2022 Lincoln Navigator Complaints

FUEL SYSTEM, GASOLINE — Filed 06/09/2026

The contact owns a 2022 Lincoln Navigator. The contact received notification of NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure.

UNKNOWN OR OTHER,SERVICE BRAKES — Filed 05/22/2026

No collision warning; completely break failed. Vehicle had some fuel leakage which was fixed on May-21-2026 and break was failed on May-22-2026 which caused due to this repair. It was a major accident and my car got total due to this. I need full refund of my car; same amount when I bought this car.

STRUCTURE — Filed 05/23/2026

The rear portion of the moonroof on the vehicle, spontaneous imploded while sitting in the parking area in the middle of the night we have video evidence to prove that nothing happened to the vehicle during the night, and it also appears that the moonroof imploded from the inside as it expanded towards the outside of the body.

FUEL/PROPULSION SYSTEM,VISIBILITY/WIPER,FORWARD COLLISION AVOIDANCE — Filed 07/08/2025

Vehicle is subject to multiple open federal safety recalls with no repair remedy currently available from Ford/Lincoln. One recall involves potential fuel pump failure causing loss of fuel pressure, engine stall while driving, and increased crash risk. A second recall involves interruption of driver assistance and visibility systems including rearview camera, forward collision warning, lane keeping, and related safety systems. This vehicle is operated in a commercial passenger rental fleet. Due to federal rental vehicle recall compliance requirements, the vehicle was removed from rental service immediately after issuance of the recalls and cannot legally be rented until repaired. Ford/Lincoln currently has no available repair remedy despite the recalls having been active for an extended period of time. The lack of available remedy has rendered the vehicle commercially unusable for an extended period while continuing to create ongoing safety concerns related to engine stall and interruption of critical driver assistance systems. The vehicle remains unavailable for lawful commercial operation pending manufacturer remedy.

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,BACK OVER PREVENTION — Filed 04/06/2026

The contact owns a 2022 Lincoln Navigator. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System Gasoline) and 26V165000 (Back Over Prevention, Electrical System); however, the parts to do the recall repairs were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

UNKNOWN OR OTHER — Filed 03/10/2026

While in an airport cell phone waiting lot, an extremely loud explosion happened. I screamed and looked back at my toddler and infant also in the vehicle with me. Thankfully, nobody was harmed. There were no warning lights or sounds before or after the event. I could hear some wind above. I exited the vehicle and checked it - the front panel of the panoramic sunroof had exploded. There was in incredibly large defect in the center with upward bowing and tenting throughout the remaining glass. Pieces of all sizes, tiny to large, were gathered on the closed shade below. I contacted the dealership as the vehicle was still under a bumper to bumper warranty. I took the vehicle to the dealership, and the service department submitted a claim to the warranty department. This was denied as “no point of impact” was identified. Lincoln forums report multiple similar incidences of spontaneously exploding sunroofs. This is incredibly dangerous as it would be a huge hazard if occurred while driving and, if the shade had been opened, it would have seriously injured my children or me.

ELECTRICAL SYSTEM,ENGINE — Filed 11/24/2025

At about 2:30am after hearing some popping noises I went to the vehicle and saw that the engine under the bonnet was on fire. The fire was seeping out from the sides of the bonnet. The vehicle had been parked since 9:20pm the previous night. I called emergency services including the fire department and the police. It spread very quickly in the Garage where the car was parked and burnt out the garage and the Tesla Plaid parked in the same garage. Firefighters put out the fire with total disintegrated remains. It was just luck that I was awake to catch this at this stage otherwise it would have spread to the house. My 3 children and wife were sleeping. The fire started in the engine of the parked Lincoln Navigator. Visual confirmation of the event is evident.

UNKNOWN OR OTHER — Filed 06/22/2025

The foot rails outside the vehicle either don't go up or don't go down. Also, there are several times that the foot rail goes down, and as I step on it, it closes with my foot still on it. Causing me to fall or get my foot stuck between the rail and the car. Fortunately, I didn't get hurt the 4 times that it happened. There is no consistency as to when it happens or any type of warning. The vehicle is scheduled to go in for additional service, but I wanted to file this complaint as it's an extremely dangerous hazard for occupants. Started around the end of June.

SERVICE BRAKES — Filed 09/15/2023

upon arriving home after a vacation, the NAV experienced complete brake fluid loss and no braking as a result. I investigated the brake lines and one of the lines had been secured to the frame with a clip - this clip was not secure and the brake like was chaffed against the air cleaner housing

ELECTRICAL SYSTEM — Filed 03/13/2023

2022 Lincoln Navigator L Reserve has many issues with Modules one of them that keeps goes bad is Apin which controls the screen and all other features like Massage seats Running Boards and Music and all other controls that gets disabled when it goes bad it’s a frequent problem which I has been having often changed 3 times but the problem is persistent Lincoln hasn’t made a recall for this particular model they are keep updating the software or replacing Apin but it’s not a long time fix you’ll have this issue as long as you have this model it’s my 4th time getting fix other issues with this model is blind spot sensor that goes on while driving and it stays on the screen till it’s get reprogrammed at the dealership with updates so this 2022 Model is not as same as the other Lincoln Navigator models