2022 Nissan Pathfinder Complaints

SUSPENSION — Filed 06/30/2026

The contact owns a 2022 Nissan Pathfinder. The contact stated that the vehicle previously received a repair on the rear brakes at approximately 30,000 miles; however, the vehicle recently received an oil change at an independent mechanic, and it was discovered that the rear brakes showed excessive wear. Additionally, it was discovered that the rear shocks were worn. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 46,000.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 08/03/2026

A/C and electrical board

UNKNOWN OR OTHER — Filed 06/13/2026

I am reporting a systemic safety defect regarding the rear Air Conditioning (AC) lines/hoses in the 2022 Nissan Pathfinder. The rear AC lines are prematurely corroding and leaking refrigerant, mirroring a previous recall Nissan issued for the front AC lines due to similar corrosion issues. On June 13, 2026 at approximately 86,000 miles, my vehicle's rear AC system failed due to a rotted, leaking line. This defect creates several critical safety hazards: 1. FLAMMABILITY HAZARD: The 2022 Pathfinder uses R-1234yf refrigerant, which is classified as an ASHRAE A2L mildly flammable gas. A rapid, uncontrolled leak of pressurized R-1234yf near hot exhaust components or electrical wiring creates an unmitigated vehicle fire risk.  2. TOXIC GAS EXPOSURE: If R-1234yf ignites or comes into contact with high heat, it thermally decomposes into hydrogen fluoride. This turns into highly toxic hydrofluoric acid upon contact with moisture, posing an immediate inhalation and chemical burn hazard to vehicle occupants and first responders. 3. OCCUPANT HEALTH RISK: Sudden climate control failure in extreme summer temperatures poses a risk of heat-related illness for vulnerable passengers, like children or the elderly, in the rear seats. 4. REPEATED DEFECT: Nissan previously acknowledged their factory AC lines were prone to premature corrosion but only recalled the front lines. The rear lines suffer from the exact same material or manufacturing defect. This is a widespread issue widely documented by numerous 2022 Pathfinder owners. I request that NHTSA open a safety defect investigation to expand the previous recall remedies before this visibility hazard causes a severe accident.

SERVICE BRAKES — Filed 11/01/2024

The rear brakes on my 2022 Nissan pathfinder are having unusual fast deterioration. I purchased the car at 13,000 miles and had to replace the rear brakes at 25,000 miles and now once again I am having to replace the rear brakes again at 52,000. This seems very odd since the front brakes have not needed replacement yet. I also have been advised to replace the rear calipers which are also very early for a car with 52,000.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 05/28/2025

Components Affected: STRUCTURE:SUNROOF | ELECTRICAL SYSTEM | VISIBILITY/WIPER Description of Safety Hazard: My 2022 Nissan Pathfinder suffers from a severe, chronic manufacturing defect causing substantial water intrusion into the vehicle's cabin through the sunroof assembly during rainfall. To date, the manufacturer’s authorized dealership network has attempted to repair this exact leak three separate times and has failed to cure the defect. This unfixable water leak creates two distinct, critical safety hazards: 1. Electrical Failure/Fire Risk: Water actively flows into the headliner, pooling behind the dashboard and running down the A-pillars. This directly exposes critical safety electronics—including the side-curtain airbags, rearview mirror sensors, forward-collision camera arrays, and steering column electrical modules—to active moisture. This creates a severe risk of sudden, catastrophic electrical short-circuits, unintended airbag deployment, or sudden loss of safety assist systems while operating the vehicle at highway speeds. The vehicle is currently leaking for a fourth time. Because the manufacturer's certified network is entirely incapable of sealing the vehicle or curing this defect, the vehicle remains an ongoing safety hazard to its occupants and other motorists on the road.

VISIBILITY — Filed 06/13/2026

The contact owns a 2022 Nissan Pathfinder. The contact stated that while driving at 7 MPH, the sunroof exploded outward. The sunroof cover was closed during the failure, preventing glass fragments from falling inside the vehicle. The contact pulled over to the side of the road. Upon inspection, the contact became aware that the sunroof had exploded without impact. The vehicle was driven to the residence and was parked in the garage. The dealer was contacted and provided an estimate for the repair. The vehicle was not diagnosed or repaired due to the cost. The manufacturer was not yet contacted. The failure mileage was unknown.

STRUCTURE — Filed 05/22/2026

Panoramic sunroof drains failed due to being pinched by headliner. Documented water leaking into vehicle at 6060 by dealership. Water coming in along the a pillar and roof. Vehicle has been in the shop 3 separate times for gurgling noise and roof leaks. Dealership had issues re-creating issue. It’s a known engineering defect by the manufacturer but no recall has been issued.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SERVICE BRAKES — Filed 12/06/2025

First Incident- volume kept rising on its own. Would turn it down, it would go right back up. Would turn the radio off, it would turn on by itself and would keep rising until full blast. Vehicle was parked, came back from work, turned vehicle on and the volume was fine on it. Second Incident- (this has happened twice) about a month after the volume incident. This time the vehicle would accelerate by itself. No cruise control was on, vehicle would keep going faster and faster. First time this happened the vehicle needed to be towed, cops were involved. I finally was able to stop the vehicle at a red light (where it eventually broke down and would not start). Extended warranty covered the tow. There was no check engine light on. Replaced the battery as I was told the errors were pointing back to low voltage. After battery was replaced, maybe three weeks later the vehicle did the same thing on the highway again. Car speed kept increasing on its own, no cruise control or pedal input. Vehicle kept speeding. I took this vehicle to Moon Township, PA Nissan Cochran dealership and they could not replicate the issue. I have video proof the first time this happened where the vehicle kept increasing in speed without pedal input. I have two kids under the age of [XXX] , This is an unsafe vehicle and it has lost my trust completely. The extended warranty company for this vehicle said they can’t do anything since the dealership says no check engine light is on. Third incident- got into vehicle, turned the vehicle on and the parking brake would not release. The parking brake was never applied in the first place so I have no clue how or why it was on when I turned the vehicle on. I just recently called the dealership on this issue now (Moon Township, Nissan Cochran) and will see what they say. Again, no check engine light is present. I am at a loss on this vehicle. 2022 with only 45k miles on it and have never experienced this many issues with a vehicle before! It is unsafe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER — Filed 04/18/2026

I am writing regarding the defective condition of the 2022 Nissan Pathfinder (approx. 16,431 miles) purchased on Nov 10, 2025. With the onset of spring, the A/C system has failed, blowing only ambient air. This aligns with known manufacturer defects: Jump Tube Defect (PC899/PC939): Faulty seals causing refrigerant leaks. A/C Amplifier (NTB23-033A): Irregular airflow and spontaneous surges. Notably, I reported HVAC and mechanical concerns within the 90-day warranty period. On Dec 20, 2025, I notified the dealership of whistling sounds/airflow bursts and clicking noises in the steering system. Although technician dismissed these as "normal" at the time, reporting them within the warranty period preserves my right to repair. While previous issues (loose bolts/chassis vibration) were resolved, the HVAC irregularities persist. On April 18, 2026, I returned to report the A/C failure and was denied a complimentary diagnostic, despite the vehicle being sold in a defective condition. Requested Actions: Full Diagnostic: A comprehensive, no-cost inspection of the entire HVAC system. Complete Repair: Replacement of the condenser, jump tube, seals, A/C amplifier, and related components under dealer responsibility/manufacturer goodwill. System Service: Full evacuation and recharge of refrigerant to manufacturer specs. Confirmation that the vehicle is returned in fully functional and safe condition at no cost due It was reportes during warranty period.

VISIBILITY/WIPER — Filed 04/09/2026

While driving down the road or a smooth road 60 mile an hour 60° weather, it sound like a bomb went off inside my car after walking around my car I saw nothing wrong and then before I got in I noticed something on top of the car and it was my panoramic window blown up

SERVICE BRAKES — Filed 04/09/2026

My 2022 Nissan Pathfinder was purchased new and now has 27150 miles. On April 9 2026, I was having my summer tires installed and was told by the tire shop that the rear brakes were worn out and needed replacement. I contacted the Nissan dealership who quoted a cost of $570 for brake replacement. There was no warning lamps or other symptoms but there is only 3mm of brake pad left. Per the dealership, at 2mm the pads will begin grinding on the rotors. The vehicle has not been used to tow or used off road and the brake pads should last much longer then 27K miles. They, or the brake system components installed by Nissan, are obviously defective.

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 01/28/2026

Front collision sensor has failed, on a vehicle that had 40,000 miles. This keeps the adaptive cruise being able to be used as well as automatic emergency braking.

SERVICE BRAKES — Filed 03/20/2026

Vehicle has 65k miles on it and has already been through 2 sets going on 3 of brakes there has been maybe 6k miles put on it and the brakes are going and possibly rotors it feels like the brakes aren't fully releasing. I've seen alot of people complaing so I know its just not my imagination.it makes the vehicle seem like it takes longer to stop

AIR BAGS — Filed 03/13/2026

I am submitting this complaint to report a serious safety issue involving the airbag system in my vehicle. The airbag warning light has illuminated on the dashboard, and I also received a notification indicating that the airbag system may not function properly in the event of a crash. This creates a significant safety risk, as the airbags may fail to deploy when needed. I contacted an authorized Nissan dealership regarding this issue. The dealership informed me that they have received similar complaints from multiple vehicles of the same generation as mine. However, they advised me to wait for a potential recall rather than proceed with immediate diagnostic and repair, stating that repairs at this time would be very expensive despite the vehicle being only three years old. Given the critical safety function of airbags, this situation is extremely concerning. A potential failure of the airbag system could result in serious injury or death in the event of an accident. I am requesting that this issue be investigated promptly to determine whether a defect exists that warrants a safety recall. It appears this may be a broader issue affecting multiple vehicles, not an isolated incident

ENGINE — Filed 02/12/2026

⸻ My 2022 Nissan Pathfinder experienced a catastrophic engine failure at approximately 70,000 miles. The vehicle suddenly developed severe engine knocking and required a complete engine replacement. There were no engine warning lights or oil pressure warning lights prior to the failure. The vehicle had been maintained according to the manufacturer’s recommended service intervals, including oil changes using full synthetic oil. The Nissan maintenance system indicates oil changes at approximately 10,000 mile intervals. Because there were no warning indicators prior to the failure, the issue occurred without any notice to the driver. A sudden engine failure without warning could present a potential safety risk if it occurred while driving in traffic or at highway speeds. The repair required a full engine replacement at a cost exceeding 8,000. The vehicle was just slightly outside the manufacturer’s powertrain warranty at the time of failure. Given the relatively low mileage and lack of warning indicators before the engine failure, I am submitting this complaint so the issue can be documented and evaluated for potential safety concerns or patterns of engine failure in this vehicle model.

ELECTRICAL SYSTEM — Filed 07/23/2025

The vehicle AC has stopped working. This is the ongoing problem in which can cause a fire anytime a leak occurs or a failed AC compressor without anybody knowing can cause a fire oppose a threaten Safety to the community.

STRUCTURE,UNKNOWN OR OTHER — Filed 02/07/2026

Hi as I was driving my car on a clear road no cars near my car all of a sudden my sunroof exploded as if it was shot my a military tank we panicked thankfully tried to maintain calm and it didn’t hurt my children and thankfully no car was around as the sound did put us at panick mode which could have resulted in a car crash from the cause of the incident

UNKNOWN OR OTHER — Filed 01/14/2026

While driving at a moderate speed of 65 mph, the back portion of my panoramic sunroof spontaneously shattered. There was a very loud noises followed by rattling of the glass on the sun roof cover. I pulled over immediately and pulled the sunroof cover half way back to see a hole the size of a softball through the sun roof. There is no debris that was flying in the air, on the road, or any signs of an object hitting my car. On inspection there was no body damage from my car and when i looked into the hole of the sunroof there was no object within it. There was also no vehicles directly in front of me, only a vehicle 150 feet in front. The weather was cloudy, but no rain or wind.

ELECTRICAL SYSTEM,AIR BAGS,ENGINE — Filed 07/31/2025

Car caught fire when off and parked.

AIR BAGS,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 09/08/2024

The contact owns a 2022 Nissan Pathfinder. The contact stated that while the wife was driving approximately 60 MPH and attempting the stop, the braking system malfunctioned and the vehicle did not stop or reduce speed while the brake pedal was being pressed causing the vehicle to crash into the rear of a second vehicle. During the crash, the collision avoidance system did not activate and the air bag did not deploy. No injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The failure mileage was 38,600.

SEATS — Filed 06/22/2024

My Toddler was seated (in the car seat that was buckled into ) the second row bucket seat. While driving the vehicle we hit a bump in the road which then launched the back passenger seat up and forward pinning my child between the two seats. His face smashed into the front passenger seat headrest which caused forced injury to his head. The EZ seat button could not have been reached by my child due to them being in a car seat. This has been reported to the manufacture of Nissan. There are no warnings for this feature.

SEATS — Filed 01/06/2023

While I was driving my toddler who was in the 3rd row pushed the bottom located at the back of the 2nd row seat. The seat came foward with my baby who was in his carseat causing him to come foward at a really high speed (since the seat moves foward really fast and with impulse) causing him to hit his head and almost causing me to crash. I had to stop in the middle of where I was driving since my baby was screaming and crying and couldn't breath since he was being squished by the seat. The seat is very heavy and hard to push back in case of an emergency from someone sitting in the back row. You have to actually get down to be able to put it back in it's place.

UNKNOWN OR OTHER — Filed 08/14/2023

2022 NISSAN PATHFINDER SL AWD UNDER WARRANTY. WIFE AND CHILD APPROACHED CAR, THE PROXIMITY UNLOCK DIDN'T WHEN TOUCHING THE DOOR HANDLE. WIFE PULLED OUT KEY FOB AND HIT UNLOCK BUTTON. THEN PLACED CHILD IN CAR SEAT BEHIND DRIVER. THE KEY FOB WAS INSIDE OF DIAPER BAG ON FLOOR BOARD DIRECTLY IN FRONT OF CHILD SEAT AND BEHIND DRIVER SEAT. WIFE NEVER INITIATED A DOOR LOCK NOR HEARD ANY AUDIBLE LOCK MECHANISM. SHE THEN CLOSED THE BACK DOOR AND WENT TO OPEN THE DRIVERS DOOR. THE DOOR WAS LOCKED AND POLICE AND EMS VIA 911 WERE CALLED TO FORCIBLY ENTER CAR SINCE IT WAS NEAR 100 DEGREES OUTSIDE. LATER THAT DAY THE LOCAL NISSAN DEALER SERVICE SAID THAT NOTHING WAS WRONG WITH THE VEHICLE AND SAID NOTHING COULD BE DONE. I TRIED MULTIPLE TIMES TO DUPLICATE THE DOOR LOCK WITH FOB INSIDE LAST NIGHT AND COULD NOT GET IT TO DUPLICATE WHAT HAPPENED YESTERDAY. MY NINE MONTH OLD SON WAS SEEN BY URGENT CARE AND EMS PERSONNEL BUT NOT POLICE REPORT WAS FILED SINCE THERE WAS NO ACCIDENT AND MY SON DID NOT REQUIRE IMMEDIATE EMERGENCY CARE, JUST CAUTIOUS HEAT IMPACT CARE AT LOCAL URGENT CARE CLINIC. UPON FURTHER RESEARCH APPEARS THIS ISSUE WITH NISSAN KEY DEFECTS GOES BACK MULTIPLE YEAR S AND VEHICLES AND HAD MULTIPLE NHTSA COMPLAINTS. NONE OF THOSE HOWEVER LOOK TO COVER THE 2022 NISSAN PATHFINDER, HENSE THIS COMPLAINT.

POWER TRAIN — Filed 06/16/2022

On 6/16/2022 our vehicle did not allow me to pull my boat and trailer up a gravel road hill leaving our RV Park at 31733 Aqua Vita Road, Gravois Mills, MO 65037. a)Front wheels started slipping but the rear wheels never engaged. b)Either the brakes were applied or engine power was derated despite application of the throttle. c)I didn't just continue to slip the front wheels but kept stopping, adjusting the traction selector and then try again until a warning pulled up "AWD Overheat, Stop Vehicle". At least twice during throttle application there was unanticipated rollback of the vehicle. a)This sudden rollback surprised me and by the time I could react, the vehicle rolled back several feet, sliding in the gravel back down the hill. b)This rollback was partially uncontrolled and caused the trailer to back at an angle down the hill. c)The trailer backed into a tree just off the road keeping the trailer, boat, vehicle and 5 occupants from rolling off the side of the road d)If not for the tree there would have been great personal property damage, physical harm to the occupants, possibly even death.

UNKNOWN OR OTHER,LANE DEPARTURE,FORWARD COLLISION AVOIDANCE — Filed 08/29/2022

While driving the vehicle automatically applied brakes even though there was nothing in front of me. There was a car in left lane but nothing in front. No crash this time but close to being rear ended. Also backing up i took my eyes off camera to look in mirror, there was a car behind me & BAM we collided. Not warning beep, no applying brakes when it should have.