2025 Mazda CX-90 Complaints

UNKNOWN OR OTHER — Filed 06/21/2026

Following a period of heavy rainfall, I entered my vehicle and began to drive off when an excessive amount of water suddenly poured into the cabin from the overhead console (where the light and sunroof switches are located). ​To investigate the source of the leak, I opened the sunshade but found no residual water or permanent staining inside. Moving to the exterior, I verified that the sunroof was fully sealed, but I did notice an unusual gap/channel gutter between the top of the windshield and the roofline. ​I took the vehicle to the dealership the following day. While there, I learned that another 2026 CX-90 was brought in at the exact same time for the identical issue. The dealership's technician inspected my vehicle and found that the flap at the bottom of the sunroof drain was stuck. They cleared the debris, verified proper water flow, and cleaned the drains from the roof down as a precaution. They also advised me to avoid parking under trees. ​Because this is an internal gutter system, a simple clog shouldn't result in immediate, severe cabin flooding over critical electronics. This is a serious safety hazard and a design flaw. Left unaddressed, this issue poses a severe risk for electrical shorts, potential vehicle fires, and toxic mold development. This design vulnerability needs to be formally addressed by the manufacturer.

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM — Filed 07/14/2026

I own a 2026 Mazda CX-90 hybrid with approximately 13,000 miles. The vehicle began making a grinding noise while driving, which has progressively worsened over time. It has since developed a hard knocking noise accompanied by noticeable vibration when the vehicle shifts gears. This knocking occurs during normal in-town driving. I have taken the vehicle to the selling/authorized Mazda dealership on two occasions — June 2, 2026 and July 14, 2026. On both visits, the dealer was able to reproduce and confirm the noise and knocking. The dealer stated they are aware other customers have reported the same issue, but that Mazda considers the noise/knocking acceptable and declined to perform a repair. No warning lights or diagnostic trouble codes have appeared at any point; the only symptoms are audible and physical. The vehicle is under both factory warranty and a purchased service/maintenance agreement. It has only been inspected by the selling dealership; no inspection has been performed directly by Mazda North America, law enforcement, or an insurance representative. I am concerned about my safety and the safety of others because a worsening, unexplained drivetrain issue that produces hard knocking and vibration during routine driving suggests a mechanical fault that could progress to sudden failure, and the manufacturer has declined to investigate or repair it further despite the symptom escalating across two documented visits. The vehicle remains available for inspection upon request.

POWER TRAIN,UNKNOWN OR OTHER — Filed 07/04/2026

My car is literally stalling out on me. It started by sputtering when I put my foot on the gas a week or so ago. Then today It literally started just losing power while driving. It’s not throwing any codes but that’s super dangerous and this car is only a year old. I am extremely concerned for my safety.

STRUCTURE — Filed 06/12/2026

My driver door would not open from the inside. Doors are unlocked, but only the driver side door will not open from the inside. Driver side door can only open from the outside.

STEERING,SERVICE BRAKES,LANE DEPARTURE — Filed 12/11/2025

Every time I drive the vehicle, it basically snatches me back into the lane aggressively. If I am moving into the next lane, the lane correction is so aggressively, I am afraid it is going to cause a collision. The brakes squeak and squeal constantly. They have oiled the brakes but it didn't work.

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 04/18/2026

Hybrid battery recall was replaced and failed a month later for a second time burning other systems and causing a compete failure in the car. It failed in a deserted portion of [XXX] while traveling from [XXX] to [XXX] for important business. This left me stranded in the middle of the [XXX] desert late at night in a dangerous area. It failed on the highway loosing complete power with multiple failures reported on dashboard. I was left stranded in the middle of nowhere with no nearby services or immediate assistance and was forced to remain in the vehicle overnight in unsafe conditions. The vehicle required towing, and I was later informed the issue was again the hybrid battery the same component that had already been replaced under recall less than one month prior. This repeated failure creates a serious safety concern because the vehicle can unexpectedly lose power and leave occupants stranded without warning, even in remote or unsafe locations. In addition it lost power on the highway and that posses a significant safety concern. The vehicle is unreliable given its age and repeated failures, and I am requesting investigation into a potential safety defect involving the hybrid battery system and sudden loss of propulsion/power and damages to other parts. I had 8 different warnings on my dashboard before the car completely died and I couldn’t even open or close windows or lock and unlock doors. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FORWARD COLLISION AVOIDANCE,LANE DEPARTURE — Filed 09/30/2025

There is an intermittent issue where the dashboard will indicate that the rear side radar is obscured and turn off all the safety features of the car. This happens typically on a clear day when there should be no issues. Turning off the car resets this. Its unsettling because as there are quite a few blind spots in this vehicle you are dependent on the blind spot warning, especially in heavy traffic. Reported it to dealer but they indicated since its intermittent there isn't much they can do. Ridiculous for a new $45k vehicle

ELECTRICAL SYSTEM — Filed 01/10/2026

2025 backup camera not working with 8,500 miles on the car. This is a safety hazard and so far neither Mazda of Everett who broke it will not fix it unless I pay just about 1,300. They claim I have to talk to Mazda to see if they will warranty the part even though I have a 4 year 48,000 mile bumper to bumper warranty. There is no damage to the car what so ever and it has been inspected by the dealer since new with a 190 point inspection at 3,700 miles and never a problem with the camera. EITHER THE BACKUP CAMERA IS A BAD DESIGN THAT DOES NOT ACCEPT NORMAL USAGE OR THE DEALER DOES NOT TAKE SAFTEY FEATURES SERIOUSLY and broke it when washing the car.

ENGINE — Filed 12/22/2025

I am submitting this complaint regarding my 2025 Mazda CX-90 PHEV, leased in April 2025. Since early in my lease, the vehicle has had ongoing drivability issues that have worsened over time and now present a serious safety concern.From the beginning, the vehicle exhibited jerking and hesitation while driving. Initially minor, this has become more frequent and now includes stalling behavior during normal driving conditions, including acceleration and traffic flow. This creates a risk of collision, especially when merging or at intersections.Approximately six months into my lease, the radiator failed and had to be replaced. More recently, while driving, multiple warnings appeared at once: Hybrid System Malfunction, Battery System Malfunction, Oil Monitoring Malfunction, and i-ACTIVSENSE partially disabled. These warnings were documented.Two weeks prior, the dealership reported no diagnostic codes. However, on my most recent visit, I was told via video that the active air shutter is now the issue. The required part is on backorder until August. I was told I could either remain in a non-comparable loaner while still making full lease payments, or continue driving the vehicle in its current condition until the part arrives. I find this unacceptable given the safety concerns.I expressed that I do not feel safe driving this vehicle, but the service advisor stated this is “not a safety concern.” I disagree. A vehicle that jerks, hesitates, or stalls while driving, combined with multiple system malfunctions and disabled safety features, presents a clear safety risk.I also disclosed prior to leasing that I do not have access to charging. I was told this would not be an issue. I am now being told that not charging the vehicle may be contributing to the problem. Service advisors have also indicated these vehicles have known hybrid battery issues.I no longer feel safe driving this vehicle and am concerned for my safety and my family’s safety.

SEAT BELTS,SEATS — Filed 03/18/2026

Seatbelt got stuck between seat and seat frame. Seatbelt was stuck in the locked position and was neither able to be retracted or pulled out rendering the seatbelt unusable. This is a huge safety concern as we were stranded at night with small children and unable to use the seatbelt. A recall should be made to this vehicle (Mazda cx90). Further Mazda is claiming that seatbelts are not part of the warranty (it’s a <1 year old car) and they are charging $1000 to fix this. This is a huge safety issue to not have a functioning seatbelt and a design flaw that should be fixed. It is too easy under normal use for this to occur.