2023 Kia EV6 Complaints

ELECTRICAL SYSTEM — Filed 06/10/2026

ICCU failed and replaced under warranty

POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 04/27/2026

First ICCU the power completely went out on 2/23/26. Power went out again April, 2026. Currently car is immobile and unreliable and not safe for driving due to power failures. Towed car to Kia Cerritos. Car supposedly "fixed" (with other issues I've reported to KIA of America & CA BAR/DMV) Currently 12V battery is not holding charge as of 4/27/26, 4/28/26, and 5/2/26. I received a letter from KIA stating ICCU and inability to charge, Keep this Letter in your Glove Box for a free diagnosis and possible no cost servicing. As an older American this is inherently unsafe, as I travel for work and cannot be stuck on the road. The vehicle suddenly loses power in traffic. It simply stops running. This is my 5th attempt to file this very complaint between April and 6/14/26.

POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 05/14/2026

ICCU failure, a well known issue with these cars.

ELECTRICAL SYSTEM,ENGINE — Filed 05/14/2026

Iccu failure with Kia ev6. Unreal that this car has not had a recall yet. It is totally unacceptable that this car can at any time fail. Car will not start and shut down while I was driving. Luckily I was beginning to park when it happened

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 05/05/2026

The ICCU unit failed. The message "Check Electrical System" appeared on the instrument cluster. Low-voltage battery voltage was 12.0V and vehicle speed was limited to 60 mph. Maximum speed was gradually reduced to 30 mph over a period of 40 minutes (voltage was 11.5 V) with minimal 12V loads. I pulled over and called a tow truck to the nearest service center. Kia confirmed the ICCU was defective and replaced the part under warranty.

POWER TRAIN,ELECTRICAL SYSTEM — Filed 04/14/2026

ICCU failed despite all prior recall updates being performed. Incident began when home circuit breaker tripped; vehicle subsequently refused Level 1 charging with "Check Electrical System" warning. Per dealer suggestion, tested public chargers. Level 3 (DC) worked, but upon connecting to Level 2 (AC/J1772), a loud "pop" occurred, and the public charging station immediately suffered a mechanical failure/shutdown. Vehicle then displayed "Stop vehicle and check power supply," and was unable to drive above 40mph (with a turtle icon visible on the dash) once I pulled away from the charging station. This created a significant safety hazard while navigating traffic. Within two hours, the 12V battery was completely depleted; vehicle was unresponsive and required a jump-start for towing. Dealer confirmed ICCU failure requiring replacement. The fact that the vehicle's internal failure caused the immediate malfunction of public infrastructure is deeply concerning, as was the loss of motive power on the road.

ELECTRICAL SYSTEM — Filed 03/16/2026

My vehicle has been in the possession of Koons Kia of Owings Mills since March 15, 2026, for diagnosis and repair of this issue, with service beginning March 16, 2026. During this time, the dealership has replaced the 12-volt battery and performed a software update; however, the defect has not been corrected. On April 10, 2026, I was notified that the vehicle was ready for pickup. When I arrived on April 11, I found that the battery was completely discharged and the issue had not been resolved. Because the vehicle was not operational at the time of attempted pickup, it was not returned to me and remained in the dealership’s possession. I was contacted again on April 13, 2026, and informed that the vehicle had been repaired. When I returned to the dealership on April 14 to retrieve the vehicle, I again found that the battery was discharged and the defect persisted. As a result, the vehicle was not returned to me and has remained continuously in the dealership’s possession since March 15, 2026. As of today, the vehicle has been out of service for more than 30 consecutive days due to this defect, and multiple repair efforts have failed to resolve the issue. This ongoing condition substantially impairs the use, value, and reliability of the vehicle.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM — Filed 07/05/2025

*ICCU assembly and ICCU fuse fault (a kia recall SC327( NHTSA ID: 24V867000) for ICCU was performed months early but does't help AND iccu crash) *yes - cars stop workind in the midle of nower at 317 mile away from home with 5 persons in) *yes ( kia already performed recall SC327 for our car but doest help and the ICCU crash) *yes *yes-vehicle broke down while driving.Had to be towed to closest Kia dealer(the incidend hapened 317 miles away from our home Dacula GA 30019)

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 03/04/2026

Got in my car to leave a store and heard a loud pop and noticed a smell like an electric motor burning. Backed out of my space to drive home and the car displayed several error messages- Check electric vehicle system, turtle mode, power reduced. I was stranded and had to order a tow truck to be towed to the dealer and get a ride home.

ELECTRICAL SYSTEM — Filed 04/17/2026

ICCU on my Kia EV6, this is a known issue, shouldn’t be bound by miles, as it’s not a mileage issue or concern! The warning was Stop Vehicle Check Power Supply!