2016 Nissan Frontier Complaints

UNKNOWN OR OTHER — Filed 07/28/2026

OUR 2016 NISSAN FRONTER HAS A SLOW AIR LEAK ON THE TIRES AFTER HAVEING THEM CHECKED BY A TIRE DEALER IT WAS FOUND THE TIRE PRESSURE SENSOR (TPS) WAS LEAKING AT THE CORE DEALER WAS UNABLE TO REMOVE THE CORE OR THE NUT THAT HOLDS THE TPS ON THE WHEEL. GALVONIC REACTION HAD WELDED ALL IN PLACE . DEALER CUT THE VALVE OFF AND REPLACED WITH A NEW TPS (NON METAL) AS IS THERE PRATICE AS THEY HAVE HAD PROBLEMS WITH METAL ONES IN THE PAST . I THINK THIS COULD BE A PROBLEM WITH OTHER TPSs AND COULD HAVE LOSS OF AIR PRESSURE OR AT LEAST THE OWNER WOULD BE UNABLE TO ADD AIR TO TIRE THE TPS IS A STOCK NISSAN SCHRADER ELECTRONICS RTPMS 40700 1AA0B BLUE IN COLOR

FUEL/PROPULSION SYSTEM — Filed 10/17/2025

I am experiencing a fuel pump issue that stalls the engine while driving. The issue will sometimes go away if I first loosen the fuel cap on the gas tank to relieve built up pressure but after driving for 10 to 15 minutes or so the vehicle will begin to jerk while accelerating then it will stall and cut off. I have to wait a few minutes once it cuts off and then I can start the engine up again and drive for another 10 to 15 minutes before the issue occurs again. The vehicle has over 120,000 miles on it and all parts are original to the vehicle.

STRUCTURE — Filed 08/01/2024

A loud squeaking has developed during every day driving. After inspecting - the front right truck bed mounting location has cracked and failed.

FUEL/PROPULSION SYSTEM — Filed 09/12/2024

WHILE FUELING AT DIFFERENT GAS STATIONS THE TANK SPILLS/BELCHES GAS ALL OVER. THIS IS A MAJOR SAFETY ISSUE AND NEEDS RECALLED. THERE ARE ENDLESS COMPLAINTS ON [XXX] OF SIMILAR ISSUES OCCURRING TO OTHER FRONTIER OWNERS. I TOOK IT TO MY LOCAL MECHANIC AND WAS QUOTED OVER $800 TO REPLACE ALL 5 COMPONENTS OF THE SYSTEM AS NISSAN HAS SUGGESTED IN A BULLETIN FOR MECHANICS. IF NISSAN IS AWARE OF THIS ISSUE ENOUGH TO ISSUE A TECHNICAL BULLETIN THEN THE ISSUE NEEDS TO BE RECALLED AND REPAIRED FOR FREE BECAUSE GAS SPILLING/SPRAYING ALL OVER ME EVERY TIME I FILL UP MY VEHICLE IS OUT RIGHT DANGEROUS AND UNSAFE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AIR BAGS — Filed 12/01/2023

The airbag warning light is blinking and has been for approximately 9 months. I live in Salida, CO which does not have a Nissan Dealership to take my vehicle into for servicing. I recently saw an article on Fox 31 News pertaining to the same airbag malfunction and would like to know what to do about my problem.

ENGINE — Filed 06/26/2024

Head gasket blew and it warped the heads at 98,000 miles Replace motor with a 51,000 mile motor and less than 2 months later, motor is knocking inside with broken peices of the motor. I have to replace it again.

WHEELS — Filed 06/04/2024

The issues iw with the lug nuts expanding locking on the tire so it cannot be takeoff for rotation or replacement or if you have a flat tire tout on the spare. Went to BJ's tire in Pasadena, MD (1-410-647-6600) to have a rotation and they said they could not do it the lug nuts expanded to larger size and it could cross thread if they got them off and tried tout them back on. AS WELL THEY MIGHT NOT BE SECURED TIGHT ENOUGH THAT THEY WOULD NOT FALLOFF WHILE DRIVING. A SAFTY ISSUES WITH BJ'S. BOTH MECHANICS VERIFIED IT AND THE TWO MANAGERS OF THE STORE AS WE.. I did not believe them so I took it to Sheehy Nissan in glen Burnie where the two top managers verified that the lug nut expanded so large they had to be replaces OR IT WOULD BE A SAFTY ISSUE with me driving with he old one on as they cannot be safely tightened down and may come off during driving. So I need all 24 lug nuts replaced. I think he said they expanded from 21 mm (or cm) to 22.5 mm (or cm).the manager has been doing this for over 30 years and his assistant said the same who has been doing it for over 25 years. Mr Brian Jordan at 1-410-760-3500 ext #81052) So I need all 24 replaced as the rest could expand. The real cost is over $800 but willing to do it for like $550 plus tire rotation. As both BJ's managers and tire people and Nissan managers are saying thesis a serious safety issue I believe them. They say unless proper tools used other issues can occur. And ALMOST IMPOSSIBLE TO REMOVE BY THE OWNER OF THE VECHILE. Especially if the person icon the road replacing the tier with the spare. They showed me on the internet the issues with ford and other manufactures from before 2000 having this issue. As I am [XXX] it would be really hard to deal with if an emergency came up o the road. You need look into this issue. IT IS A REAL SAFETY ISSUE esp. for older folks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN,SERVICE BRAKES — Filed 12/31/2023

My 2016 Nissan Frontier is leaking axle grease from the driver side rear tire. The grease/oil got all over the brake pads, rotor, and emergency brake. This seems to be a very common issue that was supposed to have been resolved several models prior.

AIR BAGS,FORWARD COLLISION AVOIDANCE — Filed 04/05/2023

Airbags didn’t deployed when the incident of the the truck crashed at the time. (April 05,2023)

AIR BAGS — Filed 12/15/2022

The contact owns a 2016 Nissan Frontier. The contact stated that while operating the vehicle air bags warning light remained illuminated. The vehicle was taken to the local dealer who determined that the air bag system was disconnected under the passenger’s side dashboard. The system was reconnected, and the failure was remedied. The contact stated that the failure had recently reoccurred. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 90,632.

VISIBILITY/WIPER — Filed 04/17/2023

All glass in vehicle showing spotted areas with factory tinting

ENGINE — Filed 11/01/2021

The contact owns a 2016 Nissan Frontier. The contact stated that while driving approximately 60 MPH, the vehicle lost motive power and stalled. There were no warning lights illuminated. The contact was able to restart the vehicle. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 90,000.

AIR BAGS — Filed 01/01/2021

I HAVE A 2016 NISSAN FRONTIER WITH ONLY 68,000 MILES ON IT. THE AIRBAG LIGHT ON THE DASH STARTED FLASHING. I TOOK IT TO ANY MOHR NISSAN AND THEY DIAGNOSED THAT THE SENSOR INSIDE THE PASSENGER SEAT THAT TELLS THE SYSTEM IF SOMEONE IS SITTING THERE HAS FAILED AND THAT IT IS AN $1800 REPAIR, BECAUSE THE ONLY WAY TO FIX IT IS TO REPLACE THE WHOLE SEAT. THEY SAID THEY COULDN'T SAY WHETHER THE AIRBAG WOULD DEPLOY OR NOT IN AN ACCIDENT IF I DIDN'T FIX THE SENSOR.

FUEL/PROPULSION SYSTEM — Filed 11/24/2020

WHILE FUELING AT DIFFERENT GAS STATIONS THE TANK SPILLS/BELCHES GAS ALL OVER. THIS IS A MAJOR SAFETY ISSUE AND NEEDS RECALLED. THERE ARE ENDLESS COMPLAINTS ON WWW.CLUBFRONTIER.ORG OF SIMILAR ISSUES OCCURRING TO OTHER FRONTIER OWNERS. I TOOK IT TO MY LOCAL MECHANIC AND WAS QUOTED OVER $800 TO REPLACE ALL 5 COMPONENTS OF THE SYSTEM AS NISSAN HAS SUGGESTED IN A BULLETIN FOR MECHANICS. IF NISSAN IS AWARE OF THIS ISSUE ENOUGH TO ISSUE A TECHNICAL BULLETIN THEN THE ISSUE NEEDS TO BE RECALLED AND REPAIRED FOR FREE BECAUSE GAS SPILLING/SPRAYING ALL OVER ME EVERY TIME I FILL UP MY VEHICLE IS OUT RIGHT DANGEROUS AND UNSAFE. BULLETIN NUMBER NTB16-122

ENGINE — Filed 07/15/2020

ENGINE VIBRATION AT LOW RPM THAT CAN'T BE EXPLAINED BY SEVERAL MECHANICS.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 11/06/2020

ENGINE HESITATES OR STALLS ON ACCELERATION. WHEN PULLING OUT FROM A STOP ENGINE HESITATES TO NEAR STALL NO MATTER HOW HARD OR FAR YOU PRESS GAS PEDAL. EXTREMELY DANGEROUS. INTERMITTENT ISSUE, NO FAILURE CODES WHEN TESTED. IF ENGINE DOESN'T STALL, VEHICLE IS AT A STAND STILL EVEN WITH GAS PEDAL TO FLOOR OR PUMPING GAS PEDAL. IS HAPPENING ALL THE TIME, EXTREMELY DANGEROUS. NEARLY HIT BY ONCOMING TRAFFIC SEVERAL TIMES. DEALERSHIP HAS HAD MANY REPORTS OF SAME ISSUE, BUT NO SOLUTION. I AM AFRAID TO DRIVE VEHICLE.

STEERING,UNKNOWN OR OTHER — Filed 08/24/2020

KEY LOCKED IN IGNITION THEN STEERING WHEEL LOCKED. CAR WAS PARKED AT A PUBLIC BEACH PARKING LOT BEFORE THE ISSUE OCCURRED.

POWER TRAIN,ENGINE — Filed 08/01/2020

TRANSMISSION AND BRAIN REPAIR BY DEALERSHIP UNDER WARRANTY 20017, AND OVERHEATING PROBLEM DUE TO RADIATOR IN 2020 AFTER EXPIRE OF WARRANTY, $1000 OUT OF POCKET REPAIRS.

ELECTRONIC STABILITY CONTROL (ESC),SERVICE BRAKES — Filed 06/10/2020

THE YAWRATE SENSOR AND ABS DIAGNOSTIC MODULE HAD TO BE REPLACED TO KEEP MY VEHICLE FROM GRABBING THE BRAKES AS I STARTED DRIVING

FUEL/PROPULSION SYSTEM — Filed 12/30/2019

HESITATION FROM IDLE TO TAKE OFF-NEVER KNOW WHEN IT IS GOING TO ACT UP,FOR EXAMPLE TURNING IN FRONT OF ANOTHER VEHICLE-- WILL I MAKE IT THIS TIME WITHOUT AN ACCIDENT? *TR

UNKNOWN OR OTHER — Filed 06/24/2019

MY VEHICLE WAS BURGLARIZED. THE THIEVES GOT IN THROUGH THE REAR SLIDING GLASS. THE LATCH DOES NOT LOCK AND IS FAULTY. IF THE LATCH WAS FULLY FUNCTIONAL, NOBODY WOULD HAVE GONE IN AND STOLEN EVERYTHING I OWNED.

ELECTRICAL SYSTEM — Filed 05/05/2019

WAS DRIVELING DOWN A STRAIGHT CITY STREET ON A CLEAR SPRING DAY AT ABOUT 30 MPH AND THE CAR TURNED OFF INCLUDING ALL ELECTRICAL DEVICES WITHOUT WARNING. THEN ABOUT 1.5 SECONDS LATER THE CAR TURNED BACK ON.

ELECTRICAL SYSTEM,STRUCTURE,ENGINE — Filed 01/17/2019

IN MOTION, PULLING INTO PARKING STALL, WHEN SOMETHING STARTED TO SMELL LIKE IT WAS ON FIRE, STARTED TO SEE FLAMES COMING FROM MOTOR. CAR CAUGHT ON FIRE. POLICE CASE #19-0773 *DT *DT*JB

AIR BAGS — Filed 02/20/2018

WE PURCHASED OUR 2016 NISSAN FRONTIER IN OCTOBER 2016. UNFORTUNATELY WE HAVE BEEN INVOLVED IN THREE MAJOR CAR ACCIDENTS AND TWO OUT OF THE THREE TIMES THE AIR BAGS DID NOT DEPLOY. EVERY ACCIDENT WE WERE INVOLVED IN COST OVER $10,000 TO REPAIR OUR VEHICLE SO WE KNOW THAT THE FRONT END DAMAGE WAS VERY SEVERE. WE WOULD LIKE OUR VEHICLE INSPECTED FOR ANY AIR BAG MAIL FUNCTION THE LAST ACCIDENT WE WERE INVOLVED IN WE HIT VERY HARD AND THE AIR BAGS DIDN'T DEPLOY I HIT THE STEERING WHEEL PRETTY HARD.

STEERING,SUSPENSION,WHEELS — Filed 12/02/2016

LIBERTY MUTUAL INSURANCE APPROVED A BODY SHOP TO REPAIR MY TRUCK FROM AN ACCIDENT (I WAS NOT AT FAULT) BY REMOVING ALL PARTS OF MY TRUCK FROM IT'S ORIGINAL FRAME AND PUTTING IT BACK TOGETHER ON ANOTHER FRAME. I WAS SITTING STILL, WHEN I WAS HIT FROM BEHIND AND PUSHED INTO VEHICLE IN FRONT OF ME. ALL PARTIES GOT STOPPED, EXCEPT THE LADY THAT HIT ME IN THE REAR.