2019 Ram 2500 Complaints

AIR BAGS — Filed 09/12/2026

My vehicle is displaying a service airbag system warning message. The vehicle was not in a crash. Diagnostic codes read by the dealer indicate ‘ Driver Seatbelt Retractor Pretensioner Deployment Control Circuit Open. There is an open recall (W67, NHTSA campaign ID 20V-580) for select 2019 model year ram 2500’s. My vehicle does not appear to have been included in the initially identified suspect population but requires the repair indicated by W76

POWER TRAIN — Filed 07/16/2026

While attempting to pass traffic the truck did not want to shift above or down from 4th gear. This has happened twice now and both times I had to pull over and restart the truck. My safety was put at risk due to lack of propulsion, high rpm of the truck to maintain speed before pulling over. Check engine light came on both times. Although there appears to be a lack of NHTSA reports, I have been sharing this story with others and looking at Facebook groups and it seems the 68RFE transmission is rife with issues and commonly fails while driving, regardless of towing or not.

POWER TRAIN,ELECTRICAL SYSTEM,FUEL/PROPULSION SYSTEM — Filed 07/27/2026

Transmission Slipping

POWER TRAIN,ENGINE — Filed 08/05/2026

Premature lifter and cam failures on the 6.7 engines. Yes it can be inspected. Yes it was heard and confirmed by multiple dealers and sources. It can be an issue if the engine locks up when driving

UNKNOWN OR OTHER — Filed 07/09/2026

On July 9,2026 I requested information on this truck from the dealership. It was advertised as having 55k miles on it and they were asking for $39. The carfax shows service history at 167k miles. When I confronted the salesman via text, he lowered the price to 32k. I believe this to be odometer fraud since I also asked him to verify if the mileage advertised was correct.

TIRES — Filed 06/10/2026

The contact owns a 2019 RAM 2500 equipped with Fortune Tires, Tire Line: Fortune Tormenta R/T FSR309, Tire size: 35x12.50R20, and DOT Number: 04NL1RTPC. The contact stated that while driving the vehicle at 75 MPH, the vehicle started to vibrate, followed by a noticeable wobble at low speed. The contact pulled over to inspect the vehicle and discovered a very large bulge on the outer side of the front driver's side tire. The vehicle was taken to an independent mechanic, who diagnosed the tire with a busted belt. The tire was later inspected by an authorized Fortune tire shop, and the failure was deemed to be a manufacturer's defect. The contact stated that the failure had recurred while driving on a separate occasion. The contact puller pulled over sooner and discovered that the front passenger's side tire had also developed a matching large bulge. The dealer was notified of the failure. The vehicle was not repaired. No further information was available. The manufacturer was notified of the failure. The vehicle failure mileage was 143,497. The tire failure mileage was 11,000.

STRUCTURE — Filed 08/01/2025

What component or system failed or malfunctioned, and is it available for inspection upon request?: The right-side tailgate hinge assembly on my 2019 Ram 2500 failed and became increasingly difficult to operate. The tailgate now requires excessive force to open and close throughout its entire range of motion. An independent body shop inspected the vehicle and determined that the hinge assembly requires replacement. The vehicle and failed component are available for inspection upon request. How was your safety or the safety of others put at risk? The failure significantly affects the normal operation of the tailgate and requires excessive force to open and close. This creates a risk of injury while operating the tailgate and raises concerns regarding the continued safe operation of the tailgate assembly. The failure of a primary tailgate support component could also affect the tailgate's ability to function as intended. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The problem was inspected and confirmed by an independent body shop. The shop determined that the tailgate hinge assembly has failed and requires replacement. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by an independent body shop. At this time, the vehicle has not been inspected by the manufacturer, police, or insurance representatives. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps, messages, or diagnostic indicators were present. The only symptom was a progressive increase in the force required to open and close the tailgate. I started to notice the issue about a year ago. Since then, the condition gradually worsened over time to the point where when I open it and the tailgate pops out of position.

ELECTRICAL SYSTEM — Filed 05/15/2026

My 2019 Ram 2500 with push‑button start became completely immobilized due to failure of the RF Hub Module. The truck has full electrical power but will not crank, will not click, and will not shift out of Park. The Check Engine Light blinks several times and stays on, and the security system does not activate. This is a known failure on 2018–2020 Ram HD trucks. The RF Hub controls the start authorization and immobilizer system, and when it fails the vehicle cannot be moved, even into Neutral. This is a safety hazard because the vehicle can become stranded in traffic or in unsafe locations. The part is on national backorder with almost no availability in the [XXX] , leaving owners without transportation for weeks or months. Chrysler/Stellantis has not issued a recall or provided alternative solutions. This is a critical safety defect that immobilizes the vehicle without warning.” INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AIR BAGS — Filed 02/25/2026

I was in an accident and my airbags did not deploy. I have a head injury. No Not yet No

POWER TRAIN — Filed 07/14/2025

Two snap rings in transmission came loose and caused a catastrophic fail while I was driving . No warning or sounds before it happened. Almost caused a multi vehicle pileup on the interstate. This is an issue that has been happening to all these trucks.

ENGINE — Filed 09/13/2024

Initially I witnessed a large volume of smoke coming from the exhaust pipe when pulling up to fuel pump. A passer-by informed me that there were flames underneath the truck on the passenger side. I then got out of truck, stooped down to look underneath, and observed a hose leading from the exhaust system on fire and multiple exhaust components glowing red hot. After getting my passenger out of the truck I got back in, put it in drive and pulled forward away from the fuel pumps and made it about forty feet before truck engine stalled. I then proceeded to get a fire extinguisher from the fuel pump lanes and extinguish the fire and directed the remaining agent at the hotspots to cool them. After the fire department ensured the vehicle was safe to move it was towed to the local RAM dealership where it is now awaiting service technicians to inspect the damage after the weekend.

ELECTRICAL SYSTEM — Filed 03/10/2023

Continuation to NHTSA ID # 11511305 Adding some more details and photos of the Fire. (2019 Ram 2500 6.7L Cummins Diesel engine) This is to describe the time frame from the start of the vehicle to when the fire department put out the fire. I have a store receipt that time stamps my checkout time at 2:11p CT, from the time I left the store, loaded my purchases into the truck, started and drove the car a very short distance, when the smoke started to pour out of the inside ventilation system, I pulled the truck over to the side of the road, got out of the truck and called 911 (time stamped from my phone was 2:29p CT. (18 minutes from checkout to 911 call. I Took a picture of the truck after the fire department put out the fire (time stamped 2:38p CT (9 minutes from the start of the 911 call). Adding some pictures of the burnt-out truck. What shows is that the fender on the driver’s side took the brunt of the heat, where all the electrical systems reside. Telling me that this was the main section that started on fire (possibility that the Heater Grid). This was definitely an electrical fire, given the smell and smoke that poured into the truck. I know there is a current recall by the auto maker. I think they should re-evaluate they years that this recall should affect, since my 2019 has the same parts used as the 2021-2023’s. Given the pictures below and the disaster that this caused, we were pretty lucky that it was just me and my wife in the vehicle. We were able to find a spot to pull over so it wouldn’t affect other traffic. What if we were stuck on a highway, in traffic, pulling a trailer in a rural area, who knows what else could have happened. The stress of this is overwhelming, something that I will relive over and over again. Photos and Fire Report attached.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM — Filed 03/10/2023

March 10,2023 2019 Ram 2500 Cummins 6.7L Diesel I picked up my truck from the dealership this morning, after they did the outstanding CP4 fuel pump recall. I drove the vehicle home (approx 20) miles. Parked the car in the driveway for about 3 hours. Then took a short trip to the store. After the store, when leaving the parking lot I noticed an electrical/plastic smell. Within in seconds smoke started to come through the air vents. I pulled the truck over, turned off the truck, open the hood when fire exspelled from the engine compartment. Immediately call the fire department. They arrived in minutes to put out the fire, but at that point the whole front end of the truck was on fire and smoking (dense white/gray smoke). Then there was a loud burst of flame that came from the engine compartment. The fire worked its way into the cab compartment, burned it completely. The truck is totaled.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,ENGINE — Filed 01/10/2023

Smoke emanated from the engine bay shortly after starting the vehicle first thing in the morning. The temperature outside was less 40*. Shortly after seeing smoke, the engine bay was engulfed in flames, centered on the hood, near the windshield. Newer vehicles have fire risk recalls regarding the intake-grid heater shorting out, but not the 2019 model. The grid heater would have been on due to the temperature. Please see the reports from the Police and Fire Department attached. The truck was totaled.

STEERING,AIR BAGS,SERVICE BRAKES — Filed 05/01/2022

The contact owns a 2019 Ram 2500. The contact stated that while her son was driving approximately 24 MPH, the check engine warning light illuminated and suddenly the steering wheel became inoperable causing the driver to lose control of the vehicle and crash into a parked vehicle. During the failure, the brakes were also inoperable. The air bags failed to deploy. There were no injuries reported. A police report was filed and the vehicle was towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The approximate failure mileage was 9,000.

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 04/01/2022

Service antilock came up and break pedal sensitivity change from soft to hard and caused me to missed my stopping force and hit a vehicle

AIR BAGS — Filed 02/27/2022

I was driving on the highway and was rear ended by another vehicle which lifted the back end of my truck from the ground. Both side air bags deployed. I was wearing a hoodie at the time and the airbag deployment caused my hoodie to catch on fire. There was not an open flame for me to know it was burning. Instead, it smoldered and burnt my hoodie material. I could feel the underside of my arm stinging and the holes in my sleeve, but believed that it was a result of the airbag hitting my arm and causing essentially a bad carpet burn. However, this caused second degree burns to the bottom side of my arm near my arm pit. I discovered after the incident that airbag deployment is assisted by gunpowder. I am not sure if this is what caused my hoodie to catch fire. I also discovered that 2021-2022 Rams recently had a recall on Side Airbags due to improperly compressed air. My truck is a 2019 however, so I'm not sure if that recall should be expanded to include additional years.

POWER TRAIN,ENGINE — Filed 08/01/2020

In August 2020, while I was driving my vehicle at approximately 15 mph, with approximately 13,500 miles on the odometer, I noticed that the vehicle's transmission gauge was about 230-240 degrees. I pulled over and smelled smoke. Luckily, my passengers and I were able to get out of the vehicle. The vehicle was completely destroyed. I have video showing flames coming out of the passenger side engine compartment. I had previously taken my vehicle in for repair for recall W03 to have the transmission valve body replaced so the transmission wouldn't cause an engine fire. FCA had an expert inspect the vehicle and he found that "fire progression appears to be from engine compartment thru entire vehicle terminating at rear truck bed," that "possible source of ignition is hot surface of turbocharger/exhaust components. - Most likely method of ignition is transmission fluid expelled from dipstick tube," "origin appears to be in the engine compartment," and "possible cause appears to be transmission fluid expelled from dipstick tube onto turbocharger/exhaust components. The determination of possible cause is based on: 1. Owner/driver's description of events. 2. Transmission of dipstick is extended ~ 27.0 inch from the fill tube." Despite this, FCA refused to pay me for my destroyed vehicle (or the trailer that it destroyed) because: "After the inspection of your vehicle, the information at hand would not permit us to associate the fire with a manufacturing or assembly error. We are sure you will understand fires of this nature can and do occur for a number of reasons not associated with the manufacturing process. Therefore, we must respectfully decline any assistance associated with this matter. Based on this, we suggest that you refer this matter to your insurance carrier . . ." I already had the transmission fire recall performed and my truck still blew up. Luckily, I was not injured. I am worried that if FCA does not do another recall, other trucks will blow up too.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 03/11/2021

I STARTED MY PICKUP AND PULLED OUT OF GARAGE PUT IN PARK TO CLOSE MY GARAGE DOOR AND WITH 2-3 MINUTES AT IDLE, SMOKE WAS COMING INTO THE CAB, GOT OUT OF VEHICLE AND OPENED HOOD AND FOUND FLAMES COMING FROM FUEL INJECTION PUMP AREA, WAS ABLE TO GET FIRE OUT BEFORE IT BURNT THE TRUCK COMPLETELY.

POWER TRAIN — Filed 10/20/2020

THE TRUCK WAS PUT INTO PARK I OPENED THE DOOR AND ABOUT 5 SECONDS LATER IT STARTS ROLLING DOWN A SLIGHT INCLINE, THE DOOR HIT ME ,THE TRUCKS TIRES WERE SKIDING FOR ABOUT 25 FEET AND CAME TO A STOP. I CHECKED THE TRUCK AND IT WAS IN PARK, THE WAY I LEFT IT.

ELECTRICAL SYSTEM — Filed 09/07/2020

STARTED MY TRUCK TODAY AND WITHIN A MINUTE OF DRIVING IT OUT MY DRIVEWAY I SMELLED SOMETHING BURNING AND SAW SMOKE. THE ELECTRICAL WIRING HARNESS UNDER THE FRONT DRIVERS SEAT WAS ON FIRE. HAD TO PUT THE FIRE OUT WITH A BOTTLE OF WATER. CALLING MY LOCAL RAM DEALERSHIP IN THE MORNING TO HAVE IT TOWED THERE.*DT*JB

STRUCTURE,UNKNOWN OR OTHER — Filed 06/24/2020

WELL DRIVING DOWN THE INNER STATE AT 65 MILES AN HOUR A FRAME SNAPPED AND THE DRIVE TRAIN AND AXEL FELL OUT TRUCK VEERED TO THE LEFT IN CONSEQUENTLY I HIT THE GUARD RAIL THIS HAPPENED AND A DRY FLAT STRAIGHT INTERSTATE I -20I MILE MARKER NUMBER 4 IN NORTH AUGUSTA SOUTH CAROLINA THE MECHANIC THAT TOWED THE TRUCK SAID THIS HAPPENED DUE TO A MANUFACTURER'S DEFECT THE TRUCK ONLY HAD 6000 MILES ON IT.*DT*JB*DT*DT*JB*DT*JB*DT THE CONSUMER STATED THAT THE VEHICLE IS UNDER INSPECTION BY THE MANUFACTURER. *AS*DT*DT*DT*DT *TR*AS*DT*DT*DT *TR*DT THE CONSUMER PROVIDED PHOTOS. *TR*DT *TR*DT

STRUCTURE — Filed 06/21/2020

TRUCK HAS 5000 MILES ON IT. TWICE NOW THE TAILGATE HAS COME OPEN WHILE TRAVELING. YESTERDAY 6/22/20, I GOT HOME FROM TRAVEL TOWING CAMPER, AND UNLOADED BACK OF TRUCK. CLOSED TAILGATE AND DOUBLE CHECKED IT TO MAKE SURE IT WAS CLOSED, DO THIS NOW AFTER FIRST TIME. TOWED CAMPER TO STORAGE AND WHILE MAKING TURN IN STORAGE AREA TAILGATE HAD OPENED ON TRIP AND HIT CAMPER CAUSING DAMAGE TO TAILGATE AND CAMPER. *TR

POWER TRAIN,ENGINE — Filed 05/01/2020

TL* THE CONTACT OWNED A 2019 DODGE RAM 2500. THE CONTACT STATED THAT WHILE DRIVING SMOKE SUDDENLY CAME FROM UNDER THE HOOD AND THE VEHICLE IMMEDIATELY STOPPED ACCELERATING. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER AND WATER. THE CONTACT STATED THAT HER AND HER SPOUSE WAS BURNT ON THEIR HANDS AND LATER SEEKED MEDICAL ATTENTION FOR SMOKE INHALATION. THE FIRE DEPARTMENT ALONG WITH THE POLICE DEPARTMENT CONTACTED HOWEVER, THE FIRE WAS ALREADY EXTINGUISHED BY TIME THEY REACHED THE SCENE. THE CONTACT DOES NOT KNOW IF A POLICE OR FIRE REPORT WAS FILED. THE CONTACT STATED THAT THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND SHE RECEIVED AN EMAIL STATING THAT THE MANUFACTURER WOULD BUYBACK THE VEHICLE. HOWEVER, THE MANUFACTURER HAS BEEN UNRESPONSIVE TO THE CONTACT'S ATTEMPTS TO PROCESS THE BUYBACK PROGRAM. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V043000 (POWER TRAIN). THE CONTACT STATED THAT THE INSURANCE COMPANY WILL NOT PAY THE CLAIM AS A RESULT OF THE RECALL AND THE BUYBACK OFFER. THE DEALER MOUNTAIN HOME AUTO RANCH (2800 AMERICAN LEGION BLVD, MOUNTAIN HOME, ID 83647 888-229-6919) WAS MADE AWARE OF THE FAILURE HOWEVER, THE FAILURE WAS NOT DIAGNOSED. THE DEALER ASSISTED THE CONTACT IN GETTING A CLAIM NUMBER FROM THE MANUFACTURER. THE FAILURE MILEAGE WAS 21,000.

POWER TRAIN,SERVICE BRAKES — Filed 08/29/2019

TL* THE CONTACT OWNS A 2019 RAM 2500 VEHICLE ROLLED AWAY CRASHED INTO A 2ND VEHICLE FAULTY TRANSMISSION AND BRAKE SYSTEM THE CONTACT STATED THAT AFTER STOPPING ON A VERY SLIGHT INCLINE AND SWITCHING THE TRANSMISSION TO THE PARK POSITION WITH THE ENGINE STILL RUNNING THE OCCUPANTS EXITED THE VEHICLE AND THE VEHICLE SUDDENLY ROLLED FORWARD CRASHING INTO A SECOND VEHICLE. DURING THE INCIDENT THE OWNER RE-ENTER THE VEHICLE AND PRESSED THE BRAKE PEDAL BUT THE VEHICLE DID NOT STOP. NO INJURIES WERE REPORTED. NO POLICE REPORT WAS TAKEN. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT YET NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,900.