2017 Kia Optima Complaints

ENGINE AND ENGINE COOLING — Filed 08/20/2026

The contact owns a 2017 Kia Optima. The contact stated that after receiving an oil change, the contact became aware that the engine oil level was low. The vehicle was taken back to the service center, and the engine oil was topped off with an additional quart of engine oil. The contact was advised to return for an oil consumption test. There was no oil leak found and the contact was informed that there was an internal oil leak.

ENGINE — Filed 07/18/2026

While driving at highway speed, my engine began to produce a loud knocking noise without prior warning. Within few seconds, the engine seized completely causing sudden loss of motive power.This caused a dangerous situation— loss of power steering and barking at highway speed, leaving me stranded in traffic lanes. I was forced to coast to the shoulder. The vehicle was towed to the nearest independent repair shop because it was not drivable and I was stranded far from home. The shop diagnosis —- seized engine due to big end connecting rod bearing seizure, identical to NHTSA Recall 17V-224 and KIA recall SC 17/ SC165 and TSB P1803 related to Theta engine bearing wear and engine seizure.My vehicle has the 2.4 L engine covered by this recall/defect.The failure occurred exactly as described in the recall: knocking , the seizure. KIA has denied warranty coverage because the vehicle was initially diagnosed and repaired at independent shop after the roadside emergency.The shop was used only because the vehicle was immobilized on the freeway away from home. I did attempt to contact a dealership in FortWorth, Texas, Morits KIA, but they could not provide roadside assistance or a tow solution at that time. I am reporting because: 1) This is a sudden loss of power at highway speed, which is a major safety risk 2) This appears to be the same defect KIA has recalled for, but the vehicle was not remedied or remedy failed 3) KIA is refusing to honor the extended warranty for this known defect I request NHTSA document this failure as part of the ongoing monitoring of Theta II engine failures. Vehicle is available for inspection and defective engine have been preserved.

POWER TRAIN,ENGINE — Filed 08/17/2026

Loosing oil putting oil in every 3 to 4 days no leaks on ground or oil pan or drain plug.oil don't smell or looks burnt happened around did 2 oil changes in a week still the same. Car will sputer hesitation on acceleration every so often have all updateds and recalls.

ENGINE — Filed 03/15/2024

I am requesting urgent assistance regarding my 2017 Kia Optima EX, which is experiencing a serious oil consumption/burning issue. The vehicle is burning oil into the engine, causing the oil level to continually decrease and creating a significant concern for engine failure, overheating, or a potential vehicle fire. I am extremely concerned about my safety and the safety of others because I depend on this vehicle every day. This is also my only vehicle, and I am still making payments on the financing. I do not have the financial ability to simply purchase another vehicle or take on a new car payment. I am asking Kia to please take this matter seriously and investigate the vehicle as soon as possible. I am requesting that Kia review whether there is a known engine issue, applicable warranty or assistance, recall/campaign coverage, or any other program that could help with the necessary repairs or engine replacement. I cannot afford to lose my only means of transportation because of an engine problem that is beyond my ability to financially resolve. I am asking Kia to work with me toward a safe and reasonable solution as urgently as possible. Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING — Filed 04/21/2026

Since 4/1 my car has intermittently lost power steering. I received dashboard warning lights and the wheel was difficult to turn. When I shutoff the car and turned back on, the warning lights were gone and the steering returned. My mechanic did a diagnostic and found the following codes c1259, c1260, c1290 and c1688 each time the incident occurred. After research, we discovered these codes relate to TBS CHA114 and TSB CHA864 under extended warranty WTY023. I was unable to upload the TBS documents. The same thing happened on 6/18. I brought the car to a different dealer. The first time they supposedly did a diagnostic and said there were no codes. I have pictures of the codes. They said it did not matter because the codes need to be active and the lights need to be on the dashboard. The second time at a different dealer, they didn't do a diagnostic but said it did not matter because the codes need to be active. No where is any documentation does it say the codes need to be active. They are stored in history and Freeze frame data. It is impossible for me to get the car there with the illuminated dash and "active" codes because when it happens, I cannot steer the car and when I shut if off they go away. Plus when I get to the dealer, they will tell me they cannot take me and to make an appointment. I am now working with KIA escalation department but she informed me today that she did not have the authority to authorize a dealer to repair the car. When I asked who does she said I need a techline which is opened by the dealership. WHAT??? This all started with the dealer. The car is now having glitches with the steering while driving. IT IS DANGEROUS AND I AM AFRAID TO DRIVE IT. I have no idea when the steering might go out. I need help in getting a Kia dealership to fix the issue under the extended warranty they sent me in 2022. I am so sick of the run around and brush off. How do I get this accomplished?

SUSPENSION,ENGINE — Filed 06/01/2026

I just bought this car and it runs thru oil fast.

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM — Filed 03/03/2026

Loosing oil putting oil in every 3 to 4 days no leaks on ground or oil pan or drain plug.oil don't smell or looks burnt happened around did 2 oil changes in a week still the same. Car will sputer hesitation on acceleration every so often

ENGINE — Filed 03/25/2026

The engine of this vehicle is still exhibiting the issues that are under the class action lawsuit. Engine. Was not repaired properly by dealership. I must change my oil around 1700 miles

ENGINE — Filed 03/07/2023

The contact owns a 2017 Kia Optima. The contact stated that on three of four occasions while driving at approximately 50 MPH, the vehicle began rattling and shaking, and he observed a knocking noise emanating from the engine compartment. The check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the knock sensor needed to be replaced, and he was advised that his vehicle may have been included in Manufacturer Recall Number: SC162. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 98,000.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 05/01/2023

Constant Mis-firing, must put oil in car every 3 to 4 weeks. Hesitation when driving and sputtering.

ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 08/04/2025

The electrical wiring harness connecting to the hybrid system electric fuel pump(s) was found to have significant corrosion and a missing factory-installed protective covering. This is a manufacturing defect. The protective covering was never installed at the factory, leaving the wiring exposed to moisture and corrosion from the time the vehicle was built. COMPONENT THAT FAILED: Electrical wiring harness to hybrid electric fuel pump(s). Missing factory protective covering caused corrosion. The failed component is available for inspection upon request. SAFETY RISK: Corroded wiring in a hybrid vehicle electrical system poses serious risks including electrical shorts, potential fire hazard, and sudden loss of hybrid propulsion while driving. The vehicle is currently inoperable and unsafe to operate. CONFIRMED BY DEALER: Yes. The vehicle was taken to an authorized Kia dealership where it remained for approximately 8 months. The dealership and manufacturer inspected the vehicle and confirmed the wiring issue but denied warranty coverage. THIRD-PARTY CONFIRMATION: A third-party warranty representative independently reviewed photographic evidence and confirmed the missing protective covering is a manufacturing defect, not wear-and-tear or owner-caused damage. MANUFACTURER RESPONSE: The manufacturer denied warranty repair, falsely claiming the hybrid component warranty does not transfer to subsequent owners. Federal warranty law requires transfer unless explicitly excluded in the warranty terms. WARNING SIGNS: No warning lamps, messages, or symptoms appeared prior to the failure. The defect was hidden beneath the vehicle and not visible during normal operation or routine maintenance.

ELECTRICAL SYSTEM,ENGINE — Filed 03/23/2026

On March 23, 2026, I took my 2017 Kia Optima Plug-In Hybrid (VIN: [XXX] ) to Mark Kia [XXX] ) solely for two open safety recalls: SC218 (Engine Inspection/Replacement and KSDS software installation) and SC278 (Emergency Trunk Latch Release) under Repair Order #6807251. No customer-pay work was performed. The Multi-Point Inspection that day noted only the cabin air filter. During the drive home on March 23, a faint rotten-egg (H₂S) smell appeared for the first time. By the morning of March 24, 2026, the smell was severe. I immediately returned the vehicle. Under new Repair Order #6807360, a second Multi-Point Inspection suddenly recommended $1,134.10 in customer-pay services (new 12V battery, fuel induction service, cooling system service, brake fluid exchange, and ATF exchange) that were not flagged the previous day. Since the recall service, the vehicle has developed numerous new defects that never existed before: Rotten-egg smell (H₂S) Intermittent AC that blows warm in stop-and-go traffic Passenger-rear power window clicks but will not roll down Brake warning (“Stop vehicle and check brakes”) “Key not detected” message Passenger-side mirror pushed in with temporary motor malfunction 12V battery cover left completely disassembled and misplaced in the trunk Complete no-start / dead 12V battery condition (will not crank even after multiple jump attempts as of March 30, 2026) On March 24, 2026, I sent a formal demand letter by certified mail (received and signed for by the dealership on March 27, 2026) giving Mark Kia five business days (until close of business March 31, 2026) to provide a free tow, free loaner, and free repair of all defects. I followed up with six supplemental addendums (dated March 24–30, 2026) attaching photos and videos of every issue. On April 1, 2026, Service Director [XXX] replied by email and admitted in writing (twice) that the dealership did not follow recall procedure INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 06/19/2023

Turbocharger failed at 90000 miles because fan assembly was bad. May have happened when dealership replaced high pressure fuel pump. Fan sheared and metal parts got in the engine about a thousand miles after that.

AIR BAGS — Filed 03/11/2024

The contact owned a 2017 Kia Optima. The contact stated that while driving at 35 MPH, another vehicle crashed on the front passenger side tire of the vehicle. Due to the impact, the vehicle was sent over four lanes of traffic and jumped over a curb. The contact stated that the front air bag was deployed only after the vehicle jumped the curb; no other air bags in the vehicle were deployed despite the contact's children in the vehicle's rear seat. The contact stated that metal shrapnel was released upon deployment of the air bag. The contact used her left arm to block the fragments from hitting her face. The contact and her children were all transported to the hospital by ambulance. The contact sustained multiple cuts to her jaw, lips and face. In addition, the contact sustained multiple lacerations and bruises to her left arm and the contact's right arm was broken; the contact also sustained eight cracked teeth. The contact stated that all four children located in the rear seats suffered minor bruising with one child suffering a seat belt laceration on their right shoulder. A police report was filed. The children were discharged from the hospital on the same day; however, the contact stayed in the hospital for a week due to her injuries. The other driver's air bags were deployed upon impact and no injuries were reported. The vehicle was towed to an independent mechanic where it remained in their possession pending. The manufacturer was notified of the failure. The vehicle had been deemed a total loss. The failure mileage was approximately 110,000.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 03/07/2024

ON [XXX], AROUND 11:30 A.M., I WAS DRIVING [XXX] ON [XXX], GOING ABOUT 78 MPH, JUST PASSED [XXX], WHEN THE LIGHTS ON THE DASH LIT UP, SMOKE STARTED COMING FROM THE BACK OF THE CAR, THEN THERE WAS SMOKE COMING FROM UNDER THE HOOD THEN SMOKE STARTED COMING FROM THE A/C VENTS. THERE WAS A FULL FLEDGE FIRE UNDER MY HOOD. THE GUY DRIVING NEXT TO ME, KINDA GESTURED FOR ME TO PULL OVER, ALTHOUGH I WAS ALREADY THINKING I NEEDED TO PULL OVER, THE SHOCK OF WHAT WAS HAPPENING, I LOST MY TRAIN OF THOUGHT. I PULLED OVER AND SO DID THAT GUY, HE HAD A FIRE EXTINGUISHER AND TRIED TO PUT OUT THE FIRE BUT TO NO AVAIL. 5 MINS AFTER I GOT OUT, THE ENTIRE CAR WAS ENGULFED IN FLAMES. IT WAS VERY SCARY AND I AM THANKFUL FOR THAT GUY, BECAUSE I FROZE FOR A MINUTE AND COULDN'T THINK OF WHAT TO DO, I PULLED OVER JUST IN TIME. THE FIRE DEPT WAS CALLED AND IT TOOK THEM AWHILE TO PUT THE FIRE OUT, THE CAR WAS BURNT TO A CRISP, A 100% LOSS. A POLICE OFFICER TOOK MY NAME & PHONE NUMBER AND ARRANGED FOR A TOW TRUCK. I HAD TO ARRANGE FOR SOMEONE TO PICK ME UP FROM THE SIDE OF INTERSTATE I [XXX] AND HAD TO CALL OFF WORK. THE CAR WAS TOWED BY PROFESSIONAL TOWING TAMPA LOCATED - PHONE# 813-242-0610 EXT. 5 EMAIL - DISPATCH@PROTOWTAMPA.COM | WEBSITE - www.professionaltowingtampa.com I SPOKE TO SOMEONE AT THE TOW YARD AND THEY TOLD ME TO BRING THEM THE TITLE TO THE CAR THE NEXT DAY AND SUGGESTED I PAY THE TOWING FEE RIGHT AWAY BEING THAT THE TOTAL AMOUNT DUE INCREASES EVERY DAY. ON [XXX], I BROUGHT THEM THE TITLE TO THE CAR AND PAID THE, I BELIEVE, $285 TOWING & STORAGE FEE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 10/22/2023

The engine on this vehicle caught fire while the vehicle was parked and not running. It had previsouly been drive for approximately 4 hours throughout the day but at the time of the incident there were no warning dashlights present. It is currently available for inspection, however depending on the length of this invesitagion it may no longer be available as i work with my insurance company determing next steps. My safety and the safety of other were put at risk by and open flame and smoke that occured during the fire. Ultimately the Fire Department were required to put out the fire. Approximately 8 months ago the engine was replace by the dealership Summit Place Kia East in Michigan due to an open recall for a knock sensor issue. I suspect this vehicle will be a total loss.

STEERING,VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE — Filed 06/07/2022

On 6 June 2022 I was driving Eastbound Interstate 80 passing Fairfield, CA. Traffic was moderate, average traffic speed 65. The Kia’s Adaptive Cruise was enabled and set to the maximum amount of safe distance. I recall the car directly in front of me changed lanes to pass a truck towing a trailer. I remember the Kia began to accelerate and I couldn’t turn the wheel. Next memory was opening my eyes to the dust smoke of deployed air bags. I lost consciousness likely due to the sudden impact and air bags deployed. I was taken to a Fairfield hospital by ambulance where I spent 4 days. A slurry of tests ruled out loss of consciousness as the cause. No stroke, heart attack or seizure occurred. I was treated for bruised ribs due to the airbag. No doubt to me that this collision could have been catastrophic to this driver and others driving nearby. Witness reported that I sped up and clipped the truck/trailer while attempting to pass. What I believe happened: 1) the Adaptive Cruise accelerated when it determined there was room but failed to see the trailer and 2) the steering was unresponsive when I attempted to avoid a collision. The reaction time between car accelerating and getting knocked out had to be a mere three or four seconds. The vehicle was totaled, The insurance company, Mercury Insurance, released the vehicle

UNKNOWN OR OTHER — Filed 02/18/2023

No vehicle warning as it became engulfed in flames. Fire started from under the hood.

ENGINE — Filed 06/05/2022

On June 5th 2022 as I was traveling out of state with my wife and daughter the car lost power on the highway. I pulled over to the side when safe and noticed whitish grey smoke puffing from under the hood by the hinges. Being a fire lieutenant, I recognized this as the car being on fire. We exited the vehicle, my daughter was asleep in the back seat, so it was a panic to wake her and make sure she got out away from traffic. Within the 3 minutes I was on the phone with 911 the car was engulfed. A few minutes after the first Chief arrived the fire had reached the fuel tank and the vehicle exploded, approximately 8 minutes in. I opened a claim with my insurance and with Kia America. Kia has taken the blame but refused to replace the vehicle, instead offering me $15000 for the car with only 57000 miles on it. After fighting with Kia for 3 weeks during my claim they finally provided me with a rental vehicle paid for by their insurance. To this date they have not paid for said rental and I am now on the hook for the $930 charge. This event has caused much undue stress on me, I already have cardiac issues, my wife and daughter still have nightmares from the event. Kia inspected the vehicle which is totally burned, they found it to be an engine failure causing oil to spill onto the hot exhaust. They accepted blame. There was no warning, no noises, no lights. I never received a recall notice, I found out about the recall from my insurance after the fact. Kia has been less than helpful.

STEERING,UNKNOWN OR OTHER — Filed 07/10/2022

There is a viral trend spreading throughout the country that shows how easy it is to steal a key-start Kia or Hyundai. The perpetrators bashed my back rear window, dislodged the undercarriage of the steering wheel, and used something as simple as a USB cable to turn a knob and start the ignition. My safety was put at risk as well as others because these people that stole my car clearly do not care about their own life or others. No one steals a car for a positive reason. They drove it recklessly and abandoned it without concern for anyone. Kia and Hyundai need to address this issue or more and more of them are going to continue to get stolen and people are going to continue to get hurt, both physically and financially.

ENGINE — Filed 11/16/2020

On November 16, 2020, Lucy Robinson was driving her 2017 Kia Optima when she started seeing smoke. She pulled into a gas station and the engine was on fire. The fire department extinguished the fire. A cause and origin was conducted and it was found that the fire originated within the engine compartment. The fire was caused by the release of heated oil coming from the leaking PCV located at the top portion of the valve cover.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE — Filed 03/03/2021

THE WIRING HARNESS WAS REPLACED IN MY 2017 KIA OPTIMA IN 2019 AT APPROXIMATELY 45,000 MILES. KIA REPLACED MY ENGINE JANUARY 2020 BECAUSE IT WAS CONSUMING LARGE AMOUNTS OF OIL. I JUST GOT MY CAR BACK IN JANUARY 28, 2021 WITH A SUPPOSEDLY NEW ENGINE. ON MARCH 3, 2021, MY CAR CAUGHT FIRE WHILE PULLING OUT OF MY NEIGHBORHOOD ACTUALLY DRIVING DOWN THE STREET. SMOKE AND FLAMES WERE COMING OUT FROM UNDERNEATH THE HOOD THE OF THE CAR. THE ENTIRE FRONT END OF THE CAR BURNED. THANKFULLY, THE FIRE DEPARTMENT GOT THE FIRE OUT AND NO ONE WAS INJURED.

ENGINE — Filed 10/15/2020

MY 2017 KIA OPTIMA CAUGHT ON FIRE ON OCTOBER 15, 2020. I WAS DRIVING TO THE STORE AND HEARD A TICKING SOUND AND SOME NOISES. THE CHECK ENGINE LIGHT ALSO CAME ON. I PULLED OVER IN THE LEFT TURNING LANE ON THE HIGHWAY TO EXIT THE VEHICLE. I HEARD A POPPING SOUND AND SAW FLAMES. I EXITED THE VEHICLE AND IMMEDIATELY CALLED 911. MY CAR BURST INTO FLAMES.

ELECTRICAL SYSTEM,STRUCTURE,ENGINE — Filed 07/21/2019

WHILE MY SIGNIFICANT OTHER AND I WERE DRIVING DOWN THE HIGHWAY OUR CAR BEGAN SMOKING FROM UNDER THE HOOD, THEN SMOKE BEGAN COMING THROUGH THE AIR VENTS INSIDE THE CAR; WITHIN SECONDS WE SEEN FLAMES COMING OUT FROM UNDER THE HOOD AND IMMEDIATELY EVACUATED THE VEHICLE IN HEAVY TRAFFIC WITH NO WHERE TO PULL OVER. WITHIN MINUTES THE ENTIRE CAR WAS ENGULFED IN FLAMES. THERE WAS NO WARNING, OUR CAR WAS REGULARLY MAINTAINED, THERE WERE NO CHECK ENGINE LIGHTS OR OTHERS DISPLAYING ON THE DASH, NO LEAKS OR OVERHEATING TO CAUSE THIS.

ELECTRICAL SYSTEM — Filed 04/12/2017

TL* THE CONTACT OWNS A 2017 KIA OPTIMA. WHILE ATTEMPTING TO ACCELERATE FROM A STOP, THE VEHICLE STALLED WITHOUT WARNING. AS A RESULT, ANOTHER VEHICLE CRASHED INTO THE REAR OF THE CONTACT'S VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE. THE VEHICLE WAS TAKEN TO JEFF WYLER KIA (LOCATED AT 5815 DIXIE HWY, FAIRFIELD, OH 45014) WHERE IT WAS DIAGNOSED, BUT THE TECHNICIAN COULD NOT FIND A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THEY WOULD GET BACK WITH THE CONTACT. THE CONTACT HAD NOT HEARD BACK FROM THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 4,700.