2023 Hyundai Ioniq 5 Complaints

AIR BAGS — Filed 07/20/2026

There is a yellow air bag (SRS) safety restraint critical wire harness underneath the seats and it's loose and hanging down touching the floor with lots of slack, very easy for a water bottle or any object to roll under there and pull it loose, which would disable a critical passenger safety system. This issue is reported by many drivers including myself, photos attached are from multiple people's experiences with this issue.

SERVICE BRAKES — Filed 07/15/2026

The vehicle repeatedly displays a "Stop Vehicle and Check Brake System" warning together with an ABS warning, accompanied by a loss of normal braking response. On XXX, while driving at approximately 60 mph on I-85 northbound near Exit XXX in [XXX], the warnings appeared and the brakes did not respond normally. I was maintaining a substantial following distance, and the braking system restored itself before I reached the point of needing to brake hard, so no crash or injury occurred. Had hard braking been required in that window, I do not believe the vehicle would have stopped as commanded. This is a recurring fault. The vehicle, purchased certified pre-owned and still under the Hyundai factory warranty, has been taken to the dealer (Ed Voyles Hyundai, [XXX]) three times for the same condition. On the first visit the Integrated Electronic Brake (IEB) unit was replaced; on the second, the Smart Junction Box was replaced; on the third, the dealer removed an aftermarket tracking device wired to the data link connector and referenced Hyundai TSB 24-GI-011H, representing the problem as corrected. The braking-loss event on XXX occurred after that repair. The vehicle has been out of service approximately 30 days total. Because the failure is an intermittent loss of braking response at highway speed, I consider it a serious safety hazard and no longer drive the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM — Filed 04/21/2026

The contact owns a 2023 Hyundai Ioniq 5. The contact stated that while driving at higher speeds occasionally, the vehicle suddenly lost motive power. The "Smart Smooth Cruise Control Conditions Not Met" warning message was displayed on the instrument panel. The contact restarted the vehicle as a temporary fix; however, the failure recurred. The vehicle was taken to a local dealer where it was diagnosed with an unknown electrical failure. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the same local dealer; however, the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 47,000.

LANE DEPARTURE — Filed 07/05/2026

The ioniq 5 highway driving assist, which steers the car and keeps it centered in the lane, will disengage without clear warning - the small green steering wheel icon (which is at the top of the dash cluster) simply becomes grey and blinks, but there's no audible chime to indicate that the car has disengaged the steering assist. I have had multiple times on the highway where it disengaged and I don't notice (because I am looking at the road, not the dash) and one time on the highway it disengaged during a turn and hit the rumble strip, causing me to swerve back onto the road. My hands were on the steering wheel and I was paying full attention, but I was expecting the car to handle the turn, and it just disengaged without me noticing. Had there been another car in the middle lane or I reacted slower, it's likely a crash would have occurred. This has been documented as well on Reddit and confirmed by multiple owners, who have mentioned they have disclosed to the manufacturer: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STRUCTURE,UNKNOWN OR OTHER — Filed 07/04/2026

Rear hatch window spontaneously shattered for no apparent reason. Car was parked in a Florida parking lot, no use of rear hatch and no use of rear defroster. I understand there is a potential class action lawsuit for the Ioniq 5 model years 2022-2025 for this problem.

POWER TRAIN,ELECTRICAL SYSTEM — Filed 06/14/2026

I have a 2023 Hyundai Ioniq 5 Limited and had the ICCU "popped" (failed) which took about two weeks to replace. This time we were lucky that in happened at our home but had we been driving the car would it would have completed died. We regularly drive from from [XXX] to [XXX] were there are large section of [XXX] with no cell service. Meaning potentially walking for miles in extreme heat or cold. Hyundai right now seems only interested in continuously replacing the part rather than actually fixing the route cause, making it so the car is not trustworthy or safe to drive long distances. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 06/13/2026

1. What component failed, and is it available for inspection? The Integrated Charging Control Unit (ICCU) failed. The vehicle is currently at the dealer's service center, so the failed component is available for inspection upon request. 2. How was your safety or others' safety put at risk? After parking and re-entering the vehicle following a grocery stop, the vehicle displayed "Check Vehicle Electrical System" followed by "Check Vehicle Power Supply" warnings. This occurred without warning while the vehicle was in normal use, and the vehicle had to be towed since it was no longer driveable. The sudden, unannounced failure of the electrical/power system created a risk of being stranded in traffic or in an unsafe location had the failure occurred while driving rather than while parked. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The vehicle was towed to the dealer's service center, where the Hyundai-certified service technician confirmed the ICCU failed and informed us it needs replacement. 4. Has the vehicle been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by the dealer's Hyundai-certified service technician, who confirmed the ICCU failure. No additional inspection by Hyundai corporate, police, or insurance representatives has occurred at this time. 5. Were there any warning lamps, messages, or other symptoms prior to the failure, and when did they first appear? No warning lamps or messages appeared prior to the incident. The first symptoms were the "Check Vehicle Electrical System" and "Check Vehicle Power Supply" messages, which appeared suddenly upon re-entering the vehicle after a grocery stop, approximately one week after purchase (used) at roughly 8,000 miles.

ELECTRICAL SYSTEM,SERVICE BRAKES,FUEL/PROPULSION SYSTEM — Filed 06/02/2026

OnXXX, as we approached what I call the 6 o’clock position of a round-about in [XXX], we had braked almost to a full stop (0-5 mph) to wait on the car ahead of us to enter the round-about when we felt increasing movement. Despite braking, to wait on that car, our car with increasing speed started shoving that car into the circle. Fortunately, he was able to drive away from us, but that car had been damaged on the back and right side. With that obstacle out of the way, our car rapidly and exponentially increased speed - all while we were fully braking. Two witnesses said they saw our brake lights as we sped along. We hit the curb as we approached the 12 o’clock exit, and that turned us so that we crossed both lanes of the road and headed towards the far sidewalk and storefronts. When we hit that curb it pushed us diagonally to face the street again. Hard to estimate but we must have been doing 50 mph when we hit a very large brick planter and we finally were wedged to a stop when we slammed in between two vehicles parked parallel to the sidewalk. The motor ran for a few seconds after we stopped, and finally quit on its own. We KNOW the brake was applied the whole time; there were no visual or audible alarms from the car as we entered “UNINTENDED ACCELERATION”. Despite the incredibly strong impact (our car has been deemed totaled) the front air bags did not deploy. Only the driver’s side curtain deployed. The bumper of the parked transport van on our front left was damaged, and the small SUV on our front right was deemed totaled. No people were in those two parked cars; the first car was hit at the initial slower speed so those people were not injured. By some grace, no pedestrians were in our path or they would surely have been killed. The driver of our car (my husband) was miraculously not injured, but CT scans and x-rays showed I had several contusions and a fractured tibia that will require surgery due to brake, propulsion, no air bags. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER — Filed 05/30/2026

All symptoms of a 2nd iccu failure. Pop noise heard. Warning lights came on 12v drained, vehicle towed to nearest dealer.

POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 05/22/2026

Car indicated 12v battery was critically low and that I should stop safely. I was just starting it in a parking lot. This is a classic ICCU failure and the car is up to date on all recall updates. The car requires manual key unlocking for outside access at this point, and the rear hatch is only unlockable using the manual release mechanism which is recessed into the rear hatch and needs the key. The back two doors cannot be opened at all, from either direction and the handles don't work when the electrical system has failed and the child lock was engaged accidentally when it happened. This legitimately terrifies me for anyone traveling with back seat passengers who need quick exit. There isn't one.

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 05/14/2026

The Integrated Charging Control Unit (ICCU) failed on my 2023 Hyundai Ioniq 5. The vehicle stopped charging prematurely overnight via AC Level 2 charging and then refused to charge again at all. The ICCU is responsible for maintaining the 12V battery by topping it up during normal operation. No warning or check engine light came on, I was only made aware when I attempted L2 charging and the car would refuse to take the charge. I understand that with a failed ICCU, if I'm unaware of the failure (e.g., relies solely on DC fast charging which bypasses the ICCU), the 12V battery can deplete without warning while the vehicle is in motion, potentially causing sudden loss of vehicle systems including power steering, brakes, and other safety-critical electronics. The vehicle was parked at the time charging failure was discovered. No injuries occurred.

POWER TRAIN,ELECTRICAL SYSTEM — Filed 05/17/2026

The ICCU died a second time

POWER TRAIN,ELECTRICAL SYSTEM — Filed 01/14/2026

ICCU failed at 20,000 miles, 2 years after I first got the vehicle. Blue link showed the P1a9096 ICCU code failure. Car could not be driven for more than a few minutes then the message to stop safely came about and car would die. It took the dealer 2 months to replace the ICCU with the SAME defective part. It is only a matter of time before it fails again.

POWER TRAIN,ELECTRICAL SYSTEM — Filed 04/24/2026

My Hyundai IONIQ 5 has repeatedly lost 12V power and shut down. The vehicle had to be jumped by AAA multiple times. After being restarted, it died again, and after two days of use it was dead again. I am concerned this is related to the known ICCU / 12V battery charging issue affecting IONIQ 5 vehicles, which can cause loss of motive power or make the vehicle undrivable. The vehicle is currently at Hyundai Southern States in Raleigh, NC for diagnosis and repair.

ELECTRICAL SYSTEM,STRUCTURE,UNKNOWN OR OTHER — Filed 04/04/2026

On XXXXX, while parked at a campsite approximately two hours from my home, the vehicle displayed an “electrical failure” warning on the dashboard. The vehicle had been parked for less than 20 minutes when this issue occurred. I contacted Hyundai customer support that same evening to report the problem (Case #XXXXXX). On April 4, 2026, the vehicle was towed via Hyundai roadside assistance to Winner Hyundai in Dover, Delaware, where Tracy is my current point of contact. This situation left my family of four, along with our belongings and pet, stranded without transportation. Despite significant effort, we were unable to secure a rental vehicle in the Dewey Beach area, even after contacting multiple rental agencies and the dealership directly. This was later resolved, and I am currently in a rental through Enterprise; however, the stress and uncertainty of potentially being stranded was significant and unacceptable. While at the dealership, my wife witnessed the tow operator unloading the vehicle without proper equipment to safely lower it. As a result, the vehicle’s hitch made forceful contact with the pavement and became lodged. Multiple dealership employees observed the incident. After considerable effort to free the vehicle, it was released abruptly and rolled into another vehicle on the lot, causing additional damage. An argument then occurred between the dealership owner and the tow operator, which my wife was forced to witness. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 02/19/2026

7 incidents of electrical drive problem incidents 1-3car would not start despite full battery Incident 4 same thing and car went to dealer, they said know problem and they would fix it overnight by downloading new software and charge about 400 for new 12V battery Incident 5 While on freeway using cruise control card speed varied wildly I disabled cruise control and with manual throttle same problem Incident. 6 In middle of traffic car went blank no lights or anything. I tried to restart 3 times and nothing, so I sat back and was in process of calling for tow. I did nothing and car violently accelerated and turned into steel pole. Only injury I had was bump on head that went away. As soon as the ghost mode engaged I hit the brake which likely prevented more damage to me, but front end of car was damage Incident 7 While I was detained someone else drove car to dealer and driver reported felt like driving on ice with rapid direction and speed changes Currently at dealer where neither dealer or Hyundai will take of problem and I get run arround from Hyundai and dealer. Dealer claim the don’t know is the problem. Dealer has had car for approximately 65 days Bottom line, the car is totally unsafe to drive and very dangerous

BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE — Filed 11/28/2024

The rear video camera fails intermittently. It works sometimes and doesn't at times. The same with the rear cross traffic warning and pedestrian warning. I've taken my car to the dealer service center but they claim to not being able to reproduce the issue. I know the issue still exists since my husband hit a parked car while backing out of a driveway since there was no alert provided and the rear camera did not work.

VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE — Filed 07/28/2024

Incident occurred when head-in parking in a space pointed into an stores exterior wall. There were no parking/wheel stops, just pavement then wall. No adjacent cars. I was decelerating with foot completely off accelerator and over the brake pedal. The car is an EV and was in 3rd level of regenerative braking, slowing down quickly. As I completed the turn into the space and began straitening the wheel, the car suddenly and rapidly accelerated and crashed into the wall. The only likely explanation I have is that I inadvertently pressed the Driving Assist button with my right thumb or hand while turning the steering wheel, which would have activated Smart Cruise Control, and, if the necessary conditions were met, set the minimum speed to 30 km/hr. The car manual states: "If your vehicle speed is between 0 - 20 mph (0 - 30 km/h) when you press the Driving Assist ( ) button, the Smart Cruise Control speed will be set to 20 mph (30km/h)." The Foward Collision-Avoidance Assist was set to Active Assist, which should have applied the brake to stop from colliding with the wall, but instead the car accelerated. (Note, the parking assist feature does not usually recognize head-in parking.) The car has two Driving Assist settings: Based on Drive Mode and Based on Driving Style. If the latter is selected, three additional features are set on sliding scales: Distance (close to far), Acceleration (slow to fast), Response Speed (slow to quick). These three settings are adjusted automatically based on the car's interpretation of the driver's driving style, or they can be manually overriden. I have never changed these settings. Post-incident I checked the setting and it was set to Based on Driving Style with Acceleration=Fast. Concerns: Is Driving Assist to easy to inadvertently activate? Should Driving Assist not activate at very slow speeds and not auto-set to 30k/h? Why did Forward Collision-Avoidance not activate? Drive Assist should not default to Based on Driving Style.

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 07/04/2024

Charging port burned during DC fast charging session, resulting in melted charging pin. Unable to insert CCS connecter due to melted pin obstructing insertion. Further damage to electrical systems unknown. No warning signs shown aside from vehicle charging session ending. Lack of safety systems to prevent melting/burning of charging pins leaves potential for general vehicle fire, battery fire, etc. Dealer has had car in possession for over 10 days with no update. Corporate contact has been unresponsive.

VEHICLE SPEED CONTROL,SERVICE BRAKES — Filed 01/07/2024

When parking in a supermarket parking lot I slowly approached the space while braking. As I turned left into the space and released the brake pedal to allow the car to slowly roll into the space as I always do, the car surged as if someone floored the accelerator. I veered left to avoid a head on collision with the parked car facing me and went diagonally between the right front fender of that car and the left front fender of the car parked in the space to my left. I sideswiped both sides of my car and damaged the front fenders of both cars before I was able to apply the brake and bring the car to a stop. There was a mother with her two young children loading groceries into the car in front of me. Fortunately I avoided hitting anyone, but the witnessed the accident. I was in shock. My car suffered $25 in damages. There is absolutely no way I accidentally applied the accelerator, and if I had I would never have floored it! The car malfunctioned. I reported this incident to Hyundai also. They supposedly were sending someone to inspect the car at the auto body repair center.

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 12/30/2023

12/30/2023 at approximately 5:30pm I drove home with the iPedal engaged. The iPedal was installed as a download to the car in August 2023. My daughter was in the passenger seat. I began to back into my driveway but shifted to Drive to straighten out the car. The car began to roll forward I took my foot off the accelerator but the car did not stop in spite of the iPedal being engaged. I put my foot on the BRAKE PEDAL which went all the way to the floor to no avail. The car rolled slowly into an electrical pole which brought the car to a stop. I previously filed a complaint here but I have since learned that iPedal may disengage if the car is put into reverse. There is not warning light to alert the driver that iPedal is disengaged so the driver is not aware that the brakes may not work as expected. I believe this may have been the case with my accident. However, this does not address why using the foot pedal for the brakes did not stop the car. Have found many complaints about this on various forums and believe this aspect of iPedal needs to be addressed. It should not disengage unless the driver instructs the car to do so. I have not been able to find documentation of this functionality in the manual, but I have searched and will continue to do so.

POWER TRAIN,FORWARD COLLISION AVOIDANCE — Filed 01/04/2024

Driver was moving forward into a space in a parking garage between two other vehicles. Driver had pulled most of the way in and was slowly inching forward. As the car came to a stop, it suddenly lurched forward, hitting a concrete wall. The collision warning system did not alert, and auto-braking did not occur. The car was in Regen Level 3, and Auto Hold was not activated. In the months prior to this, the car twice had a similar situation when coming to a stop at an intersection with foot on the brake, then suddenly lurched forward, nearly rear-ending a car in front. There was no visible damage to the concrete wall, and a police report was not made. Hyundai says they want to inspect vehicle, but have not done so after a month. It is easy to believe that this was driver error, but it absolutely was not. Car lunged forward and accelerated into a wall with only the brake being applied. All of these events have occurred after the Hyundai Ioniq 5 software update was applied on 26 Sep 2023.

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 12/30/2023

12/30/2023 at approximately 5:30pm I drove home with the iPedal engaged. The iPedal was installed as a download to the car in August 2023. My daughter was in the passenger seat. I began to back into my driveway but shifted to Drive to straighten out the car. The car began to roll forward I took my foot off the accelerator but the car did not stop in spite of the iPedal being engaged. I put my foot on the BRAKE PEDAL which went all the way to the floor to no avail. The car rolled slowly into an electrical pole which brought the car to a stop. Neither iPedal nor the foot brake pedal had any effect on the car. I then put the car in reverse and backed the car into my driveway and the brakes worked as expected. When I then attempted to charge the vehicle, the charging port would not open. I could hear the motor working to open but it would not open. On 1/11/2024, I again attempted to open the charging port and this time it did open. So, TWO different electrical (including the brakes and the charging port) were not working properly. Inasmuch as the charging port again worked and the brakes again worked, there clearly was a malfunction that was random and unpredictable and also nearly impossible to reproduce but if this happened once, it could happen again. The brakes failed. Had we been traveling on a busy road, or at the top of a hill, we would have faced significant bodily harm, death to ourselves or others. This car had been driven locally, predominantly on local roads. The car is available for inspection and has only been driven on the dealer lot since the the incident. There were no warning lights or messages to indicate that any issues existed. The manufacturer has executed an inspected but has not reproduced the problem. The manufacturer and dealership claims the car is safe to drive without addressing the brake failure. I do not believe the car is safe to drive without a determination of how the bake failure happened or without a repair to that issue.

AIR BAGS,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 12/23/2023

The car proceeds by itself and does not stop even when brakes are engaged. This happened 2 times. Once in reverse and once forward, both caused severe damages to the car. In the forward incident, the driver was wearing seat belt but air bags deployed with impact.

ELECTRICAL SYSTEM,SERVICE BRAKES,BACK OVER PREVENTION — Filed 09/23/2023

Intermittent Electrical / Brake failure . Put vehicle in reverse . Brakes failed to stop vehicle . Vehicle has had electrical issues before . Waring lights came on for steering and tire pressure in the past . Recall then came from Hyundai for the ICCU .45 minutes before the collision, the front collision warning came on when I was stopped at an intersection with no one in front of me . I stopped the vehicle and turned the vehicle off . Turned on the vehicle and it reset the warning lights and sounds , and I continued to drive . Later while pulling out of a parking space in reverse ,I stepped on the brakes but the vehicle did not stop . I pumped the brakes to no avail . After the collision , the brakes worked again when the tow truck driver placed the vehicle on the flatbed .The Hyundai dealer , after the vehicle had been in their possession for several weeks with the battery disconnected, said there was no problem They also had a factory rep look at the vehicle and he made a report . We have not been able to get a copy of the report . Vehicle is still at the dealership . When notified by the factory rep of their claim that the vehicle had no problems , the vehicle had been out of service more then 30 days .