2023 Kia Telluride Complaints

UNKNOWN OR OTHER — Filed 09/18/2026

While driving down a highway, the front sunroof glass exploded.

UNKNOWN OR OTHER — Filed 08/03/2026

Screen go black or blanks out. Sometime when shifting from reverse to drive the reverse screen stay on.

VISIBILITY/WIPER — Filed 09/03/2026

Three times over the past year minor debris or small rocks have hit the windshield causing major spidering affects that have run all across the windshield. Even when using the windshield repair kits.

UNKNOWN OR OTHER — Filed 09/02/2026

While driving 2023 Kia Telluride driver side over head visor detached tangling in front of driver obscuring vision.

POWER TRAIN — Filed 08/21/2026

On XXX, at approximately 7:40 a.m., my 2023 Kia Telluride, VIN [XXX], experienced a sudden mechanical failure while traveling approximately 65+ mph southbound on [XXX]. The vehicle suddenly locked up, causing the driver to lose control, skid, and swerve toward the side of the freeway. The rear wheels appeared to be locked. Fortunately, no collision occurred and no one was injured. The vehicle was towed for inspection. A technician at Colton Tire advised that the axle appeared to be bent. The vehicle was then transported by flatbed to Allstar Kia in [XXX] for diagnosis. The Kia dealership initially suggested the vehicle must have been involved in an accident because of a minor exterior scrape on the driver's-side rear passenger door. The vehicle has not been involved in an accident or collision. The scrape occurred while slowly maneuvering into a home garage at approximately 1–2 mph and did not involve impact to the wheel, axle, suspension, drivetrain, or differential. The dealership later advised that the technician believed an alleged “accident” caused the differential to slowly leak over time, ultimately causing the axle to bend “pretty badly.” I dispute this conclusion and have requested the complete diagnostic findings and physical evidence in writing. I am reporting this incident because the vehicle suddenly experienced a serious mechanical failure and loss-of-control event at freeway speed. I am also requesting investigation of whether the intermediate shaft, right-front driveshaft, axle, differential, or related drivetrain components could have been affected by NHTSA Safety Recall 24V-214 / Kia Safety Recall SC303, or another mechanical defect. I understand the recall has not been established as the cause of this specific incident. I am asking that the actual cause of the sudden vehicle lockup be investigated because the failure occurred at approximately 65+ mph and could have resulted in a serious crash. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SEATS — Filed 08/18/2026

The contact owns a 2023 Kia Telluride. The contact received notification of NHTSA Campaign Number: 26V430000 (Seats); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available for the recall repair. The contact was concerned that the recall posed a fire risk, rendering the vehicle unsafe to drive or park. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and denied rental vehicle assistance. The contact had not experienced a failure.

ELECTRICAL SYSTEM,ENGINE — Filed 08/08/2026

This is an update to my original NHTSA complaint (ID 11755209) regarding an intermittent no-start/no-crank defect on my 2023 Kia Telluride (VIN [XXX]). Since my original filing, the identical defect has recurred twice more, on XXX — once at approximately 1:01–1:30 PM EST and again at approximately 5:03–5:17 PM EST, the same day. In both incidents, the dashboard and infotainment system powered up normally, but the vehicle would not crank, consistent with all prior occurrences dating back to XXX. This brings the total documented occurrences to six between XXX and August 8, 2026, including two in a single day. In both August 8 incidents, my wife was stranded and had to be picked up because the vehicle would not start. This follows a dealer-confirmed and dealer-executed starter replacement (Kia of Cleveland, RO dated XXX, part #36100-3L160) that was performed after the dealer duplicated the fault on the vehicle and on a bench test — and a 4th recurrence on XXX, just 10 days after that repair. I have video evidence of all four August incidents (XXX, and the two on XXX showing the instrument cluster and infotainment fully powered with a no-crank condition. I am providing this update because the frequency of occurrences is escalating — two failures in a single day — despite a repair that was physically confirmed by the dealer's own testing. This strongly suggests the actual root cause (potentially an immobilizer/smart-key system fault, IBU communication failure, or intermittent wiring/ground fault) has not been correctly identified, and the defect continues to pose an unreasonable stranding risk to occupants. I am concurrently pursuing a vehicle replacement request with Kia America under Customer Care Case #26211382. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER — Filed 01/01/2026

CLEAR COAT PEELING OFF IN SHEETS ON A 2023 KIA TELLURIDE. IT'S A KNOWN PROBLEM AMOUNG KIA OWNERS HOWEVER KIA IS NOT ACCEPTING RESPONSIBLITY FOR A MANUFACTURER DEFECT.

ELECTRICAL SYSTEM,ENGINE — Filed 05/01/2026

My 2023 Kia Telluride (VIN [XXX]) has an intermittent no-start/no-crank defect that has occurred on four separate occasions between [XXX] and [XXX] (mileage range 49,850–51,180). In each occurrence, the dashboard and infotainment system power on normally, but the engine will not crank when the start button is pressed, with both key fobs. The fault clears itself with no consistent trigger, making it undetectable by standard diagnostic scans after the fact. The vehicle was taken to Kia of Cleveland (2492 South Lee Highway, Cleveland, TN 37311) three times. On the first two visits (6/18/26 and 7/1/26) the dealer could not duplicate the fault and returned the vehicle unrepaired. On the third visit (7/17/26–7/27/26), the dealer successfully duplicated the no-start condition both on the vehicle and on a bench test after removing the starter, and replaced the starter under warranty (part #36100-3L160). Despite this confirmed and completed repair, the identical no-start condition recurred on [XXX], only 10 days and approximately 250 miles later. This is a safety issue: on [XXX], my wife was attempting to leave for work with our twin 5-year-old daughters in the vehicle when it failed to start. This is the type of defect that could strand occupants in unsafe locations or conditions (heat, cold, traffic, isolated areas) with no warning and no reliable workaround. I have video evidence of the [XXX] incident showing the vehicle's instrument cluster and infotainment fully powered with a no-crank condition, timestamped and showing the odometer reading. I am filing this complaint because the defect has now defeated a dealer-confirmed and dealer-executed repair, suggesting a root cause (such as an immobilizer/smart-key system fault, IBU communication failure, or intermittent wiring/ground fault) that has not yet been correctly identified. I am concurrently requesting a vehicle replacement from Kia America under Case #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN — Filed 07/10/2026

A P0741 warning light comes on and off leading driver to believe the problem is intermittent when in fact it is a torque converter failed. The intermittent nature of the warning light could lead drivers to believe the problem is not a safety issue, particularly on a SUV with only 105,000 miles. However, when a converter fails it is definitely a safety issue.

ELECTRICAL SYSTEM,LANE DEPARTURE — Filed 07/12/2026

Driver Assistance Warning (DAW) warning bells and dash sign "Driver Needs a Break" with Coffee Pot showing goes off constantly. Even with safest driving possible, on purpose safest driving, the warning and sounds goes off every few miles and few minutes. KIA dealer has kept car for 2 weeks and say they can not duplicate and I drive it (Perfectly) and it goes off. this is a 2023 Kia telluride , previous year models and later models you could turn off or turn down sensitivity of this warning. KIA eliminated the owner the opportunity to disable or turn down this warning. It is a safety hazard because it is always going off, causing the driver to take his attention from the road to the dash every few minutes with the bells and coffee pot Take A Break Warning . KIA will not do anything about it.

LANE DEPARTURE — Filed 07/12/2026

The Kia Driver Assistance Warning, Showing a Coffee Pot, and Warning "Driver needs to Take Break" goes off constantly. Sometimes starts within 5 minutes of driving and goes off constantly for every 3 minutes . Dealer says it is a KIA problem and can not do anything. This constant warning is a Safety Hazard because it takes the Drivers Attention off his Driving with the constant Bells going off. It is a 2023 Kia Telluride and previous models you could turn off this Warning but NOT in 2023 according to dealer and KIA will not repair or turn off. This is a Safety Hazard.

FUEL/PROPULSION SYSTEM — Filed 06/26/2026

The fuel gauge intermittently fails and incorrectly displays that the vehicle has little or no fuel, even when the tank is nearly full. On the first occasion, I was at home. The second time, after shopping, I started the vehicle and the gauge indicated there was no fuel, despite knowing the tank was almost full. As I continued driving, the fuel gauge slowly began registering correctly until it eventually returned to showing the proper fuel level. This has now happened twice. This is a serious safety concern because the driver cannot accurately determine the amount of fuel in the vehicle. An incorrect fuel reading could cause someone to believe the vehicle is out of fuel, become stranded in an unsafe location, or make unnecessary emergency stops, creating a potential hazard for both the driver and others on the road.

UNKNOWN OR OTHER — Filed 07/11/2026

My 2023 Kia Telluride has been subject to at least 8 separate NHTSA recalls, including SC181 (seat belt/child restraint), SC194 (trailer brake light/cruise control), SC207 (airbag OCS/ODS), SC262 (side airbag wire harness), SC303 (driveshaft/rollaway risk), SC316 (power seat motor fire risk), SC347 (door trim detachment), and now SC374/NHTSA 26V430 (recurrence of the power seat motor fire risk, explicitly noted as possibly caused by an improper repair under the earlier SC316 recall). I am especially concerned that the current recall (26V430) describes the same underlying defect as an earlier recall (SC316/24V407) that was supposed to have been repaired, and that no remedy is yet available for this recurrence. This raises serious questions about the adequacy of the original repair and the vehicle’s ongoing fire risk. I am filing this complaint to document this pattern of recurring safety defects and request that NHTSA and Kia treat this as evidence of an unresolved, recurring hazard — not an isolated incident.

POWER TRAIN,UNKNOWN OR OTHER,ENGINE — Filed 06/19/2026

On June 15, 2026, my check engine light came on. On June 17, 2026, I took it to Auto Zone, they checked the code for the check engine light, and it indicated P0016 and P0017–crankshaft issues. On June 19, 2026, while driving down the highway, my vehicle failed to accelerate. I exited the highway, and my vehicle completely decelerated and ultimately shut down. I was unable to get my engine running and had to get it towed to the dealer. It has been at the dealer for 3 weeks now. The dealer said my engine will likely need to be replaced. It is a 2023 Kia Telluride with less than 66,000 miles on it.

UNKNOWN OR OTHER — Filed 12/03/2025

AWD Coupler is bad make noise and shaking at low turn speeds only

UNKNOWN OR OTHER — Filed 05/04/2026

Standard vehicle component- shattered window. I was driving on highway I 275 and heard a loud sound, when I investigated I realized that the window in the second row to the right simply just shattered, glass flying everywhere.

AIR BAGS,SEAT BELTS,SEATS — Filed 12/30/2022

VIN: [XXX] Owner: [XXX] Purchase Date: December 2022 I am filing an urgent safety complaint regarding my 2023 Kia Telluride. For nearly two years, I have unknowingly driven this vehicle with multiple active safety recalls, including: •Airbag wiring harness defect (airbags may not deploy) •Seatbelt pretensioner/tensioner defects •Front power seat motor overheating (fire hazard) •Driveshaft engagement defect (vehicle may roll out of Park) Kia never properly notified me of these recalls and never repaired them, despite my family using the vehicle daily. I drove this SUV with my autistic child and infant grandchild, believing it was safe. I have now discovered that Kia allowed me to operate a vehicle that could: •Fail to protect us in a crash •Catch fire •Roll away unexpectedly •Malfunction in ways that could cause severe injury or death This is a serious safety negligence issue. Kia did not offer a loaner vehicle, did not notify me promptly, and has not provided any remedy despite these recalls being federally regulated. I am requesting NHTSA intervention to: 1.Investigate Kia’s failure to properly notify and protect consumers. 2.Require Kia to provide a full replacement vehicle (2025/2026 Kia Telluride) or a full buyback due to prolonged safety risk. 3.Ensure Kia corrects VIN-level recall handling and compliance failures. 4.Document that Kia exposed vulnerable passengers (disabled child and infant grandchild) to unsafe conditions for almost two years. My family has been placed in danger this entire time, and Kia has not provided a timely or adequate remedy. Please investigate this matter urgently. — [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM,STRUCTURE — Filed 09/13/2025

Contact states large metal vehicle door trim came off while driving, unknown if accident was caused or other damage to surrounding vehicles. Further states, noticed when large rubber-like molding under door trim was flapping and thunking against door. Contact says water now intrudes into vehicle cabin and suspects constant water inside door affecting door electrical systems. Dealer notified by contact and no remedy provided for this "known issue". Contact is concerned about other trim pieces coming off and penetrating other vehicles at speed with "sharp and pointed edges", as well as electrical fire from water intrusion corrosion. Contact demands further investigation and action by vehicle safety regulators.

ENGINE — Filed 12/10/2024

The contact owns a 2023 Kia Telluride. The contact stated while driving at an undisclosed speed, she was flagged down by another driver who informed her that there was a fire near the rear exterior of the vehicle. The contact merged to the shoulder of the road and discovered that the fire had extinguished on its own. No warning lights were illuminated. A fire and police report was not filed. No injuries were reported. The vehicle was towed to the dealer, where the inspection was being performed. The was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 20,000. The VIN was not available.

AIR BAGS — Filed 08/14/2024

I was hit on driver side and no side airbags deployed. The collision cause over $16k in damage to my vehicle. There is no reason side airbags should not have delivered and if my child was in the car on the passenger side he would have slammed his head on glass.

POWER TRAIN,ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 02/15/2024

Placed the car in park then it started rolling backwards and crashed

STRUCTURE,LANE DEPARTURE — Filed 05/13/2023

The contact owns a 2023 Kia Telluride. The contact stated while driving 30 MPH, the vehicle made an abnormal sound. The contact stated that the lane recognition sensor located on the rearview mirror had exploded. The contact sustained injuries to his face. No medical attention was received. The vehicle was taken to the dealer, who stated that the windshield would be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 6,001.

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 02/04/2023

The contact owns a 2023 Kia Telluride. The contact stated that while driving at an undisclosed speed, the instrument cluster displayed a blank screen. Additionally, the parking brake inadvertently engaged while driving. The Auto Start/Stop was intermittently inoperable, and the doors failed to unlock with the remote starter. The vehicle was towed to the dealer; however, the dealer only performed a recall repair under NHTSA Campaign Number: 23V035000 (Air Bags). The failure recurred. The contact then stated that while pulling into a parking space at 4 MPH, the brake pedal was depressed, but the vehicle lunged forward and experienced unintended acceleration. The forward collision avoidance failed to activate to stop the vehicle. The vehicle crashed into the median, causing the front passenger's side tire to blow out. The front view camera fault message was displayed. No injury was sustained. The vehicle was then towed to Steve Schmitt Kia (11655 New Halls Ferry Road, Florissant, MO 63033) where the vehicle remained, not yet diagnosed or repaired. The contact later received notification of NHTSA Campaign Number: 23V298000 (Electrical System) however, the part to do the recall repair was not yet available. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 11.

ELECTRICAL SYSTEM — Filed 08/01/2022

The KIA Telluride Tow Hitch Harness Module has been responsible for getting humidity and dirt inside and starting a fires. So, KIA has recalled this issue BACK IN AUGUST, 2022 and told everyone not to park the vehicle inside or near any buildings and expected a solution this October. However, it's December and I have contacted my Dealer as well as KIA corporation and KIA is telling everyone that they do NOT have any solution for this fire hazard and they cannot even provide any date as to when they will have a solution. So, now, they are just shipping all the new Telluride's (that should be coming with the Tow Hitch and Harness) without them and saying they have no idea when you can get the new revised Hitch and Harness Solution????? At this point it feels as though KIA is not taking this seriously and offering ANY SOLUTIONS for their dealers or customers. So, what can be done?