2021 Lincoln Aviator Complaints

ELECTRICAL SYSTEM,SERVICE BRAKES — Filed 07/07/2026

I have been having issues with my breaks sticking when applied. To the point that it’s completely stopping my car and i need to use my foot to release the brake from behind. I have had the dealership look at this issue and they can’t seem to find the problem. They also broke my car and claimed they did not feel the sticking. I’ve had the dealership look at my vehicle twice for this issue. It is a safety risk with children in my vehicle. Also everyone i lock my vehicle. My alarm is going off saying someone is opening the door on my Lincoln app. Additionally, every time i start my car it says the passenger door is open, when it’s not. The sync Bluetooth constantly connects and disconnects or if i plug my phone i to the charger for CarPlay it does not work. This biggest problem is my brakes sticking. Like i said when i am braking gradually they are sticking to the floor and not releasing. Thai doesn’t always happen but it has happen a lot recently. I need this fixed!!!!! Multiple recalls that are not available as well

VISIBILITY — Filed 07/15/2026

The contact owns a 2021 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 26V117000 (Visibility); however, the part to do the recall repair was unavailable. The dealer was contacted, and the contact was informed that parts would be available at the end of June 2026. The manufacturer was not contacted. The contact had not experienced a failure.

FUEL SYSTEM, GASOLINE — Filed 07/12/2026

The contact owns a 2021 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving 70-75 MPH, the check engine warning light illuminated, and the vehicle stalled. The vehicle was towed to a friend's residence, where it failed to restart. The dealer was contacted and informed that the vehicle would be repaired at the owner's expense because the recall remedy was unavailable. The contact was informed that a reimbursement claim could be filed with the manufacturer afterwards. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 67,000.

POWER TRAIN — Filed 03/15/2026

The contact owns a 2021 Lincoln Aviator. The contact stated that while the vehicle was unoccupied and parked on an incline, the vehicle rolled backwards several feet and then came to a complete stop. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 26V402000 (Power Train); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 98,000.

UNKNOWN OR OTHER — Filed 06/05/2026

My vehicle is a hybrid and repeatedly gets high voltage battery warnings when the electric battery shows zero miles when idling. Four times it has shown pull over safely messages and high voltage battery warnings and then it is only in auxiliary mode. By the time a tow truck comes it is able to start again and Ford has been unable to find the issue after 4 visits

ELECTRICAL SYSTEM,ENGINE — Filed 05/23/2026

The contact owns a 2021 Lincoln Aviator. The contact stated that the vehicle did not start, the vehicle was , the hood was raised, the contact went back to the vehicle to try to start, the vehicle would not turn over with clicking in the engine. the vehicle began to smoke with very thick white smoke, the contact was unable to exit the vehicle of the drivers side front seat. The battery was disconnected and a manual latch was discovered on the drivers side door. The vehicle was towed to the dealer but had not been diagnosed or repaired. The manufacturer was not notified of the issue. The approximate failure mileage was 60,000.

AIR BAGS — Filed 05/09/2026

I was completely stopped in traffic a car failed to reduce speed and slammed into the back of my car. My neck whipped forward no air bags deployed.

INTERIOR LIGHTING — Filed 03/17/2026

Interior front reading lights turn on and off randomly when driving and when not driving. This is incredibly distracting especially at night.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SERVICE BRAKES — Filed 01/26/2026

The vehicle is intermittently braking on its own while driving. The issue has become significantly worse over the course of a month. The dashboard message reads, “brake applied, power reduced”. This is a danger to both myself and other drivers as we are unable to control the speed of the vehicle.

SUSPENSION — Filed 12/15/2025

My car start making a very loud squeaking noise when I turn or hit any small bumb in the road. So I took it to the shop and was told both front lower ball joint boots are broken the exact same way. Now what bother me is what the mechanic said next. I quote " some type of suspension problem always happens on these cars. So my question is were there any recall about suspension on these cars? Online says yes. While my vin doesn't show one