2025 Ford Explorer Complaints

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 10/15/2026

I was driving at approximately 5mph when my car suddenly slammed on breaks. The pre collision warning popped up. There was no obstical in site. Happened approximately 30 mins ago. Had immediate pain in my shoulder, neck and head.

EXTERIOR LIGHTING — Filed 10/09/2026

Faulty led chip in headlight, DRL , high beam & low beams affected EXACTLY like the recalled 2026 models.. ford recommended replacement @ 2,400$ Ford should be forced to extend the recall to all affected models. This is an attempt to mitigate and minimize financial damage for ford motor company and is unacceptable

ENGINE — Filed 09/04/2026

At approximately 17,000 miles the Explorer started misfiring, would not shift out of gear and check engine light would flash. Dealer replaced #1 spark plug. 1 week later the car misfiring occurred again, where #4 spark plug was replaced. 18,300 miles later, #1 and #3 spark plugs were replaced due to cracked spark plugs which caused misfire. All instances happened under engine load while merging onto freeway which caused a hazard due to lack of acceleration and reduced speed while getting onto freeway.

AIR BAGS,VEHICLE SPEED CONTROL,SERVICE BRAKES — Filed 09/21/2026

The contact owned a 2025 Ford Explorer. The contact stated that while his wife was making a right turn into a resident carport, the vehicle surged forward and crashed into the house at approximately 10-15 MPH. The brake pedal was depressed during the failure. The contact was following his wife at the time and became aware that the brake pedal was being depressed. The air bags deployed on the driver's and passenger's sides, steering, curtain, and footwell. The driver sustained bruises from the air bag and seat belt. The vehicle was towed. The EMT provided medical attention at the scene. A Police report was filed but the police report number was not available. The manufacturer was contacted by phone and opened a case. The vehicle was inspected and totaled by the insurance company. The failure mileage was approximately 27,954.

ELECTRICAL SYSTEM,VISIBILITY/WIPER — Filed 09/18/2026

A recent over-the-air (OTA) software update deployed by Ford Motor Company to my 2025 Ford Explorer ST introduced a primary safety hazard and severe system latency. PASSENGER MIRROR FAILURE: Approximately 10% of the time upon vehicle startup, the passenger-side power-folding exterior mirror fails to unfold. This leaves the driver with no right-side mirror visibility, creating an immediate blind-spot hazard and violating FMVSS 111 visibility standards. APIM / NAVIGATION LATENCY: The software update severely degraded processing in the Accessory Protocol Interface Module (APIM). Navigation display systems lag behind the actual vehicle location by approximately 0.1 miles, causing delayed routing information and significant driver distraction. System resets (soft reboots and full master resets) fail to fix the issues. Upon contacting Ford In-Vehicle Technology support, representatives acknowledged the issue but refused to log or escalate the side-mirror failure as a safety defect.

FORWARD COLLISION AVOIDANCE — Filed 09/18/2026

I was making a left hand turn with incoming traffic. I had pleanty of time to make the turn. Next thing I know my forward pre collision alarm goes off, locks up breaks, alarms started going off. It only lasted a couple seconds, but that’s all it takes to killed.

ELECTRICAL SYSTEM — Filed 09/04/2026

the rear passenger door flew open while I was driving on a public road, with absolutely no warning or dashboard alert to indicate it was unlatched

SEATS — Filed 09/15/2026

Just dropped off my [XXX] and [XXX] to elementary school drove to get gas and the passenger backseat behind the driver side fell forward and slid forward. I put it back in place drove again. It did it again and it is not staying in place. I called FORD. They told me they were supposed to be a remedy for it mid September. It is mid September but I can’t have my [XXX] getting hurt with a default seat and when I called today XXX at approximately 1:20 PM mountain time the lady on the phone told me pretty much. There’s nothing that they can do about it until there’s parts to replace it even though it opposes a danger to my child. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE AND ENGINE COOLING — Filed 08/26/2026

The contact owns a 2025 Ford Explorer. The contact received notification of NHTSA Campaign Number: 26V122000 (Engine and Engine Cooling). The contact scheduled an appointment at the local dealer after being notified of the recall. The dealer initially stated that the part would be available within a week, but the contact was subsequently informed that the part was on backorder and there was no estimated date when the part would be available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

ELECTRICAL SYSTEM — Filed 08/18/2026

I am reporting recurring engine misfires involving my 2025 Ford Explorer Platinum equipped with the 2.3L EcoBoost engine. The vehicle currently has approximately 15,700 miles. The first incident occurred approximately five months ago. The check-engine warning appeared and the vehicle was diagnosed by an authorized Ford dealership with DTC P0303, indicating a cylinder 3 misfire. The cylinder 3 spark plug was replaced. A second misfire subsequently occurred at approximately 15,700 miles. The vehicle again exhibited an engine misfire/check-engine warning and was transported through Ford Roadside Assistance for service. An authorized Ford dealership diagnosed DTC P0301, indicating a cylinder 1 misfire. I was advised that the cylinder 1 spark plug was physically damaged and that a portion/cap of the plug had broken off and was not present. I am concerned because this represents two spark-plug-related misfires involving two different cylinders of the same engine within approximately five months and at relatively low mileage. Ford has issued technical service information addressing P0301-P0304 misfires on certain 2025 Explorer vehicles equipped with the 2.3L EcoBoost engine. I am not claiming that this establishes the cause of my vehicle's failures; I am reporting the recurring condition so NHTSA can document it and evaluate it alongside any similar reports. Both incidents were diagnosed by authorized Ford dealerships. Repair documentation and manufacturer/dealership correspondence concerning the incidents have been retained and can be provided if requested. The vehicle/component may be available for further inspection if requested, subject to its current repair status.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 07/05/2026

On XXX, my 2025 Ford Explorer Platinum experienced a complete unexplained no-start failure while approximately six hours from home. The vehicle had less than 1/4 tank of fuel but was not empty and was parked on a slight decline. It remote-started normally and ran for approximately 10 minutes before automatically shutting off. Afterward, it would not restart, repeatedly displayed "Accessory Power Only," and later displayed and audibly announced "System Failure, Contact Dealer." Multiple jump-start attempts failed and the vehicle required towing to Lugoff Ford in [XXX]. Lugoff Ford documented fuel and transmission-related codes and initially advised that the vehicle appeared to need a transmission replacement. That explanation later changed, and the vehicle was returned without an identified cause or repair. I subsequently took the vehicle to Cleveland Ford in [XXX] for a second evaluation. Their repair order specifically states that Ford connected data showed a fuel-pressure code on the day of the failure, but they found no active DTCs and could not duplicate the condition. The vehicle was again returned without diagnosis or repair. I am concerned that an intermittent defect involving the fuel system, transmission controls, electrical system, software, or related components could cause another sudden disabling event. Two Ford dealers have evaluated the vehicle, evidence of the original failure exists, and the underlying cause remains unidentified and unrepaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM — Filed 08/12/2026

The contact owns a 2025 Ford Explorer. The contact stated that while the vehicle was parked, the vehicle was started and the doors were unlocked and the contact walked over to the front passenger’s side door to put her purse inside the vehicle; however, after the contact walked over to the rear driver’s side door to place a child into the car seat, the doors inadvertently locked and the child was trapped and locked inside the vehicle. The key fob failed to operate as designed, and the contact was unable to unlock the doors. The contact broke the rear driver’s side window to remove the child from the vehicle. No warning lights were illuminated. The vehicle was taken to a dealer, and the dealer stated that the failure might be related to a software malfunction; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 4,000.

SERVICE BRAKES, HYDRAULIC,AIR BAGS — Filed 08/05/2026

The contact owns a 2025 Ford Explorer. The contact stated that while driving 50 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The vehicle crashed into the driver's side of another vehicle. The air bags failed to deploy. The vehicle was towed to a local tow yard. The contact was transported to the local medical center for medical attention. The contact sustained bruises and contusions during the crash. The contact sustained a continuous headache after the crash. The contact was receiving continuous medical treatment. A Police report was filed. The vehicle was scheduled for an inspection by the insurance company within days. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 20,000.

STEERING — Filed 08/25/2025

Steering fails to self-center after slight bear-left such as lane change manuver or steering to track a gentle left bend in road, typically holding ~10 degree left position of the steering wheel. Center feel is "notchy." Behavior is almost completely a bear-left problem and only a slight similar behavior in bear-right condition. Self-centering from hard left seems to be correct in fully returning wheel to center. This behavior has been confirmed by many owners' complaints posted online, and is a problem unique to the Explorer model and 2020+ generation. Video demonstrating problem while driving: [XXX] Explorer ST Owner Forum post confirms similar behavior by others: [XXX] My dealer is treating this as "not a problem, they all do this." No other vehicle in my life (dozens) has ever exhibited this behaviour of steering not returning to center while moving. After delivery I returned the car almost immediately to the dealer on noticing the steering just felt "weird." They found nothing. I narrowed the behavior down to the specific circumstance of bear-left and notchy on-center feel, returned it again, and again they found nothing. With ~3000mi, no change in behavior --"break-in" is long past. I know how to correct for the issue, but if I loan out the car? While it can be called a fit and finish flaw, on the outside it could be a safety issue for unfamiliar drivers. Answers to General Guidelines questions >>> Dealer has identified no failed components or need for repair after two attempts and multiple discussions of the problem. >>> Safety? Issue results in fatigue after long use of the vehicle. Drivers unfamiliar with non-return-to-center behavior may not give the neccesary corrective input to return steering to center. >>> Two dealer repair visits, both inconclusive. >>>No warning lamps etc. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STRUCTURE,SEATS,UNKNOWN OR OTHER — Filed 08/05/2026

This vehicle was a rental car. The rear door opens and closes at random times. On multiple occasions even after locking the car, we would come out to the door being open. The door came down on its own and smacked my wife as well as hitting my [XXX] daughter in the head. While driving down the highway that rear door decided to open on its own putting my family in immediate grave danger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SERVICE BRAKES — Filed 08/03/2026

On repeated occasions the vehicle’s braking system has malfunctioned without driver input, including uncommanded automatic brake engagement at highway speed and, most recently, a failure of the braking system to respond as commanded. These malfunctions occur without warning and directly impede my ability to control and safely operate the vehicle. On at least one occasion the malfunction occurred while I was driving on the highway with my three minor children in the vehicle and nearly resulted in a major collision.

ELECTRICAL SYSTEM,SERVICE BRAKES — Filed 06/08/2026

On XXX at approximately 4:30pm, while driving through a parking lot (between 5-10mph), I tapped my brakes and then the parking brake activated and caused several errors on my dash, such as the ABS light, a brake failure error, a service Advance-Trac error, and others. The brakes became incredibly stiff and would not work when I pressed them. The car would continue to roll and stop randomly. I was able to pull into a parking spot out of traffic and when attempting to disable to parking brake, it would not work. I had to attempt to disable it, turn off my car, and then turn it back on. After a few seconds, the parking brake audibly unlocked and then my brake pedal became usable again. I called Two Rivers Ford in [XXX] the next day and they advised that they would look at it, but it would be the end of July before they had a service loaner available. I brushed it off as an electrical glitch. On XXX at approximately 7:30pm, my car did the exact same thing again while coming to a stop on a highway. This again occurred around 10mph. I was able to get off the highway and reset the parking brake again by turning the car on and off and was able to begin driving again with no issues. On XXX I called the same dealership again and they were able to provide me with an emergency service loaner same day due to the urgency of the situation. They advised that this had happened to 5 other Explorers in the country prior, the first step is to reset the ABS Module, if that doesn't fix it, they will replace the brake booster. On XXX at approximately 9:45am, while braking prior to turning in an intersection, at approximately 30mph, the same issue occurred again. This time I rolled into the middle of the intersection, because my brakes wouldn't work. On XXX, I called the dealership and they provided me with another service loaner to attempt to replace the brake booster. This is a major safety issue due to loss of brakes. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING,VEHICLE SPEED CONTROL — Filed 07/03/2026

When going around a curve the steering wheel is sticking on the right. I have to tighten my grip on the wheel and manually straighten the wheel. This happened to me several times today on my 50 min trip. This was very frightening to me making me scared the wheel would stick and I have no control of the car while driving. I purchased this car on sat June 27. It just started today July 3. I am planning to take it back to the dealership on Monday.

UNKNOWN OR OTHER — Filed 04/29/2026

I was driving on the Highway and all the sudden for absolutely no apparent reason the Passenger side door window completely shattered into small bits of glass. I check the vehicle for any damage other than the window not a scratch on the door at all I have no idea what caused the window to shatter.

FORWARD COLLISION AVOIDANCE,LANE DEPARTURE — Filed 02/05/2026

While using Ford Blue Cruise, the Blue Cruise system failed to maintain lane control and fought the driver's steering wheel input, resulting in the vehicle colliding with a traffic cone. I have had 3 other instances where Blue Cruise has randomly jerked me toward the shoulder or an exit ramp, this is the first time colliding with anything. Only damage to the vehicle from this incident is a ripped fender well liner, there are some markings on tire sidewall but no damage. Certainly could have been worse. The cone collision happened on Interstate 79 Northbound at MM101 in West Virginia. I have had lane jerking happen with Blue Cruise twice Northbound at MM105, and once Southbound at MM118. The system is on by default, I am trying to figure out how to turn it off to prevent future safety issues.

POWER TRAIN — Filed 08/29/2025

Automatic Return To Park safety feature failed to stop vehicle from forward rolling causing vehicle to crash into open garage. The drivers door hit side of garage frame, closing onto my left leg causing calf muscle pain and bruising.

STEERING,SERVICE BRAKES — Filed 10/24/2024

On October 24, 2024, my 2025 Ford Explorer ST experienced a sudden steering column lock and complete loss of braking while I was driving, leading to a crash and injuries. The vehicle had approximately 800 miles and was a warranty replacement provided weeks earlier. Prior to delivery, the dealer referenced a Quality Assurance hold of about two months on this vehicle, which was not disclosed to me in any detail. The simultaneous loss of steering and brakes suggests a potential common cause safety defect that may affect other 2025 Explorer ST vehicles. My insurer State Farm is currently conducting a Cause and Origin inspection. I request NHTSA review for a potential defect trend.

SERVICE BRAKES,ELECTRICAL SYSTEM — Filed 04/28/2025

The contact owns a 2025 Ford Explorer. The contact stated that while at an intersection at a stop light attempting to make a turn at 5 MPH, the brake pedal was hard when depressed, and the vehicle continued to move. As a result, the vehicle crashed into the rear of another vehicle. The air bags did not deploy. The front camera was not operational. There were no warning lights illuminated. There were no reported injuries, fire, or police reports filed. The contact was able to continue to drive. The vehicle was taken to the local dealer, who test-drove the vehicle and was unable to determine the failure. The vehicle was not diagnosed or repaired. The contact called another dealer, J. O. Williams Motors419 E Broadway Ave, Gladewater, TX 75647, and reported the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted, who referred him to another local dealer. The failure mileage was approximately 4,000.

UNKNOWN OR OTHER,SERVICE BRAKES — Filed 03/02/2025

Put car in park. sUV rolled back & damaged my garage door. Also damaged my trunk of SUV.

VEHICLE SPEED CONTROL — Filed 01/14/2025

The contact owns a 2025 Ford Explorer. The contact stated that after his wife had pulled into the parking spot at the residence and shifted into park(P) to turn off the vehicle, the contact stated that the cameras activated on the display screen and then went black before the engine revved up and the vehicle unintendedly accelerated and crashed into the residence before coming to a stop. No warning light was illuminated. During the failure, there were two teenagers and a toddler in a car seat during the failure. No injuries were sustained. A Police report was not filed. The vehicle remained at the residence and the contact was waiting on the Insurance Company to inspect the vehicle. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer was notified of the failure, and the contact was referred to the Insurance Company for assistance and then referred to the NHTSA Hotline to report the failure. The approximate failure mileage was 400.