2024 GMC Canyon Complaints

SERVICE BRAKES — Filed 08/27/2025

I first noticed the brakes squealing in August 2025 at 15,000 miles. The dealership said I needed to resurface the front rotors. I mistook this a coating and brake debris, but it was actually the rotors warping. By 21,000 the vehicle is pulsing heavily when stopping. I went back to the dealer and this time they told me all 4 rotors are warped. GM denied coverage of the pads and rotors. Normal driving, no collisions or towing.

ENGINE — Filed 03/08/2026

Coolant leak caused by known manufacture defect in upper hose assembly causes coolant to drain and engine to overheat. CEL only comes on when coolant is almost gone. GMC refuses to cover the known issue after 36k miles.

ENGINE — Filed 02/10/2026

Coolant Leaking at 22K miles, smell of coolant, check engine light on and off 2X's. Coolant evidence on driveway and in engine cabin. Known condition for GM Model. No parts available for replacement. No recall for issue.

UNKNOWN OR OTHER — Filed 03/04/2026

Radiator Hose began to leak coolant. Faulty radiator hose. This could have caused engine failure and potentially caused an accident or may have put others at risk for hazards. No warning other strange sound. Inspected by authorized dealers service center.

ENGINE — Filed 02/24/2026

Upper radiator hose connection to radiator is faulty causing leak of coolant. Yes it is available for inspection upon request. Truck began to run cooling fan at full speed in the middle of winter with no warnings of high heat or low coolant. After two weeks, check engine light finally cut on to indicate low coolant flow. Coolant reservoir was subsequently checked and found to be completely empty. It is apparent this reservoir had been extremely low / empty for at least two weeks with no warnings. Without proper warning and leaking coolant, truck could have overheated. Should this had happened in dead of summer, truck could have very well overheated with no warning. The problem was investigated and confirmed by dealer as leaking coolant at the connection of the upper radiator hose to the radiator. Was quoted $983 to replace the hose. No warning lights appeared until issue had been ongoing for over two weeks. A quick search of "GMC Canyon Upper Radiator Hose" will reveal many identical occurrences of this issue. This is a safety hazard / design flaw that GM is not acknowledging and is putting the burden on the vehicle owners for their own issue.

ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE — Filed 11/07/2024

On 2 occasions the battery was drained and a tow truck had to jump the battery. On one occasion after the battery was jump started it took several hours before the brakes were able to be used and the car driven safely. Had to drive very slowly (under 50 mph) per note that appeared on dashboard. After nearly an hour of waiting Engine light stayed on and dealership ran diagnostic and found nothing wrong with the battery nor anything else. Have to start and run engine everyday to keep battery from dying. If not started in 24 to 36 hours, battery will die.

SERVICE BRAKES — Filed 01/19/2026

Upon starting the vehicle, I got multiple warning lights. The most important was brake failure. I had no brake function. I took it to the dealer and they replaced the brake module after 3 days.

ENGINE — Filed 01/19/2026

There are widespread reports of the O ring seals on the radiator and heater hoses failing and causing coolant leaks. These leaks are significant enough to render the vehicle inoperable and with no cabin heating or cooling. This could lead to life-threatening situations in adverse weather conditions. It could also create dangerous roadside failure situation in heavy traffic, particularly on interstate highways. Dealers are aware of the issue and are currently repairing vehicles under warranty. However some dealers are telling owners that the cooling system is not part of the engine and drivetrain, and therefor is not covered under the original factory warranty if the vehicle has exceeded the initial bumper to bumper warranty limits. Dealers are also telling owners that parts are on backorder due to high demand, and that repair wait times could take weeks. The vehicle is unsafe to operate with a known coolant leak. Video of leak (another owner) here. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 01/02/2026

Upper radiator hose attachment is leaking due to faulty rubber gasket. This comes up across GMC Canyon groups on Facebook 10 times a day. It is happening to ALL of them mainly pre 2025 on 3rd gens. Part is on back order at all GMC dealers due to so much volume of issue. Happening as early as 10k-20k miles on brand new trucks causing over heating issues due to coolant leaking out. Hopefully a recall for the part is done before engines start blowing.

POWER TRAIN,ENGINE — Filed 12/30/2025

Truck began idling very rough. Went straight to the dealership. They shut the truck off and it would not restart. No CEL or messages on the dash. Tear down reveled a failed exhaust valve in cylinder #4. Truck has 10,000 miles. A replacement engine has been ordered under warranty. Luckily, we happened to only be a few miles from a dealership when the failure happened. There was no warning, no prior symptoms what so ever.