2018 Mazda CX-9 Complaints

ENGINE — Filed 08/07/2026

While driving at highway speed in heavy rain the oil light suddenly came on followed within 30 seconds by an urgent need to immediately stop the car due to overheating. There was no radiator fluid left due to the sudden and catastrophic structural failure caused by a known manufacturing defect. Mazda calls it csp-11. They did NOT do a recall even though a situation such as this is clearly life-threatening. They offer an extended warranty to fix the problem fully up to 120,000 miles. Our car has 124,000 miles. Two months ago it would have been fully repaired at no cost but now they want in excess of 11 THOUSAND DOLLARS. I have spoken to more than 6 people in customer service, 2 supervisors, and they are ADAMANT they will not cover one single penny of repair even though this was not due to wear and tear, but due to a known and recognized manufacturing defect which they have since corrected in newer cars. First, this should have been a full recall since having this happen with no warning is without a doubt life threatening. If an inexperienced teenager had been driving and their engine suddenly seized, they likely would have died, and taken adjacent cars with them. Second, why is this limited extended warranty allowed, it is arbitrary and capricious to say they will fix their mistake up to 120,000 miles but then in an 8-year-old car they will pay nothing? Prior to this there was no advance warning, no fluid leak, and the car had been serviced regularly without any mechanic noticing anything. 3/14/26 repair rear brake pads/rotors 113,896 miles 7/10/26 oil change/tire rotation 123,544 miles 8/7/26 Catastrophic failure due known manufacturing defect csp-11. Brought to Mazda dealer and they confirmed the hole in engine caused by this defect that has an extended warranty. Car still sitting at dealership a month later, now, like a brick, because who has $11,000 in their pocket?

ENGINE — Filed 08/20/2026

My 2018 Mazda Cx-9 equipped with the skyactiv-g 2.5T developed a serious cylinder-head/cooling-system failure. The vehicle began to lose coolant with no apparent external leak and subsequently displayed and engine -overheating warning. It continued to lose coolant after a flush. The Mazda dealership inspected the vehicle and diagnosed a warped cylinder head; I was also advised that the engine oil was milky, indicating coolant contamination. The affected component is the engine cylinder head/cooling system. This condition created a safety concern because loss of coolant and overheating can lead to severe engine damage or engine failure and potentially leave the vehicle disabled while driven. Mazda has formally documented a cylinder head coolant leak condition in certain 2016-2020 CX-9 2.5T, including cracks around the cylinder head, exhaust manifold area, and states that the cylinder hear/exhaust manifold gasket design was modified to address the condition. Mazda then established customer service program CSP11, extending coverage for the specific cylinder head coolant leak condition to 10 years/120,000 miles, whichever comes first. The dealer has confirmed and inspected my vehicles condition, and Mazda customer experience has also review the matter after I provided the TSB and CSP11 information. Mazda has declined financial assistance because my vehicle falls outside the applicable coverage period and has stated that its decision is final. I am submitting this complaint because I believe this documented cylinder head failure may represent a significant safety/reliability concern for other CX-9 owners, particularly if the condition develops shortly after the 10 year /120, 000 mile coverage limit. I believe and should be made aware of the potential for coolant loss, overheating, and engine damage and that NHTSA should review the scope and safety implications of this condition.

ENGINE — Filed 07/29/2026

I was driving home from work and may car started overheating out of nowhere. I was stuck in traffic and white smoke was exiting my exhaust. I pulled over and all of my coolant leaked out of my car. Took it the shop and they said I had a cracked head and need a whole new engine. I seen that there was a warranty sent out for a problem with an exhaust manifold issue leaking coolant and that is exactly what caused my problem. I contacted Mazda and they said there is nothing they can do. I will have to hire a lawyer and file a class action lawsuit. I never recieved anything from Mazda regarding the issue. They should be paying for my car. I had zero issues until the day it faulted out. I am outraged that I had a great car then something that Mazda knew about cause me an issue.

ENGINE — Filed 11/25/2025

The cylinder head on this 2018 Mazda CX-9 (Skyactiv-G 2.5T engine) cracked, allowing engine coolant to leak and intermix with engine oil, causing loss of coolant and catastrophic engine failure. The vehicle became undriveable in the first week of November 2025 at approximately 125,019 miles and has remained inoperable since; it was not in a crash and had to be towed. This matches a known, documented defect on Mazda's Skyactiv-G 2.5T engine: coolant leakage at the cylinder head near the exhaust manifold, leading to overheating and engine failure. Mazda issued technical service bulletin(s) addressing cylinder-head cracking and coolant intrusion, revised the cylinder-head casting (a superseding part number), and extended warranty coverage (program CSP11) for this specific concern. This vehicle fell just past the mileage cap of that extension. Safety risk: a cracked cylinder head causing coolant loss and engine overheating can produce sudden loss of engine power and overheating if it occurs while driving. No crash, fire, or injury resulted in this case. A formal dealer diagnosis is pending; the failed engine/cylinder head is being preserved and is available for inspection on request.

SEATS — Filed 02/13/2026

My passenger heated seats malfunction while I was driving. As I was driving on the highway I smelled something burning. I didn't know where the smell was coming from it was strong . Then while I'm driving on the highway my seat started to smoke a lot I got scared and pulled on side of the road. I realized my seat was the issue turned off the heated seats on the control. Step out the vehicle on side the highway I was nervous and scared standing outside my vehicle. The smoke eventually died down and cleared out. I never turned it back on and put a small piece of tape over the hole it burned through my seat.

ENGINE — Filed 05/20/2026

My wife was driving the vehicle when the emergency lights started going off. She had to pull over because the car wouldn't run and said it was overheated. All the maintenance has been done to the car. We took it to the dealership and they said it is a cracked head and it is a known issue. They even issued a extended warranty for it. It is TSB 01-002/23. There should be a recall on this not just a partial credit.

POWER TRAIN — Filed 04/01/2026

My 2018 Mazda CX-9 with the SKYACTIV-G 2.5T engine has been diagnosed with a cracked cylinder head, cracked exhaust manifold, and cracked turbocharger at approximately 88,000 miles. This is a known design defect documented in Mazda TSB 01-002/23 and addressed by Customer Service Program CSP11, which extended the powertrain warranty to 10 years/120,000 miles for coolant leaks at the cylinder head. The TSB identifies exhaust manifold deformation and residual production stress as root causes of the cylinder head cracking. In my vehicle, the failure has extended to the exhaust manifold and turbocharger, both directly mounted to the cylinder head in the same high-stress zone. The turbocharger on this engine is a coolant-cooled unit. As coolant leaks from the cracked cylinder head, the turbocharger is deprived of its cooling supply, leading to excessive heat buildup and eventual cracking of the turbo housing. The turbo damage is a direct consequence of the cylinder head defect Mazda has already acknowledged. CSP11 covers the cylinder head but does not address consequential damage to the exhaust manifold and turbocharger caused by the same defect. I am requesting the NHTSA investigate whether Mazda's remedy is sufficient and whether a formal recall is warranted given the risk of sudden engine failure at highway speeds.

ELECTRICAL SYSTEM — Filed 03/08/2026

The liftgate (trunk) opens sporadically. The system keeps trying to open the truck and it's causing a parasitic drain on my battery. I was stranded 2 hours from my home due to this. My trunk would sporadically beep three times, that is the only warning I received. There are safety recalls for other year of Mazda cx-9 but not my specific even though I am having the same issue.

SERVICE BRAKES,ENGINE — Filed 02/19/2026

My 2018 Mazda CX-9 experienced catastrophic engine damage after a radiator failure allowed coolant to enter the engine. The vehicle provided no dashboard warning, overheating alert, or coolant warning before the failure occurred. Modern vehicles are designed to alert drivers to overheating or cooling system failures. The lack of warning prevented me from addressing the issue and resulted in catastrophic engine damage. I believe this represents a potential safety defect in the vehicle’s cooling system monitoring and warning system.

SEATS — Filed 02/11/2026

The adjustable rails holding the rear left seat in place no longer latch. It is available for inspection. This is the most common place for a car seat in this car. In the event of a crash the seat would slide forward. The seat belt attaches to the seat so there would be little restraint on the rear passenger. The mechanic who attempted a repair stated Mazda does not sell this part, only sells a replacement for the entire seat, about $5000. There were no symptoms, when adjusting the seat the rail just stopped holding the seat firmly in place when the adjusting bar was released.

ENGINE — Filed 12/26/2025

Here the facts, bought a car out of state (Illinois) from Iowa with 130,131 miles on Sept 12th 2025, Mazda CX9, the dealer did not disclose any problems with the car, after 3 months of ownership, the car overheats on highway whit family including a [XXX] infant, white smoke under the hood and exhaust pipe, towed home, radiator was replaced, few days after that a coolant leak, vehicle was sent to an authorized Mazda dealership for diagnose, the technician told us, according to Mazda procedures, a cod P111A, the vehicle's engine reached unsafe level of temperature and the whole engine needs to be replaced because a cracked head cylinder. This problem is well known by Mazda because they addressed on a TSB01-002/23 and CSP11 extended warranty, there is a flaw in the design of the engine near the cylinders manifold area, that cracks the engine and requires a full replacement of the engine. its just a flaw in the design of the engine. This issue can appear at any point threatening the life of the occupants of the vehicle INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM — Filed 01/27/2026

Passenger seat heater either had a grounding issue or shorted out, causing to seat to start smoldering and catching fire, destroying the seat. There has been recalls and lawsuits for this specific issue on this model in other years, but not for this model year.

VISIBILITY/WIPER — Filed 08/15/2025

Passenger side sun visor will not stay in place. Cannot lock it in up position, which means it droops. Causing sight of vision impairment.

ELECTRICAL SYSTEM,LANE DEPARTURE,BACK OVER PREVENTION — Filed 09/07/2025

[XXX] 2018 MAZDA CX-9 GRAND TOURING 89014 MILES Date: 9/11/2025 To: Mazda North American Operations Attn: Customer Experience Center 7755 Irvine Center Drive Irvine, CA 92618 USA Subject: Formal Complaint Regarding Safety and Technical Issue – 2018 Mazda CX-9 Dear Mazda Customer Experience Team, I am writing to formally lodge a complaint regarding a serious safety and technical issue I have experienced with my 2018 Mazda CX-9. After a recent inspection conducted by Mazda Koch 33, it was brought to my attention that the engine wiring harness is defective and may potentially cause a fire or result in burns, posing a severe safety risk to me, my passengers, and others on the road. This issue is deeply concerning and unacceptable, especially considering Mazda’s reputation for reliability and safety. A fault in the engine wiring harness, particularly one that has the potential to ignite or burn, should be treated with the utmost urgency. It is troubling that such a critical component could present such danger. My vehicle has been serviced and maintained regularly, and I was not made aware of any recall or technical service bulletin that addressed this defect until the inspection. Given the nature of the defect, I believe this may be a manufacturer defect, and I request that Mazda: Immediately investigate and confirm whether this issue falls under an existing recall or known defect. Take full responsibility for replacing or repairing the affected wiring harness at no cost to me. Provide assurances in writing that my vehicle is safe to operate. Offer compensation or a loaner vehicle if the repair process renders my vehicle unusable for any period of time. Please consider this a formal request for immediate corrective action. I expect a prompt response within 10 business days of the date of this letter. If I do not receive a satisfactory resolution, I will be compelled to escalate this matter further through consumer protection agencies, such as the INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN,ELECTRICAL SYSTEM,SERVICE BRAKES — Filed 09/08/2025

my 2018 MAZDA CX-9 safety issue SCBS / SBS, LAS / LDWS, MASTER AND/OR HBC WARNING LIGHTS Forward sensing camera (FSC) stops functioning cause my car run rough even depress accelration and those light came on dashbaord -Forworad smart city brake support malfunction -smart brake system -front camera sensor malfunction

ELECTRICAL SYSTEM,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 08/10/2025

I am submitting this recall request because my vehicle has experienced repeated incidents of a serious safety issue. While driving—most often on the highway—a warning appears that says “Smart System Brake Malfunction.” Immediately after, the car begins braking on its own without driver input. This has happened multiple times and, based on online reports, it appears to be affecting many Mazda vehicles across different models and years. Each time, I have been forced to pull over, turn off the car, and restart it to temporarily resolve the issue. This is extremely dangerous, especially at highway speeds, as it creates a high risk of rear-end collisions and sudden loss of vehicle control. When reported to Mazda, the concern was dismissed as a “sensor issue,” but the repeated nature and widespread reports suggest a potential systemic defect that requires urgent investigation and recall.

ENGINE — Filed 07/26/2025

Cracked cylinder head/leaking coolant.

ENGINE — Filed 06/14/2025

. In January 2024, I purchased a used 2018 Mazda CX-9. The vehicle ran well until [XXX], when I discovered an engine coolant leak. My mechanic diagnosed it as a known defect involving the cylinder head. My husband contacted Mazda Customer Service (CS), and they advised us to get an official diagnosis from a Mazda dealer. We brought the car to Orland Park Mazda, where a diagnostic confirmed the defect (report attached). We later received an email from Mazda CS saying that since our car was at the dealership, Mazda would take the lead in submitting the goodwill repair claim (email attached). When we followed up with Orland Park Mazda, they informed us that no one from Mazda CS had contacted them to authorize the repair. We relayed this to Mazda CS and gave them the direct number of our service advisor, Adrian. Mazda CS said they would follow up and get back to us within 48–72 hours. On a follow-up call, I spoke with Nancy at Mazda CS, who again told me that our case manager Cindy would contact us within 48–72 hours. Instead, we received an email denying the repair, stating the vehicle exceeded the 120,000-mile limit for the extended warranty (our vehicle has 133,500 miles). While our car is outside the warranty period, this is a textbook case of a well-documented defect covered under TSBs for the 2018 CX-9. Mazda has previously approved goodwill engine replacements for other customers well beyond this mileage. We are seeking fairness and consistency in handling known product defects. Our request is that Mazda approve the engine repair under goodwill coverage as they have in many similar cases. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 12/01/2022

Infotainment screen (LCD) of Mazda CX-9 2018 has developed what looks like discoloration/scratching/frost in corner of screen about 2 years ago and it is continuing to spread over last 6 months. This screen is used for hands-free bluetooth/calling (which is now the law in Iowa) and the back-up camera which allows for safe backing. If screen is unreadable, these safety functions cannot be performed properly. I take my car into Mazda dealership for maintenance/oil changes and it has never been addressed as an issue, but I'm concerned.

ENGINE — Filed 12/07/2024

Our Mazda CX-9, having roughly 86,000 miles, had catastrophic engine failure while driving. This is caused by coolant leaking at the cylinder head and around the exhaust manifold. This in turn caused a crack in the engine block. Mazda refused to fix this as it wasn’t a “recall” and only a tsb sent out. 1000 of people have reported this issue, causing failure while driving but Mazda will not recall the engines nor fix them under an extended warranty. After a 4 month battle with Mazda they refused to fix this in our car even though they know the engine is a bad manufacturing issue. A recall needs to be made and Mazda needs held accountable. Our exact cause was exactly what the TSB stated but Mazda stated our crack was not in the correct spot. They need a recall covering all engine block cracks due to faulty manufacturing

ENGINE — Filed 12/13/2024

coolant leaking from engine block cracked cylinder head

UNKNOWN OR OTHER — Filed 12/13/2022

I was resting my foot on my brake in the middle of sealed traffic and when I eased up to move forward when traffic my brakes did stop causing me to bump the car ahead of me. After that what came next was that my car then accelerated forward with my foot still on the brake. By then 2 other vehicles were involved in this accident. My car is now totaled from this.

SERVICE BRAKES — Filed 03/15/2021

EMERGENCY PARKING BRAKE ('EPB') BEGAN TO MALFUNCTION FOLLOWING RECALL TO FIX ELECTRICAL COMPONENTS ON MAZDA CX-9, 2018. EPB WILL NOT RELEASE, OR WILL UNEXPECTEDLY AND SUDDENLY RELEASE WITH CAR ACCELERATING IN GEAR ('DRIVE' OR 'REVERSE'). MOST RECENTLY WHEN ACTIVATING THE EMERGENCY PARKING BRAKE ((CAR WAS ON A A ROADWAY INCLINE) THE BRAKE WOULD NOT RELEASE, AFTER 2 HOURS OF BEING STRANDED AND OF ATTEMPTING TO GET THE BRAKE TO RELEASE, ( INCLUDING ROCKING/SHIFTING/ALTERNATING GEARS/BRAKING/SEAT BELT ON/SEAT BELT OFF/ MANUAL BRAKE ON/OFF AND FOLLOWING ALL MANUAL PROCEDURES REPETITIVELY) A CELL PHONE CALL TO THE MAZDA SERVICE MANAGER WHO SUGGESTED ROCKING THE CAR BACK AND FORTH BETWEEN GEARS ) THE EMERGENCY PARKING BRAKE SUDDENLY AND UNEXPECTEDLY 'RELEASED', SENDING THE CAR LURCHING FORWARD AND REQUIRING DRIVER TO SLAM ON BRAKES TO AVOID DRIVING OVER A CLIFF). VEHICLE EPB INSPECTION REQUESTED, MAZDA SERVICE MANAGER STATED THE EPB IS, 'NO LONGER NECESSARY FOR VEHICLE SAFETY', BLAMED THE MALFUNCTION ON 'BREAD CRUMBS' , OFFERED TO REPLACE A DEFECTIVE CONSOLE SWITCH (PRESUMABLY WITH ANOTHER NEW, BUT ALSO DEFECTIVE, SWITCH) BUT REFUSED TO INSPECT THE MECHANICAL/OPERATIONAL ASPECTS OF THE AUTOMATIC EMERGENCY PARKING BRAKE SYSTEM (FOR ABNORMAL RUST, WATER LEAKS, DEFECTIVE CABLES, DEFECTIVE ELECTRICAL WIRING, ETC.). MAZDA USES THE SAME MANUFACTURER OF EPB FOR ALL MAZDA CX SERIES VEHICLES. FEDERAL NHSA RECALLS FOR EPB MALFUNCTIONS WERE MANDATED FOR ALL MAZDA CX SERIES VEHICLES - EXCEPT THE MAZDA CX 9. THE CX 9 USES THE SAME EPB SYSTEM AS DO THE OTHER MAZDA CX SERIES MODELS. IT STANDS TO REASON THAT THE BRAKING ISSUES FOR OTHER MAZDA RECALLS IS THE SAME REASON WHY THE CX 9 SHOULD HAVE RECALLS TO FIX THE AUTOMATIC EMERGENCY PARKING BRAKE SYSTEM. PLEASE ISSUE A RECALL FOR MAZDA CX 9 VEHICLES TO FIX THE AUTOMATIC EMERGENCY PARKING BRAKE DEFECT(S). THANK YOU.

AIR BAGS,SERVICE BRAKES,VISIBILITY/WIPER — Filed 06/21/2020

I'M CONSTANTLY HAVE A FRONT WINDSHIELD ERROR : CAUSING MY VEHICLE TO JUST AUTOMATICALLY STOPING WHILE DRIVING ON THE FREEWAY AND STREETS. MY AIR BAGS DIDN'T DEPLOY WHEN I WAS I A ACCIDENT . I'VE TAKEN IT TO THE DEALER 3 TIMES ALREADY AND THEY ALWAYS HAVE A DIFFERENT EXCUSE OR REASON

AIR BAGS — Filed 07/13/2019

TAKATA RECALL - WAS IN A HEAD ON COLLISION WITH 3 OTHER CARS INVOLVED, ALL CARS WERE TOTALED AND ALL OF THE OTHER CARS' AIRBAGS DEPLOYED WITH THE EXCEPTION OF MINE AND I WAS INJURED AS A RESULT.