2021 Kia K5 Complaints

POWER TRAIN — Filed 04/15/2021

From the get-go seemed to have trouble with transmission once in a while Little jerk when shifting gears, reported this, they could find nothing. It has become a lot worse. It has caused the car to shut down into limp mode with engine light on. So I had a problem from the beginning with my new car. But when they check it, they can’t find a problem. So I’m just checking to see if anybody else with this car make, model, year have reported anything the same.

SERVICE BRAKES,ENGINE,FUEL/PROPULSION SYSTEM — Filed 10/07/2026

I am filing a safety complaint regarding my Kia K5 because I am concerned about a potentially dangerous mechanical defect. I purchased this vehicle used from CarMax approximately two years ago. Within the first 30 days of ownership, the steering wheel began shaking. CarMax repaired the problem at no cost after ordering a replacement part. Approximately two weeks ago, the steering wheel began shaking again. The problem has now progressed to the vehicle shaking, feeling as though it is skidding or slipping, and failing to accelerate properly. The check-engine light is illuminated. I contacted Kia regarding recall SC250 and was told that my vehicle does not qualify. I am concerned because my vehicle is now experiencing symptoms that I believe warrant investigation into whether they could be related to the defect addressed by this recall. I am requesting that NHTSA investigate whether my vehicle may have an unresolved or related safety defect, and whether other vehicles excluded from the recall could be experiencing similar problems. I am concerned about the risk of losing acceleration while driving, potentially putting me and other motorists in danger. I can provide my VIN, vehicle mileage, repair history from CarMax, and any diagnostic information available.

POWER TRAIN,ELECTRICAL SYSTEM — Filed 09/22/2026

65k miles. Started driving, 20 minutes into driving i was stopped at a round about then I went to accelerate and nothing happened my engine revd really loud and after about 10 seconds my car jolted forward and I was able to accelerate, this would happen every time I stopped and anytime a wanted to accelerate to another gear

STRUCTURE,FUEL/PROPULSION SYSTEM — Filed 07/23/2021

2021 Kia K5 99K1ZRECALL Gas tank expanded and deformed the body, noticeable under back seat. Risk of gas leak or fire Kia of Mckinney service center has vehicle unrepairable SC356 KIA has case # 26282908 No symptoms, driver complained stopping was jerky CAN'T FIX CAR AND WON'T REPLACE IT.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 09/07/2026

Vehicle experienced a severe engine misfire (P0302), rough running, and loss of power while driving. Dealership confirmed the Purge Control / PCV valve failed (replaced under Recall SC356 / 25V-794), but charged out-of-pocket for the Cylinder 2 ignition coil that failed as a direct result of the PCV valve failure. The Dealership replaced the Purge Control/PCV valve at this time - the recall was not resolved until this time - I wasn't even aware of this recall until this incident. This ocurred on XXX and as a result I was stranded 1500 miles from home in [XXX] (I live in [XXX] and was driving the vehicle to my son at the University of XXX in [XXX]. The car was running fine until I stopped briefly in [XXX] and when I started the car, the engine light came on and the car's engine started sputtering and losing power as I was driving. Due to the fact that I was not in the vicinity of any Kia Dealerships or any open mechanics as it was Labor Day, I somehow managed to drive the car all the way to [XXX] as this was the closest dealership (over 120 miles away from where I was when the engine light came on). Once I arrived in [XXX], I checked into a hotel. I then attempted to drive to the nearest Kia Dealership the following morning at approximately 6:45 am and the engine light started flashing. I knew that this meant I was not able to safely drive the car even the additional 5 miles to the dealership so I pulled over and called Kia Roadside assistance and the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER — Filed 08/27/2026

The panoramic glass of the sunroof exploded out while driving on the freeway. A large piece of the glass exploded outwards and could not be retrieved. It was not damaged by external impact as other cars were not close enough to kick back rocks, debris, etc. The sunroof glass had no damage prior to shattering. Hazard lights were turned on to drive to the nearest exit, and subsequent accident happened when a speeding vehicle crashed into my vehicle. This happened on the freeway driving 75 mph causing a road hazard, the glass that shattered out could have hit vehicles behind my vehicle, causing damage or a crash. The vehicle has not been inspected by the dealership or insurance company as of yet. There were no warning signs or symptoms of failure.

ENGINE AND ENGINE COOLING — Filed 08/24/2024

The contact owned a 2021 Kia K5. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The failure was a recurring failure. The message "Not Emissions Ready" was displayed. The vehicle was towed. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000.

FUEL/PROPULSION SYSTEM — Filed 08/17/2026

I am reporting a violation of the National Traffic and Motor Vehicle Safety Act by Ball Kia (National City, CA). The dealer tried to deny service for recall 25V794000 (SC356) for a melted, leaking fuel tank, fabricated a false diagnostic narrative of road impact to exploit me, and tried to charge $3,000 out-of-pocket for a federally mandated free repair.My vehicle has a severe fuel leak from a compromised fuel tank. Ball Kia service refused the recall, claiming "external aesthetic factors" or "road debris impact" caused it, and pressured me to tow it away.Using my military infantry experience in mechanical damage assessment, I inspected the vehicle in the service bay. I verified there is absolutely no puncture, tear, scrape, or kinetic impact on the fuel tank assembly. The dealer pointed to a split in the fuel tank protector panel, but a professional assessment shows this is false. The plastic protector panel failed due to extreme thermal exposure; the expanding tank pressed it against the hot exhaust, causing it to melt and tear under heat/pressure, not a kinetic strike.The tank itself is structurally melted and deformed with zero signs of road impact. This physical evidence matches the exact defect mechanism in the NHTSA recall: a deteriorated check valve allows intake pressure into the fuel tank, causing it to expand, hit hot exhaust components, melt, and leak.Only after I read the exact NHTSA safety risk and remedy text verbatim did the service manager back down and open a manufacturer Tech Line.Because I had to fight a fraudulent diagnosis to get this safety mandate acknowledged, I fear internal dealership retaliation, being blacklisted, or receiving a subpar, dangerous repair. Leaving a high-risk fire defect unaddressed is a public safety hazard. Please audit Ball Kia's handling of campaign 25V794000 to ensure they are not endangering or defrauding other affected Kia K5 owners.

FUEL SYSTEM, GASOLINE — Filed 07/16/2026

The contact owns a 2021 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline). The vehicle was taken to a dealer for the recall repair. The contact was struggling to receive updates on the status of the vehicle. The contact spoke with a service clerk and was informed that the repair was going well and that only one recall test remained. However, a supervisor later called and stated that the recall repair could not be completed. The vehicle could not be repaired. The vehicle was no longer functional due to a high risk of catching fire from fuel tank swelling caused by the recall defect. The contact stated that prior to the dealer visit, the vehicle had no issues but became inoperable. The vehicle was not repaired, and the dealer stated that the vehicle could not be repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 111,000.

ELECTRICAL SYSTEM — Filed 07/31/2026

Wiring harness has melted at the HVAC connection point.

POWER TRAIN,FUEL/PROPULSION SYSTEM — Filed 07/28/2026

Recall NNK post-repair failure. Dealership: Kia of Valdosta (RO# XXX). After ECU update NNK-02-0118, my K5 suffered a severe loss of acceleration and torque. The car cannot safely merge on highways. The dealer’s own live scan data sheet proves that at 4,997 RPM under full load, the Turbo Recirculation (Dump) Valve reads "OFF". The factory tool key explicitly states (OFF = Open). The service manager is misreading the tool, claiming "OFF" means closed, and refuses to fix it. The boost gauge only rises under heavy floor acceleration, proving an uncalibrated boost leak. I have uploaded a photo of the technician's data sheet directly to the attachments and will also drop link to videos of my car in normal and sport mode. I have also opened Kia Corporate Case #XXX. I demand a corporate Regional Technical Manager review this data and authorize a Turbocharger Recirculation Valve (RCV) and Wastegate Adaptation Relearn at an alternate dealer...... 1. [XXX] 2. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL SYSTEM, GASOLINE,TIRES,ENGINE — Filed 07/22/2026

The contact owns a 2021 Kia K5. The contact stated that while driving approximately 55 MPH, the fuel gauge suddenly went from one-half tank to empty. The fuel level displayed 120 miles to empty. The contact attempted to refuel the vehicle but was unable to add fuel to the tank. The contact also stated that the oil warning light and the TPMS warning light was illuminated. The contact associated the failure with NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 119,185.

FUEL SYSTEM, GASOLINE,SEATS,ENGINE — Filed 02/22/2026

The contact owns a 2021 Kia K5. The contact stated that there were failures with the spark plugs. While driving at an undisclosed speed, the vehicle shuddered, and the engine sputtered. The contact stated that fuel spewed out of the filler neck while refueling the vehicle, and the fuel gauge incorrectly indicated that the fuel tank was empty after refueling. Additionally, there was an abnormal egg and sulfur odor coming from the vehicle with the check engine warning light intermittently illuminated. The contact stated that the vehicle was taken to a local dealer and inspected under NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline). During the inspection, the seats were damaged. The vehicle was not repaired. The manufacturer was notified of the failure and was negotiating a buyback. The failure mileage was approximately 120,000.

FUEL SYSTEM, GASOLINE — Filed 07/08/2026

The contact owns a 2021 Kia K5. The contact stated that while driving approximately 55-60 MPH, the fuel tank expanded. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was determined that the fuel tank had expanded, and that the vehicle was unrepairable. The vehicle was not repaired. The dealer offered a buyback. The manufacturer was not contacted. The failure mileage was approximately 115,000.

FUEL SYSTEM, GASOLINE — Filed 07/18/2026

The contact owns a 2021 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 70 MPH, upon further inspection the fuel level was lowering unexpectedly. The check engine warning light was illuminated. The vehicle was taken to a local Auto Zone and was scanned with an OBD2 scanner and diagnosed with a recall-related failure. The vehicle was taken to a local dealer, where it was diagnosed with an expanded fuel tank; however, the vehicle was not repaired because the dealer was short-staffed. The dealer associated the failure with NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline). The manufacturer was made aware of the failure; a case was filed; however, no assistance was provided. The failure mileage was approximately 90,000.

ELECTRICAL SYSTEM — Filed 07/25/2025

Kia has a known issue with the HVAC blower motor circuit on this vehicle model. They have issued a warranty extension related to relocating the blower motor fuse to another circuit in the fuse box, due to potential burning of fuse(s). After executing this extended warranty fuse-relocation-procedure, our blower motor relay burned and was replaced twice by separate Kia dealers. Kia is now claiming that our entire wire harness needs to be replaced at our own cost. It is quite obvious that any wire harness issue is now very dangerous (electrical arcing and melting) and was caused by the original motor circuit issue. (The two Kia dealers agree with our assessment but are saying that Kia will not repair because original warranty extension was limited to rewiring.) Safety issues: Electrical fire hazard (already demonstrated with burning/melting fuse-box before and after extended warranty procedure was executed). No A/C in 95 degree F conditions.

FUEL SYSTEM, GASOLINE,SEATS — Filed 03/10/2025

The contact owns a 2021 Kia K5. The contact stated while her daughter was driving 60 MPH, there was an abnormal sound coming from the engine, when the gas tank expanded, and the back seat popped up. The contact stated that two teenagers were in the back seat, and one was injured. The contact's daughter pulled over and waited for a short while. The vehicle was restarted; however, the vehicle drove slowly. The vehicle was taken to a dealer; however, the vehicle was not diagnosed. The vehicle was taken to another dealer; however, no cause for the failure was found. The contact was informed that the seat had moved two inches. The contact stated that the vehicle was not repaired because the frame of the seats could be damaged. The vehicle was not repaired. The manufacturer was notified of the failure. The vehicle remained at the dealer and had not been driven since. The failure mileage was approximately 86,000.

AIR BAGS — Filed 02/16/2022

While on her way from work, my mother was involved in an accident in her 2021 Kia K5 LXS where she was rear ended at a high speed by a driver not paying attention to the road and she ended up hitting the car in front of her. During the accident NONE OF THE AIRBAGS DEVELOPED. My mother was hospitalized for a month and do to the SEVERITY OF HER MAJOR INJURIES (rib fractures, a closed fracture of her T7-T8 with loss of sensation and mobility of lower half of body) she passed away from “Effects Of Blunt Spinal And Rib Cage Trauma.” No recalls were noted for this particular model and year until March of 2023 which was way too late.

AIR BAGS — Filed 01/27/2023

I was rearended into another vehicle at a speed of about 50mph, then rearended again by and SUV, not one of my 9 airbags deployed.

AIR BAGS — Filed 07/24/2022

The contact's son owns a 2021 Kia K5. The contact stated that while her son was driving in the rain at 50 MPH, another vehicle hit her son's vehicle from behind which sent the vehicle into a concrete barrier. The vehicle was sent spinning after it hit the barrier; the vehicle was facing oncoming traffic once it came to a stop. The air bags did not deploy upon impact. The contact's son was not injured and did not seek any medical attention. The other driver fled the scene of the accident. A police report was filed. The vehicle was towed independent collision center where it had yet to be inspected or repaired. The dealer nor the manufacturer had yet to be notified of the failure. The failure mileage was unknown. The VIN was not available.

LANE DEPARTURE — Filed 11/12/2021

The contact owns a 2021 Kia K5. The contact stated that while her daughter was driving at 5-10 MPH and making a turn on a road with no lanes, the steering wheel inadvertently started shuddering and became rigid, causing the contact's daughter to lose control of the vehicle. The vehicle crashed into a construction dumpster. An unknown warning message illuminated. The air bags did not deploy. The contact's daughter did not sustain any injuries. A police report was not filed. The vehicle was towed to the contact's residence. Then, the vehicle was towed to the dealer who towed the vehicle to a collision center. The dealer informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 21V447000 (LANE DEPARTURE, STEERING) as the VIN was not included in the recall. The manufacturer was notified of the failure and a case was opened. The vehicle was not diagnosed or repaired. The approximate failure mileage was 11,700.

ELECTRICAL SYSTEM,ENGINE — Filed 05/13/2021

VEHICLE WAS STOPPED A RED LIGHT ON A CITY STREET WHEN SUDDENLY CUT OFF. SMOKE BEGAN TO POUR OUT FROM UNDER THE HOOD. LESS THAN 1 MINUTE LATER THE VEHICLE WAS FULLY INVOLVED UNDER THE HOOD OF CAR. CAR WAS A TOTAL LOSS. VEHICLE HAD JUST BEEN DRIVEN APPROXIMATELY 25 MILES (ALL HIGHWAY) FROM HOME TOWARDS WORK WHEN INCIDENT OCCURRED.

AIR BAGS,SEATS — Filed 02/01/2021

I WAS TRAVELING 45 MPH IN MY 2021 K5 GT LINE WHEN AN OLDER TOYOTA CAMRY CROSSED MY PATH. I APPLIED BRAKES BUT THERE WAS NO AVOIDING THE COLLISION. I BROADSIDED THE CAMRY AT SOMEWHERE BETWEEN 30 AND 35 MPH. I SUSTAINED INJURIES TO BOTH KNEES, NECK AND BACK. AIR BAGS DID NOT DEPLOY. POLICE, WRECKER DRIVER AND BODY SHOP (IN THIER PREVIOUS EXPERIENCES) ALL SAY THEY ARE SURPRISED THE AIR BAGS WERE NOT TRIGGERED BEING THE FACT IT WAS A FRONTAL COLLISION. ANOTHER CONCERN IS THE FOLDING SEAT BEHIND THE DRIVER'S SIDE BROKE FREE OF THE LATCH AND FOLDED ITSELF DOWN. THAT SEAT HAS NEVER BEEN FOLDED DOWN OR EVEN SAT IN FOR THAT MATTER, SO I KNOW FOR A FACT IT WAS LATCHED. SAD TO SAY MY BEAUTIFUL BRAND NEW K5 THAT I HAVE HAD FOR 2 MONTHS NOW HAS CLOSE TO $13,000 DAMAGE. MOST IMPORTANTLY, I AM NOW SCARED TO DRIVE THIS THING. WHAT IF THIS HAPPENS AGAIN?

UNKNOWN OR OTHER — Filed 02/01/2021

I WAS TRAVELING AT APPROXIMATELY 40-45 MPH, ANOTHER VEHICLE CROSSED IN MY PATH, AND I BROADSIDED HIS VEHICLE. I AM NOT SURE OF MY SPEED AT IMPACT. I WOULD GUESS 30 MPH. AIRBAGS DID NOT DEPLOY. THE REAR DRIVERS SIDE SEAT ALSO CAME UNLATCHED, FOLDING ITSELF DOWN. THERE WERE NO OTHER PASSENGERS IN THE VEHICLE.

AIR BAGS — Filed 11/11/2020

WAS DRIVING TO WORK ON FREEWAY AND A DEER JUMPED OUT IN FRONT OF CAR, I HIT IT BETWEEN 65-70 MPH AND NOT ONE OF THE MANY AIRBAGS INSTALLED ON THIS BRAND NEW CAR DEPLOYED . THE POLICE OFFICER AT THE SCENE SAID I'M LUCKY TO BE ALIVE.