2025 Kia EV6 Complaints

ELECTRICAL SYSTEM — Filed 06/21/2026

Driving on three lane highway at 60 mph the car abruptly lost power. Was able to get off the highway. Called Kia roadside assistance. Tow truck picked up car and delivered it to Kia dealership. Service dept diagnosed and is replacing the ICCU.

ELECTRICAL SYSTEM — Filed 05/29/2026

While charging at a L3 station, charging was interrupted with a pop (which turned out to be ablown fuse). Two warning lights appeared on the dashboard (battery and vehicle with exclamation points) as well as message to "Check electrical vehicle system". Kia Connect told me to exit the vehicle and that it would need to be towed to the dealer. Dealer Service Office confirmed it was not safe to be in the vehicle nor to drive it. Car had only 2311 miles at the time! From the dealer invoice the KDS was inoperative at the time. Fault codes: P1A961C LDS Internal Power Supply out of Range and P1A9096 LDC Input Voltage Sensor Component Internal Failure Confirmed 12V battery no charging in ready on. Live data does not match given good values. LDC input voltage ~2V, LDC Output voltage 11.4C Dealer replaced ICCU and ICCU HV Fuse. Filled and bled cooling system. Verified vehicle charges on L2 charger. (Note I had been charging on an L3; this has not been verified.) I was told the ICCU ASSY had a new part number and was coming from a different factory. This part had a cost of nearly $5000 but was covered under warranty. HV fuse also replaced under warranty.

ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 05/10/2026

While driving car began to decelerate and the dash lit up with a number of ABS/Brake system failure symbols. I was on the highway traveling at abt 70 mph when the issue happened. Got car to coast off hwy onto an upward sloping exit. Stopped at a light. Turned off and back on and was able to gain minor speed got approx three blocks to a gas station. Pulled off and tried restarts. The screen stated there was an update pending, but it could not complete it because the Electronic Brake System failed. I tried triggering a brake reset but it didn’t work. Car was towed back to Dealership. Two days later the Dealership mechanic confirmed the issue was a failed Electronic Brake which must be replaced. Car has now been with Dealer for 10 days. Dealer stated the EBS was on back order and they do not have a timeline for the parts to come in. They’ve provided me a rental from their fleet which they are covering in full. Hoping this is resolved soon.

STRUCTURE,VEHICLE SPEED CONTROL — Filed 05/14/2026

While maneuvering my Kia EV6 into my garage, the vehicle accelerated unexpectedly and struck the garage wall. I believe the acceleration may have been unintentional or due to a malfunction. I request review of any vehicle event data

FUEL/PROPULSION SYSTEM — Filed 04/28/2026

2025 KIA EV6 ICCU (part#36401 1XFD5) failed at 2,658 miles. Failure occurred when power was applied after reversing out of a parking space, switching to drive and applying power. No safety issues as vehicle remained controllable. Vehicle went into "limp" mode. Build date of vehicle is 6/20/2025. KIA Dealer has replaced failed ICCU with updated unit (part#36400 1XFD6). No indication of failure occured prior to the failure (an audible "POP" heard from the rear cabin when the unit failed).

ELECTRICAL SYSTEM — Filed 04/30/2026

As I was driving, there was a loud pop that came from the rear of the car. The vehicle immediately flashed a warning to “check electrical systems”. I pulled over as quickly as possible but was faced with reduced acceleration. I ended up stuck in a parking lot awaiting a tow truck for over an hour with my dog and my wife in the car headed to a surgery appointment. The dealership has not confirmed anything but from research it seems to be a known issue that Kia has not addressed.

ELECTRICAL SYSTEM — Filed 04/27/2026

ICCU failure at 900 miles

ELECTRICAL SYSTEM — Filed 04/26/2026

Loud pop and Check Electrical System Message - limited ability to drive due to ICCU no longer charging 12V battery. Car no longer able to drive.

ELECTRICAL SYSTEM — Filed 04/17/2026

While driving Friday 4/17/26, I heard a pop and the car displayed a message to "Check electric vehicle system." The car seemed to still drive so I drive it home. That evening the car would not charge. I called Jim Shorkey Kia on 4/18/26, where I bought the car, to schedule the car to be looked at. They told me to bring it in on Monday and they will try to squeeze me in so they can diagnose the issue. Later that morning, I took that car out and made it about a block away before the car displayed a new message to "Stop vehicle and check power supply." At this point, the car went into a limp mode, barely moving. I was able to turn around and drive it home. Had I been on the highway, I might have been put in a dangerous situation. Now that the car has been diagnosed, the service department called and told me that the failed component was the ICCU. From what I've read, Kia claims that 1% of cars suffer from this issue. However, this percentage seems unlikely due to the number of online complaints. I wanted my experience to be an official documented case of this since I've heard that Kia has issued limited recalls in other countries and on older model Kia EV6's in the US.

UNKNOWN OR OTHER — Filed 04/07/2026

KIA has created a safety hazard by removing the ability for the driver to select LIGHT or DARK mode for the two 7" data and infotainment screens in their 2025 and forward EV6 electric cars. Like many, I have to drive in very fast busy commuter traffic on highway I-66. (exaserbated by driving into the sun in the AM) The DARK mode screens have insufficient contrast even with the screen lighting turned all the way up. It takes the drivers eyes away from the road longer than is safe, particularly in high speed freeway commuter traffic. This is seriously exacerbated if the driver uses sunglasses because of the sun. This is obviously not an issue confined to highway I-66, or me.