2020 Kia Sportage Complaints

ENGINE — Filed 06/29/2026

Rod Bearing failure June 29,2026 with prior Kia manufacturer recalls June 19,2023: (1.) SC206, HECU fire Recall, a serious safety recall regarding the Hydraulic Electronic Control unit. The circuit board can short out and cause an engine bay fire even when the vehicle is parked. (2.) SC249B (Tow Hitch Harness Fire Recall): Another active safety recall. Moisture or debris on the Tow Hitch accessory circuit board can short-circuit and spark a fire. March 11, 2024 Recalls (1.) SC340(Engine Emissions ECM Ligic Improvement). This is a voluntary service campaign to upgrade the software logic in your engine control module (ECM(. It is iften tier directly to how your car judges engine diagnostic faults. (2.) CS 2312/Theft Det recall(Theft Deterrent Ignition Cylinder Proctector): This is a customer satisfaction campaign that installs a physical metal protector sleeve around your Ignition cylinder to prevent "Kia Botz" style theft bypasses.

UNKNOWN OR OTHER — Filed 07/16/2026

My 2020 Kia sportage spontaneously caught fire. It started smoking about 1/3 mile from my destination. There were no dash lights on and the temperature gauge was not elevated and was below half so it wasn’t the engine overheating. I pulled into the parking lot and shut off the car and the smoke then increased and turned darker rapidly and the car caught fire and was quickly engulfed and then there were several explosions. The car was a complete loss. Had I taken any more time to figure out the smoke I would have been a casualty.

STEERING,FORWARD COLLISION AVOIDANCE,LANE DEPARTURE — Filed 12/31/1969

Vehicle has excessive wandering, that is intermittent, during traffic, surrounding traffic on freeways and on slight wind and rain. The vehicle exhibits behavior that is very very unstable.. I’ve had the vehicle for about three years and it’s been doing this for about two years now intermittently I recently took it into the Kia dealership in Stocton to have it looked at nothing was determined other than the state of the problem.

ENGINE AND ENGINE COOLING — Filed 09/05/2025

The contact owned a 2020 Kia Sportage. The contact stated that driving at 25 MPH with her daughter, another driver on the opposite lane, alerted them that the engine was on fire. Upon checking the rearview mirror, the contact noticed black smoke. The contact pulled over to the right side of the road, turned off the vehicle, and exited. The front hood had partially opened on its own, revealing flames coming from the engine. Coolant was leaking from under the passenger side of the vehicle. The contact called 911. No warning lights were illuminated before or after the incident. No injuries were sustained, and no medical attention was required. The contact has experienced panic attacks and issues sleeping as a result of the vehicle fire. The fire department extinguished the fire. A police report was filed, but the report number was unknown. The vehicle was towed off the scene to Leo's Auto Body Parts. The vehicle was destroyed. The manufacturer was informed of the failure and offered no assistance. The failure mileage was 63,120.

ENGINE — Filed 09/24/2024

The contact owned a 2020 Kia Sportage. The contact stated while driving at approximately 35 MPH, the contact discovered smoke coming from the engine compartment and from out of the A/C unit; the contact pulled to the side of the road as she discovered that the engine compartment, the front driver side and passenger side of the vehicle, and underneath the vehicle had caught on fire. No warning lights were illuminated. The origin of the fire was unknown. The vehicle was occupied during the fire. The contact's spouse sustained burns from attempting to extinguish the fire that he discovered had spread onto him and the contact's clothes while they were still driving. Once all of the passengers had safely exited the vehicle, the vehicle exploded. Medical attention was sought. A fire department and police report was filed. A dealer was not contacted however, the vehicle was pronounced totaled at the scene. The manufacturer was notified of the failure. The failure mileage was approximately 11,000.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM — Filed 10/27/2024

On October 27th my 5 year old daughter and I were driving home just after leaving Tiresplus getting four brand new tires and an oil change. On the way home out of no where my vehicle caught fire. Driving down the highway, once noticing the car was on fire, no warning no nothing- until I hit the breaks which did not work cause they were completely burnt. Within moments of thinking how I am going to get to my child in her car seat and save myself I went into the median of the highway thinking grass would slow me down. Once the car was going about 30 MPH I opened my driver door fearing we would be locked in the burning vehicle. As soon as I opened my door my legs were burning, I unbuckled my seat belt and jumped out of the car. Only to get up and chase the vehicle to get my 5 year old out. The car was fully engolfed in flames when approaching the vehicle thinking my daughter was dead. By the grace of god she unbuckled her self, climbed through the center counsel out the driver door and jumped into my arms! We were down to seconds of dying. Breaks didn’t work, nothing told me the car was hot, the trauma we endured. No one has taken responsibility for this and it’s frustrating that I owe money on the vehicle with full coverage and gap insurance still.

UNKNOWN OR OTHER — Filed 01/28/2025

[XXX] the vehicle was driven approx. 20-25 miles and parked at a local grocery store in front of the propane tanks. No warning lights came on. Regular maintenance on vehicle. The vehicle caught on fire and was extinguished by the local FD. Total loss. Case filed with kia to request an investigation however no timely response. The vehicle is at the insurance auction yard now and we are waiting on guidance for an investigation regarding the start of the fire. No guidance given and insurance would like to settle the claim, however we would like to know why/where the fire started. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 01/29/2025

The contact's parents owned a 2020 Kia Sportage. The contact's parent stated that the vehicle was parked and turned off at a local grocery store. The contact's parents were informed that the front of the vehicle had caught on fire. The vehicle was extinguished by the Fire Department. A fire report was filed, and a fire report number was not provided; however, the cause for the failure was not yet determined. A Police report was not filed. The dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was destroyed. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.

WHEELS,SERVICE BRAKES — Filed 11/28/2024

Car rolled down the hill despite being on Park with Parking breaks engaged

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE — Filed 04/20/2024

On [XXX] had oil change at Kia of Orangeburg, SC. On [XXX] travelled to Summerville, SC on [XXX]. Exited at the [XXX] exit and stopped at the traffic light. Observed smoke coming from under the hood. Pulled over at gas station on right. My daughter opened the hood and there was fire under the hood. Dropped hood and called 911. Fire Department arrived and put the fire out. There were no warning lights in dash board or unpleasant odors observed while driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VEHICLE SPEED CONTROL — Filed 12/13/2023

When pulling out of a parking area the vehicle accelerated without me pressing the gas pedal. Attempts to stop the vehicle by pressing the brake were unsuccessful. The vehicle stopped when we struck a building.

UNKNOWN OR OTHER,FIRERELATED — Filed 02/02/2024

As I was driving down the road,I started to see steam/smoke coming out of the enginge. I went to pull over and lost my brakes. I ended up tapping the car in front me. My car started to fill with smoke and then engulfed in flames. By looking at the pics, it appears the fire started on the driver's side. The car is a total loss.

STRUCTURE,UNKNOWN OR OTHER — Filed 08/05/2023

My 2020 KIA SPORTAGE WAS STOLEN AFTER THE RECALL WHERE KIA INDICATED THE RECALL WOULD DETECT THAT A KEY WAS NOT INSERTED AND WOULD SHUT DOWN CAR. THIS DID NOT WORK BECAUSE MY CAR WAS STOLEN AFTER THE RECALL!!! CAUSING EXTREME DURESS AND FINCIAL DISTRESS. THIS RECALL WAS JUST A SMOKE SCREEN TO LET EVERYONE THINK IT WAS FIXED AND THAN TACK A COUPLE SECURITY STUFF ON THE WINDOWS. WHEN IS ENOUGH IS ENOUGH AND THE NHTSA FINALLY MAKES KIA RECALL THERE CARS AND INSTALL AN IMOBILIZER AS PER NHTSA CODE.

STRUCTURE — Filed 03/10/2023

I am concerned with the liftgate/trunk panel latching/operation. On our liftgate/trunk it falls sometimes and comes down on you while you are still in the way. My wife was slightly injured on her head, when it malfunctioned, and she was in the way when it came down. Several times it just started coming down on me while I was unloading items from the cargo hold. Sometimes the lift cargo door will just open on its own and you go outside and see it, or a neighbor will see it and come let us know.

AIR BAGS,FORWARD COLLISION AVOIDANCE — Filed 02/07/2023

A vehicle failed to the right of way to me and resulted in a front end collision. Upon collision the airbags deployed and immediately began smoking. I thought my car was about to catch fire and smelt as if was going to. The airbags heat alone resulted in the entire arm of my jacket to completely melt and I now have a permanent scar on my left wrist from where I was burned.

ENGINE — Filed 02/10/2022

I was involved in an accident in February 2022 in which I had auto body damage after hitting a vehicle cutting across an uncontrolled intersection through 3 lanes of traffic where I collided into it going 35mph. On March 22 I began having issues with my car idling high, jumping and running very poorly etc. the other party’s insurance approved the repairs. March 22 My car was towed to the local Kia Dealership where it remained until may 1 due to the parts being on back order. I am unsure of what repairs were completed at that time. The day after I picked my car up I noticed a substance splattered on both sides of my car as well as the hatchback. That same day, I stopped for an oil change at my usual place when they informed me that I have a tremendous amount of oil soaking the rocker panel under my engine. They insured me that everything was put back together all nuts and bolts were in place as they should be. Showed me where the oil measured on the dipstick. A few weeks later, I stopped in for my top off to find that I was 2 quarts low on oil. I had noticed also that there were oil spots all over our driveway where there use to never be. Due to the mileage on my vehicle and reading that this is a common occurrence in vehicles with high miles I made sure I kept a close eye on my oil levels, watched for any warning lights on my vehicle(which never appeared)and never thought much more about it. But as time passes and I get my oil changed I’m always still low on oil. I reached out to the service manager at the dealership to let him know about the leak i now had. He immediately made every attempt to make this my fault. He said that the repairs they made wouldn’t have caused a leak. He was very defensive and not really interested in the concerns I had. Never once did he mention anything about the known issues these vehicles are having which are not caused by the customer. He left me feeling helpless

UNKNOWN OR OTHER — Filed 07/25/2022

Driving on hwy going to pass a car look and the mirror and was black smoke Minutes later I was trying to get out of the car took car to the shoulder car was on fire Totally lost no answers yet over what happened be careful second Kia Sportage lost

VEHICLE SPEED CONTROL — Filed 05/25/2022

On Sunday I was getting on the expressway and my car accelerated on its own. I hit the brake and the car was ok. That was May 22, 2020, On Wednesday, May.25,2020 I was pulling into a parking spot at Kroger Store and my car accelerated on its own and I hit a pole. Over $4000.00 damaged to my car but I was not hurt. I took my car to the dealer and they checked it and said nothing was wrong. I am afraid to drive it. I don't want to hurt anyone or myself. There were no warning lights.

AIR BAGS — Filed 01/29/2020

The contact owns a 2020 Kia Sportage. The contact stated that while driving at 10 MPH, another vehicle crashed into his rear driver's side door and wheel well. None of the air bags deployed upon impact. The contact's head hit the seat belt anchor ring upon impact. The contact later received medical attention for a tear in his shoulder and whiplash. A police report was filed. The vehicle was towed to a tow yard and then to a body shop where it was repaired. The tow truck driver informed the contact that the rear axle had fractured from the sub-frame. The vehicle was not deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 22V031000 (Air Bags) however, the VIN, year, and model were not included in the recall. The failure mileage was approximately 30,000.

ELECTRICAL SYSTEM,ENGINE — Filed 01/26/2022

My car caught on fire in campground where I was staying. Also burned up 2 other vehicles, my RV was deemed a total loss and it also damaged 2 other campers. There was a fire investigation which was ordered by my insurance and there is another mechanical engineer investigation pending. There was a recall on my car and I had taken it to dealership last year for repair. There was no warning lights.

UNKNOWN OR OTHER — Filed 06/12/2021

This complaint is against Fox rent a car . We rented a car from Fox car rentals located near Denver airport . Unfortunately our car was hit by a deer we called the police and they prepared a report the deputy sheriff Also mentioned that Fox rent a car has rented us and expired registration and under repo/recall vehicle which may have serious consequences for us. Nevertheless we returned the car and filled a accident form with our insurance policy and police report details . The employee at the location confirmed that since we are insured with Allstate we are only responsible to pay the deductible which in our case was $1000. Now we are received a demand from fox rental for $1810.53 . We have agreed to pay the deductible but not a single cent more . Also we would like to claim any appropriate damages / compensation for negligence and irresponsibility by fox rental for renting us expired registration car under repossession . Police officer card and case number with damage form attached

SERVICE BRAKES, HYDRAULIC — Filed 04/15/2021

The contact owned a 2020 Kia Sportage. The contact stated that while driving at 75 MPH, he and his wife began to smell a fuel odor emitting from the vehicle without warning. Soon after smelling the fuel, a flame had ignited from the engine as a dark, black smoke began to emit from the vehicle. The contact immediately pulled over and both he and his wife exited the vehicle as the vehicle became engulfed in flames. The authorities were called to the scene and the fire department was able to extinguish the fire. A police and fire report was filed. No injuries were reported at the scene. The vehicle was towed to an independent scrap yard as it had been completely destroyed by the fire. Three weeks after the failure, the contact received a call from the dealer where he purchased the vehicle that there was a recall on the vehicle for NHTSA Campaign Number: 21V137000 (SERVICE BRAKES, HYDRAULIC). The contact informed the dealer of the failure with his vehicle and the dealer hung up the phone. The manufacturer was notified of the failure and had received no assistance. The vehicle was a total loss. The failure mileage was 10,500.

VEHICLE SPEED CONTROL — Filed 03/23/2021

AS I WAS PULLING INTO A PARKING SPOT THE CAR SUDDENLY ACCELERATED WITH GREAT SPEED AND LUNGED THE CAR FORWARD INTO A CEMENT WALL. I WAS IN A PARKING GARAGE AND GOING VERY SLOW WHEN IT DARTED FORWARD. IT DAMAGED THE FRONT NUMBER AND THE ELECTRONIC SENSORS

ENGINE — Filed 12/19/2020

TL* THE CONTACT OWNED A 2020 KIA SPORTAGE. THE CONTACT WAS AT A RED LIGHT WHEN A SMOKE ODOR WAS DETECTED AND ANOTHER DRIVER INFORMED HIM THAT BLACK SMOKE WAS COMING FROM THE EXHAUST. THE CONTACT STATED THAT AS HE WAS EXITING THE VEHICLE, HE SAW FLAMES IGNITING UNDER THE HOOD OF THE VEHICLE AND MOMENTS LATER THE VEHICLE BURST INTO FLAMES. THE VEHICLE WAS TOWED TO A LOT AND THE INSURANCE COMPANY DEEMED IT TOTALED. THE CONTACT INFORMED THE DEALER OF THE FAILURE BUT THE DEALER WANTED TO SELL THE CONTACT ANOTHER VEHICLE. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 11,600. *DT

SERVICE BRAKES — Filed 12/20/2019

WHILE DRIVING/TURNING LEFT OUT OF A SCHOOL PARKING LOT, THE LIGHT TURNED GREEN, ALL CARS STARTING MOVING. GOING ABOUT 10-12 MPH, THE CAR IN FRONT SLAMS ON BREAKS, THE SAFETY FEATURE ALERTED ME AS WELL BUT WHEN ATTEMPTED TO PRESS ON THE BRAKES, THEY WERE RESISTING. I COULD NOT BRAKE AND HAD NO CONTROL OF STOPPING. THE WEATHER WAS DRY AND SUNNY THAT DAY. ABOUT 35 DEGREES.