEEKS NO COMMUNICATION.