2022 Ford Maverick Complaints

POWER TRAIN — Filed 09/03/2026

While driving on the streets the powertrain module gave out. It started to jerk around 30 mph and then just would not go.

ENGINE,FORWARD COLLISION AVOIDANCE — Filed 08/18/2026

Engine failure with fire. Fully engulfed within seconds. Police and fire on site. AAA insurance No prior issues with vehicle

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE — Filed 08/17/2002

The Ford Maverick is subject to rodent invasions which caused an engine fire. We had to file a State Farm Insurance Claim ($4016.36 of repairs done to repair the engine including electrical, emission system, cowl, fuel system, and insulation.) This was completed XXX. We have been faithfully spraying the engine with Rodent Repellent, using Natural Repeller packs, and rat snap traps. We have regularly checked the engine to see if they have come back. Yesterday, XXX, low and behold there was evidence of rat/mice droppings, insulation, food, nesting, etc. We again have spent time and money to clean the engine and use the above-mentioned products to try to protect the engine. After moving the truck, again on XXX, there was new evidence. We treated again. This is causing us stress. This should be a recall and Ford made to remedy. Sincerely, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN,FUEL/PROPULSION SYSTEM — Filed 07/24/2026

While driving my 2022 Ford Maverick on a public road, the vehicle suddenly lost acceleration and would not respond normally when I pressed the accelerator. I was left in the roadway and could not safely continue driving, creating a risk of being struck by other traffic. The vehicle was later inspected by a Ford dealership and diagnosed with a major internal transmission failure at approximately 62,000 miles. The Ford dealership recommended a rebuilt/replacement transmission. The vehicle remains available for inspection. I did not have advance warning that the transmission was about to fail.

POWER TRAIN — Filed 07/26/2026

I had stopped at an intersection and when I applied the gas, the truck stuttered a bit before going. It ran okay for less than a mile. I stopped at the next intersection and when I applied the gas, the truck shuttered, started to go then just stopped. It stayed running but didn't want to go. I was able to get it through the intersection but that was it. The message i am getting is powertrain malfunction/reduced power. When we put our diagnosis tool on it, we get code P0757.

STRUCTURE — Filed 07/01/2026

The driver's side (left front) door failed at the check-arm attachment point inside the door assembly: the spot welds securing the check-arm reinforcement bracket to the inner door structure cracked and separated. The vehicle is a commercial fleet 2022 Ford Maverick XL SuperCrew with approx. 82,000 miles. The vehicle and failed component are available for inspection upon request. First symptoms were difficulty opening and closing the door with popping/cracking noises. No warning lamps or messages occurred; the failure is concealed inside the door. This is a safety risk because the check arm attachment supports the door's structure. The same weld separation on related vehicles has been documented by NHTSA (investigation PE23-013) to cause doors that fail to latch, fail to stay closed, or open while driving, risking occupant ejection and injury. The failure was confirmed 7/17/2026 by Grapevine Collision Center (Grapevine, TX) after a Ford dealership stated there is no recall or warranty coverage for the Maverick and referred me there. The shop diagnosed broken check-arm welds and quoted $2,602.46 for a door shell replacement, noting it has seen this identical failure on Ford Escapes and Lincoln Corsairs. Not inspected by Ford, police, or insurance. This is the same failure mode NHTSA investigated on 2020-2021 Escapes (PE23-013), which Ford addressed via Customer Satisfaction Program 23B56 covering 2020-2023 Escapes. The Maverick shares the same C2 platform and door design but is excluded, leaving owners to pay out of pocket for a defect Ford repairs free on sibling vehicles.

POWER TRAIN — Filed 03/23/2026

I am filing a formal safety defect complaint regarding a severe catastrophic transmission failure on my 2022 Ford Maverick ( 2.0L EcoBoost 8f35 8 speed transmission ) that poses an immediate safety hazard to occupants and sharing traffic. Upon inspection a heavy volume of metal shavings flakes were discovered also the code PO73D unable to engage in neutral came up. The safety risk of this specific failure is extreme because the vehicle is physically unable to respond to a neutral command the driver cannot clear or cut engine power to the drive wheels during an emergency mechanical malfunction or a potential unintended acceleration event. Furthermore because the metal debris the truck exhibits severe erratic shifting behavior and a persistent risk of sudden high speed wheel lockup drivetrain binding or stalling inactive traffic. Ford motor company is fully aware of this component failure despite my vehicle exhibiting the exact failure mode the exact code PO73D and metal debris found has refused financial responsibility I urge the NHTSA to upgrade this known issue to a mandatory safety recall

STEERING,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 06/19/2026

Due to go to dealership to inspect steering wheel

SERVICE BRAKES — Filed 03/18/2026

NHTSA #26V104: I purchased this vehicle to rent it out on Turo (a vehicle sharing platform). It was de-listed from Turo on March 18 due to NHTSA #26V104 recall being unresolved. I have been unable to rent my vehicle since then and Ford has not provided a remedy to this recall. I would like to log a complaint that this software fix remedy has taken too long.

POWER TRAIN — Filed 03/20/2026

Transmission started slipping. Not wanting to pull in drive or reverse

POWER TRAIN — Filed 05/26/2026

Ford has 25N09 addressing the axles for the 2022 Ford Mavericks built later in the 2021 year, but mine was built in September of 21. I have axle issues as well, and this is the first vehicle I've ever had that's this new and has clunking in the CV axles. Mine clunks loudly, and the truck has 114k on it.

UNKNOWN OR OTHER — Filed 04/22/2026

The chrome tips on the window switch fell off and jammed itself in the switch, in the on position for the passenger window. These exact parts are already on recall for different Ford models but it is the same part number being used.

STEERING,ELECTRICAL SYSTEM — Filed 04/30/2026

I was trying to turn and the wheel kept kicking back the other direction. About a week prior to this as I was driving down the road all of a sudden the wheel threw me across a median and into incoming traffic almost causing multiple accidents. I have a video of it but it won’t allow me to upload it. [XXX] However this link should play it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SUSPENSION,POWER TRAIN,ELECTRICAL SYSTEM — Filed 05/09/2026

When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I go for a ride in it they kept it for several weeks and put over 300 miles on it and got ford engineering involved to determine the cause was broken axle. It has been replaced again since then supposedly by a recall but it feels like it is broken again ! Ford took some shortcuts and used inferior parts, infrastructure etc , we had tremendous problems with the battery to which they said their shouldn’t be any reason for this be happening loss of power loss of electrical display and distribution finally I just had to replace the battery on my own because they refused to accept responsibility 4-6 months later a recall for the batteries was issued. The axles on the truck are not sufficient and they are not taking care of it properly! I would also like to report that they cut so many corners on the Maverick that the tailgate just drops no shock absorber nothing just slams on the bumper very dangerous! & They also chose to leave many open” holes” where mud rocks , leaves etc get into the front quarter panels from the hood area at the corner of windshield . So this wet material gets trapped in there n I’m sure will eventually affect the structural integrity of the panel - maybe rust through! Same thing happens with the tailgate fills with debris from bed , rear wheel wells also have a whole. I just wish ford would go back to how Henry Ford ran the company ! Help NHTSA

POWER TRAIN — Filed 12/12/2024

Vehicle started experiencing loss of power while driving on the highway. After having it towed to the local Ford dealership, we were informed that our transmission was shot and needed to be replaced. The vehicle had 62k miles on and no dash light warning and no ford pass warnings about the issue. It cost us $7k to replace and 4 months without the vehicle.

STEERING,ELECTRICAL SYSTEM — Filed 04/18/2026

When the battery voltage suddenly drops the vehicle loses its power steering making slow speed turns extremely difficult. This poses a serious risk of the inability to control the direction of the vehicle and this makes a crash extremely probable.

ENGINE — Filed 08/17/2025

Truck smelled funny, pulled over to check it out. Got out truck and noticed it was on fire from engine.

FORWARD COLLISION AVOIDANCE — Filed 05/26/2025

When in adaptive cruise control the vehicle must of not seen the lines properly and started to steer towards the ditch. Then when trying to steer back onto the road the truck keep trying to steer into the ditch. The truck was fighting the drivers input even though the truck should deactivate the adaptive cruise control when manually taking over. The truck end up in the ditch and ran over a mailbox. The truck was inspected by Ford but they claimed nothing is wrong with it. It says in the manual that adaptive cruise control sometimes doesn't detect lines properly but when taking control the vehicle shouldn't continue to steer into a ditch. The Ford dealership were not able to get the same results because how can they when this problem doesn't happen all the time? The vehicle should not be fighting the driver instead it should of canceled the adaptive cruise control. It's very dangerous and I think needs to be looked into.

STEERING — Filed 02/01/2025

The contact owned a 2022 Ford Maverick. The contact stated that while her grandson was driving at various speeds, the steering wheel locked and the vehicle lost power steering and functionality. The vehicle flipped over several times. An unknown warning light illuminated. It was unknown if the air bags were deployed. A police report was filed. The contact’s grandson was taken to the hospital via ambulance due to sustaining injuries to the back and neck. The vehicle was towed to a local towing yard. The insurance company was contacted and deemed the vehicle a total loss. The insurance company towed the vehicle to an unknown location. The manufacturer was not notified of the failure. The failure mileage was approximately 27,000. 

AIR BAGS,STRUCTURE — Filed 07/29/2024

I was involved in an accident. During the accident none of the airbags deployed. The impact was so hard that it lifted the truck up off the ground and spinned us around 90 degrees. This resulted in the individuals seated on the passenger side of the truck to be thrown into the door fairly hard, with one passenger hitting her head on the window even with the seatbelt on. The point of impact was the drivers side back tire and bumper area.

SEAT BELTS — Filed 07/19/2023

The contact owns a 2022 Ford Maverick. The contact stated that after she parked the vehicle, her daughter unlatched the rear passenger's seat belt; however, the shoulder strap that she had placed behind her was twisted and inadvertently retracted. The seat belt then seized while tightly wrapped around the contact's daughter's waist, causing her breathing difficulty. The contact had to cut the rear passenger's seat belt with a scissor to release her daughter. The contact's daughter sustained bruising on her stomach and waist; however, medical attention was not received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 34,115.

AIR BAGS — Filed 12/15/2022

The contact owns a 2022 Ford Maverick. The contact stated that while driving at 75 MPH, another vehicle side-swiped the contact's vehicle on the passenger's front side; however, the side curtain air bag failed to deploy. There were no injuries. A police report was filed. The vehicle was towed to an auto repair center. The contact related the failure to NHTSA Campaign Number - 22V594000 (Air Bags). The dealer was made aware of the failure; however, the parts to repair the recall are not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 8,000.

AIR BAGS — Filed 02/13/2023

I was hit by another car in between the passenger side front door and the passenger side back door. I was hit with enough force to push me off the road. There was no side airbag deployment.

FUEL/PROPULSION SYSTEM — Filed 12/08/2022

The main fuel line feeding the fuel pump ruptured without warning, causing gas to spray across the engine compartment. The hot engine caused the gas to start cooking off, resulting in a fire in the engine compartment. The fuel line rupture has been confirmed by my Ford dealership.

VEHICLE SPEED CONTROL,UNKNOWN OR OTHER,SERVICE BRAKES — Filed 03/21/2022

EL DIA 21 DE MARZO DEL 2022 LLEGANDO A MI CASA Y PARA SER BIEN ESPECIFICA FRENTE A MI CASA ME ESTABA ACOMODANDO PARA COLOCAR EN RIVERSA MI GUAGUA Y LA MISMA SE ACELERO SOLA Y LOS FRENOS NO LE FUNCIONARON, CAUSANDO QUE ME FUERA POR UN RISCO. LOS AIR BAGS NUNCA LE ABRIERON.