2021 Lincoln Navigator Complaints

POWER TRAIN,FUEL/PROPULSION SYSTEM — Filed 09/21/2025

I purchased this 2021 Lincoln Navigator L Black Label used on March 22, 2024 with approximately 42,726mi. Beginning around Sept. 2025 (approximately 70,000-75,000 miles), the vehicle developed intermittent transmission failures that have progressively worsened. This is our primary family vehicle and routinely transports our three young children. The transmission hesitates, slips, skips gears, bangs into gear, and frequently delays engagement before suddenly surging forward. Engine RPM increases without corresponding acceleration. Occupants are abruptly thrown forward and backward during normal driving. Several times each month, a yellow wrench/powertrain warning appears instructing the driver to see the owner’s manual. When this occurs, the vehicle loses normal acceleration and throttle response becomes significantly delayed. The defect is intermittent and unpredictable. The condition creates dangerous situations when merging, entering intersections, accelerating from traffic lights, and in stop-and-go traffic. On one occasion, after stopping on an incline, the vehicle would not accelerate and effectively became disabled in traffic. We activated our hazard flashers while vehicles drove around us. The hesitation followed by sudden engagement also creates a rear-end collision risk. I first brought the vehicle to an independent repair shop, but the concern was dismissed. On 6/22/2026, Herb Chambers Lincoln of Norwood road tested the vehicle, confirmed the complaint, and documented that the “transmission is skipping and banging into gears” and recommended complete transmission replacement. The estimated repair cost was approximately $12,560. The vehicle remains unsafe to drive due to repeated loss of propulsion, delayed acceleration, violent shifting, and dealer-confirmed transmission failure. I respectfully request NHTSA investigate whether this represents a broader safety defect affecting Ford/Lincoln vehicles equipped with the 10-speed automatic transmission.

FUEL SYSTEM, GASOLINE — Filed 03/25/2025

The contact owns a 2021 Lincoln Navigator. The contact received notification of NTHSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The dealer confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that vehicle failed to accelerate as needed due to a lack of fuel going to the engine. The contact stated that that the engine seized with the check engine warning light illuminated. The failure mileage was approximately 70,300.

FUEL SYSTEM, GASOLINE — Filed 07/01/2026

The contact owns a 2021 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

FUEL SYSTEM, GASOLINE — Filed 06/30/2026

The contact owns a 2021 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was not contacted. The contact stated that the recall was initiated for more than a year; however, the part to do the recall repair was still unavailable. The manufacturer was not contacted. The contact had not experienced a failure.

EXTERIOR LIGHTING — Filed 11/25/2025

THE REAR LIGHT BAR DEVELOPS LEAKS AND CAN MAKE THE REAR LIGHING GO OUT. DEALER WAS MADE AWARE AND STATES IT'S NO LONGER A COVERED ITEM.

POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE — Filed 02/02/2026

While driving, the vehicle repeatedly hesitated during gear changes, lost power, and then abruptly jerked back into gear. This occurred intermittently for over a month without any warning messages, creating unpredictable and unsafe driving conditions. As the issue worsened, the vehicle began losing power more frequently. The most serious event occurred at highway speed, where the vehicle suddenly lost propulsion in the middle of active traffic, nearly causing a stall. This created an immediate safety hazard for myself and surrounding drivers. After several seconds, the vehicle violently re-engaged into gear and surged forward. Only at this point did the vehicle display a warning: “Powertrain Malfunction / Reduced Power.” I scanned the vehicle and retrieved DTC P0734 – Gear 4 Incorrect Ratio, a code associated with internal transmission faults. A dealership inspected the vehicle and reported that the CDF drum had failed. They stated they could not guarantee that replacing the drum would resolve all issues and provided two estimates: $5,600 for a partial internal repair/$8,700 for full transmission replacement. The 10R80 transmission has a documented history of failures, including harsh shifting, slipping, unexpected gear disengagement, and internal component defects. These issues are addressed in multiple Ford Technical Service Bulletins involving P0734, harsh/failed shifts, and failures related to the CDF clutch cylinder/drum. Many vehicles of the same make and model are covered under related recalls or service actions for similar problems; however, my VIN is not included, and Lincoln declined to honor the existing recall. This defect presents a serious safety risk due to: Sudden loss of power while driving, including at highway speeds, Unpredictable re-engagement and violent surging, Loss of propulsion without warning, leading to near-stall conditions. This powertrain malfunction is a known, unsafe, repeat issue among these vehicles equipped w/this transmission.

ELECTRICAL SYSTEM — Filed 12/14/2025

I am reporting a serious safety concern involving a 2021 Lincoln Navigator with factory equipment only. After snowfall, during factory remote start, the vehicle produced a hot/burning smell, and I observed visible melting and bubbling of multiple driver-side and passenger side exterior pillars. The vehicle has a factory sunroof and no aftermarket electronics or modifications. The melting appears on the exterior, indicating heat originating from inside the pillar cavities. Due to concern for electrical overheating and fire risk, I discontinued using my remote start. A Lincoln dealership dismissed the concern and incorrectly stated that there is no electrical wiring in the pillars. Lincoln Customer Care has verbally refused assistance solely due to lack of extended warranty and has declined escalation, despite the reported fire risk. I am concerned this involves water intrusion from the sunroof drainage system contacting powered body or airbag wiring, creating a risk of electrical fire. I am requesting NHTSA review this as a potential safety defect involving electrical overheating and fire risk.

POWER TRAIN — Filed 11/17/2025

Navigator transmission goes into neutral when accelerating at speeds of 50+. Trans completely overhauled. Still does it. Almost had 2 accidents when changing lanes on the freeway, trying to accelerate and instead slowing down with cars behind fast approaching . When trying to pass on a 2-lane hwy, this would be deadly.

FUEL SYSTEM, GASOLINE — Filed 10/22/2025

The contact owns a 2021 Lincoln Navigator. The contact stated that while the vehicle was parked, several attempts were needed to start the vehicle. The contact also stated that while driving at an undisclosed speed, the vehicle was shaking abnormally. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was taken to the dealer, where it was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The failure mileage was not available.

FUEL/PROPULSION SYSTEM — Filed 09/29/2025

I am the owner of a 2021 Lincoln Navigator black label, currently subject to Safety Recall 25S75 concerning the low-pressure fuel pump that can cause engine stalling and increased crash risk. Ford’s recall filing and public reports make clear the hazard and that a remedy is still being developed. My vehicle has repeatedly exhibited hesitation and loss of acceleration consistent with the recall since I purchased the car in 2021. While driving on the highway with my 10 year old daughter and her friend home from soccer on 495 last Monday 9/29, I tried to pass a car by switching to the left lane and stepped on the accelerator.  The car hesitated, and felt like it was going to cease altogether for a moment, however the accelerator did finally « catch » and I was able to pass the car.  I have had this same sensation while pressing my foot on the accelerator though at low speeds on backroads.  After the incident last Monday I had the car towed to the Lincoln dealer so they could assess the car.  I have been told that the oil was very low. The oil light or check engine light was never on, and it has gone on previously when I’ve been due for an oil change. I’ve been told that the tires also need to be rotated. The dealer who serviced the car said that the car is driving great now and is safe to drive and can be delivered to me or I can pick up. I called Lincoln corporate Friday 10/3/25 and a case was opened and called back on Monday and spoke with a representative who said that there was nothing she could do if the dealer is saying that the car is safe to drive.  I don’t feel safe driving the car with this open safety defect unrepaired. A loaner to use while the process for repurchase of the car would be appreciated, but is being denied while they continue the process of good faith eval /consideration of repurchase of the car.