2020 Ford Edge Complaints

POWER TRAIN — Filed 09/11/2026

Vehicle shudders and is sluggish. Dealer says torque converter needs replaced for $4700. This could leave me stranded on a highway or neighborhood. There are no warnings on my vehicle. Seems to be a very common problem in this vehicle. Vehicle has not been repaired yet due to cost. Parts are hard to get.

ENGINE — Filed 09/26/2026

The EGR cooler failed (TSB 20-2234) in my 2020 Ford Edge ST line on 9/26/26. I started my car and drove down my street and the car began smoking white/gray burning odor from exhausts with a sudden loss of power while driving on a public street. Leading up to this incident and during, no warning engine inicator lights or ANY notifications appeared. Temperature gauge remained at it's normal operating temp, dead center. The tow and independent mechanic confirmed there was no triggering of service lights/overheating warning. The mechanic noticed the loss of antifreeze without seeing a leak. He rulled out a cracked cylinder head and began further diagnostics. It threw a P0301 code as well as a mis-fire code on cyclinder #1. Also a code to cylinder#3. The mechanic's diagnosis was that was this was all a direct result due to the faulty Ford EGR Cooler and explained there was an TSB 20-2234 bulletin. Ford has explicitly acknowledged this engineering defect design flaw. I then found that the NHTSA has an active and elevated investigagion into this massive problem that caused my SUV to become non-drivable, needing a complete new engine-DP 26008. (SUV at 100K like other's) I have all service records as proof on the vehicle as well as the mechanics photos/paperwork. He found the coolant was leaking directly into exhaust reccirulation tracks and into the cylinders now needing new engine. This engine failure caused a sudden loss of power, steering/brakes, no sensors and managed to get to a safe area. I could have caused a caatastrophic crash or injury to other's/myself. I contacted Ford, opened a case number but they are denying any knowledge of the TSB or assistance. I have no vehicle, and out an 8k engine that was due to the negligence of this faulty part. I had it towed to independent mechanic and now will be towing it to the Ford dealership for further escalation as this new growing investigation with the NHTSA. There were NO warning signs nor sensors. It was very scary.

UNKNOWN OR OTHER — Filed 12/01/2025

I own a 2020 Ford Edge ST-Line AWD with approximately 40,000 miles I am reporting a safety concern involving the Rear Drive Unit (RDU). My vehicle has developed a noticeable rumbling/binding sensation from the rear of the vehicle when making left or right turns, particularly at low speeds and during tight turns. I am concerned this may be related to Ford Safety Recall 21S02 (NHTSA Recall 21V-011), which involves the RDU and the possibility of insufficient lubricating oil that can cause the RDU to seize, potentially resulting in loss of mobility and loss of vehicle control. I brought this concern to a Ford dealership and was told that my VIN does not qualify for the recall. However, the symptoms I am experiencing are consistent with the RDU problem described in the recall. I am requesting that NHTSA review this situation and determine whether my vehicle should be included in the recall or whether Ford should be required to address this safety-related RDU failure. The vehicle has only approximately 40,000 miles. I am concerned about continuing to drive it if the RDU could potentially seize or cause a loss of vehicle control. I believe this issue warrants investigation because of the safety implications and the similarity between my symptoms and the defect described in Recall 21S02.

ENGINE — Filed 09/26/2026

The EGR cooler failed on my 2020 Ford Edge ST Line. On 9/26/26, I started my car and it began smoking white/gray from exhausts and burning odor. Leading up to this incident and during, there was no warning indicators or messages regarding the engine that appearerd. The temperature gauge remained at it's normal operating temperature, dead center. \n\nI had the car towed to a local mechanic. They ran diagnostic & codes on the vehicle and threw a P0301code. The mechanic noticed the loss of antifreeze without seeing a leak, smoke was coming from the car and the car had no \"service engine\" lights appear. He ruled out a cracked cylinder head and began further diagnostics on the EGR cooler. He found the coolant was leaking directly into the exhaust recirculation tracks and straight into cylinder #1. He explained due to Ford's faulty EGR cooler that cracked, draining all the antifreeze directly inside cylinder #1 without triggering a service light or overheating warning. I was told my vehicle would not be driveable and need a complete new engine or replacement. The mechanic notified me that there was a TSB (technical service bulliten) labeled \"TSB 20-2234\" where Ford has explicitly acknowledged this engineering defect in the 2019-2020 design flaw. The mechanic's diagnosis states that the engine failure was entirely a consequential result of the EGR defect, with a vehicle with regular service history.\n\nMy safety was at major risk, as well as the safety of other's. This engine failure includes sudden power loss, loss of steering/brakes, loss of sensors and any ability to handle the car. I would have instantly come to a stop, easily leading to a catastrophic crash or injury to myself/other's.\n\nI contacted Ford, opened a case # and was denied any assistance. I have no vehicle and out 7K engine that was due to the negligence of this faulty part. It is being towed, at my expense to the Ford dealership for further escalation as there is a new defect investigation with the

POWER TRAIN — Filed 09/02/2026

hard shifting of the transmission causes sudden acceleration interruption. the brief delay is concerning while entering traffic.

ENGINE — Filed 10/01/2026

I have a 2020 Ford Edge Titanium. Only six years old. It has never been wrecked, flooded or had anything else happen to it. I learned today that it needs a completely new transmission due to a torque converter failure and comes at a cost that is higher than the car is now worth. This is unacceptable in a car this age.

UNKNOWN OR OTHER — Filed 05/05/2026

I was driving on the highway with my husband and our dog when out of nowhere the panoramic sunroof exploded. We were traveling home and could have been in an accident when it occurred because it sounded like a gunshot hit the car. If we had not been calm during the incident, not only our lives but the lives of everyone around us could have been affected. There were no warnings about this and when we purchased the vehicle in 2023 the dealership didn’t even say anything about a possiblity of this happening. I did research after it happened to make sure there wasn’t a recall we missed and I came across lawsuits because of this.

SERVICE BRAKES — Filed 10/07/2025

Brake pedal dropped to floor when applied slight pressure to slow from 30mph to 20 mph, then the car surged no brakes. I finally got car to stop by putting in neutral and engaging emergency brake.

POWER TRAIN — Filed 08/26/2025

My vehicle transmission gear selector went out I believe. While having my mechanic try to see if something was happening with transmission, the vehicle was placed into neutral and the tires started spinning as if it were in drive. The vehicle does not do the appropriate action when the gear is selected. In addition, it will not reverse when selected. When the mechanic was looking at transmission and wheels began to spin while in neutral, he was under car near front tire and injured his hand due to the vehicle not doing the appropriate action. The vehicle is available for inspection if requested. There was a prior recall on the same issue for model year up to 2019 however mine is a 2020. I have seen numerous complaints of the same issue in many online forums but ford has offered no help. They have not offered anything more on this issue except for an astronomical quote to have it tested and no actual idea on how to fix it. There were zero lights that came on regarding the issue and I had no warning while driving my vehicle that stopped and would not proceed to drive when it was driving perfectly fine right before.

AIR BAGS — Filed 07/20/2021

The contact owned a 2020 Ford Edge. The contact stated that while driving 40 MPH for unknown reasons, she crashed head-on with an unknown Dodge. The steering air bag did not deploy. The top edge of the air bag was activated but did not fully deploy. The contact sustained injuries to the right side of the knee, back nerve, right shoulder, and neck, and permanent knee bruises, and medical attention was provided. There was no reported fire. A police report was filed. The vehicle was towed to a junkyard. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 12,000. The insurance company deemed the vehicle a total loss.

AIR BAGS — Filed 07/25/2024

I was driving down the road, coming around a bend and then I was in bushes with a tree in the hood of my car. The car was slanted in an embankment. The driver could not get out of the door they crawled over to the passenger side and got out of the vehicle. The car was wedged between two trees. The airbags never deployed on this front impact accident.

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE — Filed 04/14/2024

On [XXX] at [XXX] I was driving home from work as I turned on [XXX] road in Jackson CA I felt the vehicle pull and not want to pick up speed to drive up the road like it wanted to stall and only rolled forward a bit. The vehicle then picked back up and I made it to the stop light at the end of the road once I stopped for less than 1 minute the light turned green, I tried to go and the vehicle shut off and began to roll back I had to step on the break and the car behind me reversed so I would not hit him and then the screen flashed a turn vehicle off and restart engine I tried multiple times about 6. Cars had to go around me as I was the first at the light. I finally got the car to turn on and white smoke came out the exhaust pipes I couldn’t put the car in drive. I tried to re start the vehicle again and got it into drive and was able to pull on the side of the highway and more white smoke came out still no vehicle warning signs came on but the screen flashed dimly like it wanted to turn off again. I flagged down a fire truck and called 911 for help the fighters stated it seemed like my engine had blown out and the coolant was completely drained and may have gotten inside the engine causing the white smoke but to take it to a mechanic to verify. I had the vehicle towed to my home. On the way to work that night it drove fine with no issues or warnings, or pulling, I ran errands the day prior and no light warnings came on nor was my vehicle temperatures out of place. I even had my car serviced on [XXX] and had no issues I keep up on the maintenance I got the vehicle used from enterprise with a mileage of 52,559 on [XXX] the vehicle now has only 96,634 I’ve had the car for only a year and 4 months it should not have had an engine issue l have made a claim with my insurance hoping to get help, I’m calling enterprise for warranty information if there’s any and ford to see if there is any manufacturer warranties hoping to hear back this week. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN — Filed 01/10/2023

My daughter along with my son in law had parked the car under the carport, once parked they got out to get my grandchildren out, My son in law get the baby on the passengers side while my daughter the drivers. My son in law got his side and shut the door. My daughter takes a bit longer because my oldest grandboy has special needs and takes a little longer. Once she shut his door with the drivers door still open the car rolled back. The drivers door struck my daughters knocking her down to the concrete. She had to toss my grandson to get him clear of the car, His head also struck the concrete. The car then ran over my daughters upper right leg. the car proceeding down hill and across the street where it struck the house across the street. Police and EMS where called, at the time my daughter refused transport. I took her the the ER , nothing was broken but she had major contusions and pain, My grandson was taken by POV the the Children's hospital to have his shunt checked. After a couple days my daughter was still complain of a headache and eye pain, she went back to the ER where she was diagnosed with a concussion. The car is currently at the dealership

VEHICLE SPEED CONTROL — Filed 11/01/2022

The contact owns a 2020 Ford Edge. The contact stated while parking the vehicle and the vehicle accelerated without any warning, causing the vehicle to strike the building in front. The air bags deployed. No one was injured. A police report was filed. The vehicle was towed to the dealer. The manufacturer was contacted, and a case was filed. The failure mileage was 90,000.

UNKNOWN OR OTHER,VISIBILITY — Filed 10/22/2022

On 10/22/2022 while driving on a highway at the posted speed limit, without warning the Panorama Sun Roof exploded showering shards of glass on Myself and My Wife. The glass sunroof was properly closed but the inside headliner panel was open to enjoy the sun. The moderate average temperature outside at this time was approximately 68 degrees. This vehicle currently has approximately 12,250 miles on it. When the sunroof suddenly exploded, my wife sustained cuts to her hand and both of us were covered in shredded glass, including tiny glass shards embedded in our scalps. The explosion was so sudden and loud I nearly lost control of the vehicle. Fortunately, there was minimal traffic on the road at the time of the explosion with no vehicles immediately in front of us. Research has revealed many incidents of exploding sunroofs on various Ford models, with an exceptionally high incident rate for the Ford Edge model. It was further discovered that this exploding sunroof issue in various Ford models has been ongoing since 2008 with the Ford Motor Company being made aware of this defect. Research has further indicated to date, Ford has failed to issue a recall for this serious and dangerous defect. If our grandchildren had been rear seat passengers (which is often the case), this incident could have been tragically much worse. Not only did the exploding sunroof cause a serious, dangerous and injurious safety threat to us as passengers, getting the vehicle off the road (with the interior headliner panel closed) caused a safety threat to any nearby drivers as we could hear and see the remaining shattered glass flying off the vehicle into the roadway.

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 07/26/2022

The contact owns a 2020 Ford Edge. The contact stated while she was depressing the brake pedal to slow the vehicle down in order to park but the brake pedal traveled the floorboard. The vehicle failed to stop and crashed into a wall where it came to a stop. The contact mentioned that the Forward Collision Avoidance/Emergency Automatic Braking failed to detect that the wall was in front and prevent the collision. The contact sustained minor injuries that did not require medical attention. The vehicle was towed to the dealer where the vehicle was diagnosed, and they stated that no failure was determined. The manufacturer was contacted and advised she will receive a call and to contact the NHTSA Hotline. The failure mileage was 17,015.

STEERING,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL — Filed 11/16/2021

Have had issues from day one. Lane centering hugs middle line, back up camera is black at times, when in drive screen is blank, all tools on steering have went out including turn signals, cruse control, collision avoidance flashes when no one is in front of me, brakes due to collision avoidance malfunction etc. in November 2021 car was in park ( know that for sure it was in park and not moving as fed ex came for delivery and walked around back of car to get package before accident) and rolled to front pinning me and breaking pelvis and back. During this incident the safety failed in park, anti collie on failed, 9 days in hospital and months of rehab. Again coming back from doctor lost steering controls. 7 weeks in shop and many calls to dealer and ford motor they replaced main wiring harness stating to me in an email and in person this was the cause of all issues including the roll over. Just got car back on 6/17/22. Shall see if this fixes problem but I don’t even want to drive this car anymore! Total miles to date 17,000

BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE — Filed 03/06/2022

VEHICLE transmission while in park failed to remain and moved backward on its own. My safety was at risk as a tractor trailer pulled into rest stop and had to brake b4 colliding with the said vehicle, also if anything was behind me it could have been at risk. unknown unknown NO there was NO warning lamps or messages of this problem, however there were indications on the dashboard lights that stated Blind Spot System Fault AND Cross Traffic System Fault at 45478 miles and Prior

AIR BAGS,UNKNOWN OR OTHER — Filed 12/23/2021

We were driving my 2020 Ford Edge when my vehicle and another vehicle collided. The entire front end of my Ford was smashed in due to the force of the impact. We had to be extracted by the fire department, because we could not open the doors. My pre collusion alert system did not sound off; nor did the airbags deploy despite the rate of speed from the other car as we both entered the intersection. As a result of the airbags failing to deploy, my wife suffered injuries resulting in a trip to the ER. She is still treating with medical providers. Prior to this incident we had no indication of any safety features failing. No warning lights, messages or other symptoms. The manufacturer has been made aware of the incident but has not yet inspected the vehicle at the time of this report. It is currently being held at an auto repair shop.

ELECTRICAL SYSTEM,ENGINE,FORWARD COLLISION AVOIDANCE — Filed 11/16/2021

On 11-16-2021 I put my 2020 Ford Edge in park, got out, and it rolled away. After I put the Edge in park, I opened my door and was moving a trash can, when the Edge rolled forward pinning me.

POWER TRAIN,UNKNOWN OR OTHER,SERVICE BRAKES — Filed 11/02/2021

Waiting in line at drive through and had my foot on the brake and my car surged forward hitting the car in front of me and they hit the car in front of them. I found no recall on my 2020 Edge titanium but this surge has happened before.

STRUCTURE — Filed 04/17/2021

I AM LEASING THE VEHICLE AND HAD IT FOR 6 MONTHS. WHEN PARKED AND LOADING GROCERIES INTO THE REAR, THE LIFTGATE HAS COME DOWN ON MY HEAD AND BACK AT LEAST 5 TIMES ON ITS OWN. THERE IS A SENSOR THAT IS UNDER THE CAR AND ACTIVATES WHEN YOUR FEET ARE UNDER IT. FAULTY DESIGN. YOU CANNOT LOAD THE BACK WITHOUT THIS LIFTGATE COMING DOWN ON YOU. I HAVE BEEN HURT AND SUFFERED HEADACHES AFTER GETTING HIT WITH THE LIFTGATE. I HAVE CONTACTED FORD AND HAVE AN OPEN CASE WITH THEM ADDRESSING THIS ISSUE. I RESEARCHED THIS ISSUE AND IT SEEMS THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS SAME ISSUE ON THE INTERNET.

LANE DEPARTURE,FORWARD COLLISION AVOIDANCE — Filed 04/04/2021

WHILE IN MOTION WITH NO ROAD TRAFFIC AHEAD OF VEHICLE CRASH DETECTOR ENGAGES, OCCURRED ON HIGHWAY STRAIGHTAWAY. WHILE IN MOTION LANE ASSIST MADE A HARD PULL TO THE RIGHT, DRIVER OVERCORRECTED TO THE LEFT RESULTING IN COLLISION, OCCURRED ON HIGHWAY STRAIGHTAWAY.

UNKNOWN OR OTHER — Filed 03/25/2021

I WAS DRIVING IN STOP AND GO TRAFFIC FOR SEVERAL MINUTES. WHEN WE WOULD MOVE FORWARD IT WOULD ONLY BE FOR 1 CAR LENGTH. I STOPPED, AND WHEN THE ENGINE TURNED BACK ON FROM THE AUTO START/STOP, THE CAR LURCHED FORWARD AND HIT THE CAR IN FRONT OF ME. I STILL HAD MY FOOT ON THE BREAK. AT FIRST I THOUGHT I HAD BEEN HIT FROM BEHIND, BECAUSE I HAD MY FOOT ON THE BREAK. I HAVE SEEN 2 OTHER COMPLAINTS SIMILAR TO MINE, HOWEVER, THEY DID NOT RESULT IN AN ACCIDENT.

STRUCTURE — Filed 01/31/2021

THE BACK HATCH DOOR WAS OPEN TO PUT SHOPPING ITEMS AWAY, AND MY DAUGHTER TURNED AROUND TO PUT A CART AWAY IN A PARKING LOT. ALL OF A SUDDEN ANOTHER VEHICLE WAS COMING AND SHE BACKED UP WITH A CART IN FRONT OF HER, AND THE HATCH DOOR HIT HER BETWEEN THE SHOULDERS. IT HIT HER, IT STOPPED AND THEN MOVED UPWARDS. SOMETHING LIKE THIS ALSO HAPPENED TO ME WITH ANOTHER FORD THAT I TRADED IN LAST YEAR FOR THIS 2020 FORD. THE VEHICLE WAS IN FOR A CAMERA REPAIR PRIOR TO THIS, SO DO NOT KNOW IF A SENSOR IS OUT OR NOT FUNCTIONING CORRECTLY; AND THE REAR END OF THE VEHICLE MAKES A CREAKING NOISE SINCE THEY REPLACED THE REAR VIEW CAMERA. DO NOT KNOW IF THIS HAS ANYTHING DO DO WITH THE HATCH BACK OPEN AND CLOSE FUNCTION. THE VEHICLE WAS IN PARK IN A SPOT IN A SHOPPING CENTER ON A TWO WAY PARKING LOT.