2015 Hyundai Sonata Complaints

ELECTRICAL SYSTEM — Filed 07/02/2026

This vehicle had a recall, 201, for the smart junction box. This was due to the blinkers not working properly. The software update was performed, however, the problem still exists. This was due to the smart junction box. Now, aside from the blinker issue, the ac stays on when the engine is turned off, lights come on by themselves, the media screen goes randomly into night mode, daylight running lights are constantly in night mode, smart junction box failure. I have not taken this to a mechanic as of yet, the dealership is aware, and I opened a case with Hyundai case #42940056, however, I have not received a call from my service advisor or Hyundai. They offered to do diagnostics, but, if these problems are not about the safety recall, I would have to pay $350 for diagnostics, unless I get the problem fixed by them. This car has 66k miles with a new engine installed at 59400 miles! At this point, I have the car parked, battery disconnected, and looking for the most efficient way to fix the problem, which must be performed by specialized equipment.

ENGINE — Filed 06/22/2026

On June 22, my 2015 Hyundai Sonata suddenly lost all electrical power without warning. The vehicle stalled and would not restart. There were no warning signs beforehand. After the incident, the car had no electrical power and was inoperable. Further inspection determined that the engine had failed and required replacement. I maintained the vehicle with regular oil changes and was unaware of Hyundai’s Service Campaign 953 (KSDS update). I was never notified that this campaign needed to be completed, and I believe that failure to receive notice contributed to Hyundai’s denial of my engine replacement claim. I purchased the vehicle December 19, 2019. I was never notified by the dealer or manufacturer

ENGINE — Filed 06/30/2026

I had the Service Campaign 9C2 and TSB 25-01-087H recall emissions update performed. I immediately noticed degraded performance with my vehicle. It's very jumpy/stuttery after I first start driving and feels less responsive. Even after driving for a bit, it feels like it drives and shifts oddly. It is not as smooth as it used to be. My car drove fine prior to the update and immediately felt different after the update. It's now been over a week and it's still like this, so it's not the engine computer adapting or something like that.

ENGINE AND ENGINE COOLING — Filed 07/09/2025

The contact owns a 2015 Hyundai Sonata. The contact stated that while operating the vehicle, exhaust fumes were noticed inside the cabin, and the check engine light illuminated before the engine stalled. The vehicle was towed to a local dealer. The cause of the failure was not determined. The manufacturer was notified of the failure. The failure mileage was unknown.

ENGINE AND ENGINE COOLING — Filed 07/02/2026

The contact owns a 2015 Hyundai Sonata. The contact stated that the vehicle was taken to a local dealer who performed an emission software upgrade. Later, while driving, the air conditioner blew hot air, the thermostat increased to high, and an engine overheating warning message was displayed on the instrument panel. The vehicle was taken back to the dealer, who diagnosed that the thermostat had failed and needed to be replaced. The thermostat was replaced, and the failure was remedied. The manufacturer was notified of the failure. The failure mileage was 74,000.

ENGINE — Filed 07/04/2026

Engine misfiring and low compression

ENGINE — Filed 12/31/1969

Oil consumption

POWER TRAIN — Filed 07/01/2026

VEHICLE: 2015 Hyundai Sonata, 2.4L Theta II GDI engine Mileage at time of incident: [ 93k Date update performed: June 2026 Dealer/location where update was performed: Fitzgerald Hyundai Gaithersburg, MD DESCRIPTION OF PROBLEM: After my vehicle received the ECM software update issued under Hyundai Service Campaign 9C2 (ECU Software Update for Theta II Emissions Improvement, TSB 25-01-087H / 26-01-013H-1), the vehicle began exhibiting noticeable jerking/hesitation during acceleration that was not present before. For this vehicle this happens consistently after a cold start then does not happen again.

POWER TRAIN,ENGINE — Filed 03/16/2026

The incident began following a routine maintenance visit on March 16, 2026, and has been a continuous, ongoing safety hazard every single day since. While the vehicle was in for routine brake service and an oil change, the dealership automatically applied an open, manufacturer-mandated ECU S/W Update THETA II (26-01-013H-1) under Service Campaign 9C2 Emissions (Code NP001-SC9C2) without my prior knowledge of its drivability side effects. This software flash directly compromised the vehicle's powertrain logic, creating two notable, daily safety failures. First, within the first 5 minutes of engine startup, and most pronounced on every cold engine startup, the throttle delivery is highly erratic, causing uncommanded low-speed surging. In a specific incident in a parking lot following a cold start, I accelerated to approximately 15 MPH and completely removed my foot from the accelerator pedal to coast. Instead of slowing down, the vehicle unexpectedly lunged and pulled ahead forcefully against my intent. Second, even after reaching full operating temperature, the vehicle completely loses safe and predictable engine braking at greater speeds; when lifting off the gas pedal, engine RPMs aggressively drop, causing the vehicle to coast freely as if in neutral. Re-applying the accelerator causes a violent "phantom shifting" downshift and a hard transmission lockup. My safety and the safety of others are put at risk every time the vehicle is driven. The low-speed throttle surging creates an ongoing risk of hitting pedestrians or cross-traffic, while the permanent loss of predictable engine braking drastically extends stopping distances. No warning lamps or diagnostic trouble codes (DTCs) appeared prior to or during these continuous failures. The vehicle remains available for inspection.

ENGINE — Filed 02/14/2025

On October 2024,I brought the car in to RickCase Hyundai for maintenance and to address an oil leaking issue. I texted the service advisor, “Please do not do the oil change till you find out where the oil is leaking”, I’m replacing it frequentlyWhen I picked up the car and inquired about the leaking, the he told me that there was not an issue. January 2025, the car was driving rough again, noticed the oil low and filled it up. February 2025 driving on 595, The car stopped. I had it towed to Rick Case, they told me I needed to replace the piston. I said no this has to do with the oil consumption issue that I brought the car in October that you never addressed. The four new spark plugs that were put in were burnt on the tips. They went through the warranty issue to get the engine repaired and it was denied. I said this is not a warranty issue. This was a mistake on your part because you never address the oil consumption issue in October 2024. As of June 12,2026, the dealership still has my car. When I call and ask, What’s going on with my car. The only response I get is we are trying something else it’s going to take some time. Last summer, the service advisor told me he was going to fix my car, wanted me to come pick it up and drive it for 1000 miles and bring it back. They couldn’t fix the car. They never offered a loaner. The vehicle suffered a catastrophic engine failure and completely stalled in the middle of a live road, creating an immediate highway safety hazard. the vehicle is still being held at Rick Case Hyundai Weston for over a year regarding excessive oil consumption issues, which the dealer failed to resolve. The vehicle has 85,000 miles and a complete maintenance history. Hyundai Corporate is currently denying a replacement engine under the active engine settlement framework, leaving a known stalling safety hazard unresolved."