2020 Subaru Ascent Complaints

WHEELS — Filed 09/10/2026

After replacing tires I started hearing noises from rear wheel. I searched online and it appears there is an issue with wheel bearings on several Subaru models (see YOUTUBE video by FIXBOOK dated July 12, 2026). The issue was confirmed by my Subaru dealer on 9/10/2026. Subary wheel bearings prior to 2026 were subject to poor design resulting in premature corrosion, complete failure and possible separation from the under carriage. New Subaru wheel bearing was redesigned in 2026 (part 28473XC00E), but Subaru never recalled the defective wheel bearings in Tribeca, WRX, Forester, Ascent, Outback models sold prior to 2026?

EXTERIOR LIGHTING — Filed 07/28/2026

Subaru has a known problem/design with their LED daytime running lamps on the Ascent model. Dealerships are seeing a high failure rate of these LED lights, and it is always with the left side headlamp assembly. The LED strip quits working. In my case my car has about 42,000 miles on it with estimated 1,500 hours of operation. LED lights are designed to last a minimum of 30,000 and up to 100,000 hours. I see these models all the time with their left daytime lamps out. These lamps are provided for safety reasons and to bring visibility to other drivers. Even Subaru dealer's state that this is a known problem and always the left headlight assembly. FYI, the whole assembly needs to be replaced, and the price range is around 1,300.00. I have reached out to Subaru, and they simply state vehicle is out of warranty, and they will not do anything about it. I say this is a known imbedded issue due to engineering, quality control etc. and each delivered vehicle is more than likely going to experience this issue which again I perceive as a safety issue. Again, LED lights are used because of their long-life expectancy. But in Subaru's case, their lights are designed to fail much sooner than one should reasonably expect. Subaru needs to do the right thing and stand behind these faulty lights and return the vehicle to the level of safety it was intended to offer. However, the only way they are possibly going to consider this if the NHTSB gets involved. I have provided a phot of my car showing the lights. One is lit and one is not.

POWER TRAIN — Filed 08/16/2026

The contact owns a 2020 Subaru Ascent. The contact stated that while driving at an undisclosed speed, the vehicle was skipping. The failure was recurrent. The contact associated the failure with NHTSA Campaign Number: 21V955000 (Power Train); however, the dealer informed the contact that the recall repair was completed on July 15, 2025. The contact was the vehicle owner on that date and stated that the vehicle was never taken to the dealer for the recall repair. The dealer diagnosed the vehicle with CVT failure and advised that the vehicle was outside warranty coverage. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 145,000.

POWER TRAIN — Filed 07/30/2026

1. The vehicle is experiencing a transmission malfunction/failure. The dealership was able to replicate the issue and confirm the malfunction, which caused the check engine light to illuminate. The vehicle is currently being evaluated by the dealership, and any failed components should be available for inspection upon request while the vehicle remains in their possession. 2.The transmission malfunction is affecting the vehicle's ability to accelerate, maintain speed, and operate predictably. This creates a potential safety risk when the vehicle loses power or experiences unexpected changes in operation while driving, particularly in traffic or at highway speeds. The concern is heightened because transmission failure can leave the vehicle unable to safely continue operating and can cause collisions with other vehicles on the road. 3.Yes. The dealership was able to reproduce the issue, which caused the check engine light to illuminate and confirmed that there is an active problem requiring further diagnosis/repair. 4.The vehicle has been inspected and evaluated by the Subaru dealership/service center. To my knowledge, it has not been inspected by police or insurance representatives. Subaru of America has reviewed my case and the repair history but has declined assistance with the repair or to open a case. 5.Yes. The dealership was able to reproduce the issue, which caused the check engine light to illuminate. The transmission problem was also associated with operation that prompted me to have the vehicle inspected. The check engine light illuminated when the dealership replicated the condition. This current transmission is a replacement transmission done by Subaru do to a previous recall of the same issue. The current transmission only has 83,000 miles on it.

POWER TRAIN — Filed 06/16/2026

The Transmission is slipping on my 2020 Ascent. I had the recall wrk-21 performed in July of 2025. Over the last 6 months the car has been hesitant to go at low speeds and shakes at high speeds. Over the last month the transmission started to slip while accelerating , especially up hill. There would be a grinding noise and RPMs would jump. I took it to the dealer and they confirmed it was the transmission via camera test. I called Subaru of America for goodwill help with the cost knowing that there is a know issue with the transmission. They refused due to the mileage, 121,010. •What component or system failed or malfunctioned, and is it available for inspection upon request? The transmission is slipping •How was your safety or the safety of others put at risk? The car is hesitant to go from a starting position. The car will jerk back and forth when trying accelerate when merging or crossing a road. I am also very concerned of catastrophic failure at high speeds. •Has the problem been reproduced or confirmed by a dealer or independent service center? The dealer has confirmed the transmission is bad via camera teat. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Just the dealership •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No dash lights just the feeling and sounds.

SUSPENSION — Filed 06/01/2026

My strut bearings have been replaced several times in the drivers sides, my shock and strut has been replaced twice on the drivers side and now the passenger side is doing the same thing. The dealership tells me that there is nothing wrong but research shows this car has known suspension issues. My passenger side front has a loud metallic grinding sound when turning the wheel in park. I’m told this is the brakes which makes no sense. The car feels like it is on ice or sailing down the road, and the car does not maintain an alignment causing the insides of tires to wear out after 15,000-20,000 miles and need to be replaced.

SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 05/05/2026

I am reporting a repeat safety concern involving a 2020 Subaru Ascent. The vehicle was involved in two separate collisions after failing to decelerate as expected following normal brake pedal application. The first incident occurred on January 26, 2026. While approaching a traffic signal, I applied the brakes under normal driving conditions. The vehicle did not slow as expected and struck the rear of another vehicle. Property damage occurred, but no injuries were reported. The second incident occurred on May 5, 2026. While approaching a stop sign at approximately 35 mph, I again applied the brakes under normal driving conditions. The vehicle did not decelerate as expected and entered the intersection, colliding with a vehicle traveling perpendicular to my direction of travel. Both vehicles were towed. No injuries were reported. During both incidents, there were no forward collision warnings, automatic emergency braking interventions, or other alerts observed prior to impact. Following the second collision, the vehicle was inspected by an independent technician. Brake components inspected were found to be within serviceable condition and no evidence of neglect or improper maintenance was noted. During inspection, abnormal brake pedal behavior was observed, including continued downward pedal travel while steady pressure was applied. The technician documented that the reported condition was not consistent with normal braking performance and stated that an intermittent hydraulic and/or brake assist related issue could not be ruled out. The vehicle has been regularly maintained according to manufacturer recommendations. Due to the repeat nature of the condition, the lack of warning or intervention from safety systems, and the occurrence of two collisions despite normal brake application, I believe this condition represents a significant safety risk. The vehicle has since been declared a total loss and may be available for further inspection.

UNKNOWN OR OTHER — Filed 05/11/2026

I am submitting this complaint regarding a known exhaust manifold/flex pipe failure affecting my 2020 Subaru Ascent Touring (VIN: [XXX] ). My vehicle was diagnosed by a Subaru dealership with a “broken flex pipe on the header” causing excessive exhaust noise and exhaust leak concerns. Repair estimate was slightly over $2,000. After researching the issue, I discovered numerous reports from other Subaru Ascent owners describing identical failures involving cracked exhaust manifold welds and failed flex pipe sections. Subaru has also issued TSB 09-106-23 involving exhaust manifold weld cracking and redesigned replacement components for this issue. Symptoms began in the low 70,000-mile range and progressively worsened before formal diagnosis at approximately 83,000 miles. This appears to be a widespread defect involving emissions/exhaust components. Many owners online report loud cold-start exhaust noise, cracked manifold welds, failed flex pipe sections, exhaust fumes/smells, and expensive manifold replacement repairs. My concern is both the widespread nature of the defect and Subaru’s handling of complaints regarding the issue. Initially, Subaru denied assistance because the vehicle has a branded title. After documentation was provided showing federally mandated emissions-related coverage/extensions were active for this VIN regardless of title status, the denial basis changed to mileage. After explaining symptoms began prior to the mileage threshold, Subaru then cited lack of dealership service history after my ownership despite the vehicle being regularly maintained by a local mechanic. I am requesting NHTSA review whether this exhaust manifold/flex pipe defect represents a broader reliability and emissions-related defect trend affecting Subaru Ascent vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN,ELECTRICAL SYSTEM,ENGINE — Filed 05/11/2026

The pressure sensor coming out of the transmission has failed, and it's pushed transmission fluid throughout the engine harness, transmission harness, the bull harness in the dash and the 02 sensors. All of those have been damaged. The car is now unsafe to drive due to the pressure sensor failing. This information comes directly from the Subaru dealership. There was nothing prior to this that indicated there was a problem. I bought the car from a certified dealership 8 months ago and it was a certified pre owned vehicle.

STEERING,POWER TRAIN — Filed 02/20/2026

The contact owns a 2020 Subaru Ascent. The contact stated that while driving on several occasions at various speeds, the steering wheel became loose and then tightened inadvertently. The vehicle was taken to a dealer where the failure could not be replicated. The contact also stated that on several occasions while driving, the vehicle puttered and a grinding noise was heard emanating from the engine compartment. The vehicle was towed to a dealer where it was diagnosed during the first visit to be the transmission module. The vehicle was repaired, but the failure persisted sporadically. The vehicle was taken back to the same dealer on the second visit where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired, but the failures reoccurred approximately 5,000 miles later. The vehicle was taken to the same dealer on the third visit where it was diagnosed that the tie rod end and bushing needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was then taken to the same dealer on the fourth visit where the failure could not be replicated. The vehicle towed to the same dealer on a fifth occasion where it was diagnosed that the transmission needed to be replaced. The vehicle was not repaired as of yet. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 82,000.

SERVICE BRAKES — Filed 02/20/2026

In December 2025, I had brake replacement, tire service, and wheel alignment performed at Monro Auto Service located at [XXX] child were traveling on the highway during a winter storm when the brakes began making a loud banging noise. My wife was unable to immediately locate a service location and was forced to continue driving for an extended period in winter storm conditions while in fear for her safety and that of our child. When she was finally able to reach a second Monro location between [XXX] and [XXX] , a technician discovered that one brake caliper bolt was missing entirely and a second was dangerously loose. The vehicle had been driven at highway speeds in a winter storm with an improperly and incompletely assembled brake system for an extended distance before help was found. The second Monro location secured the caliper bolt and confirmed the vehicle safe to continue. The original Fairport location was contacted and their manager acknowledged the issue but has failed to provide any meaningful resolution after nearly four months. In a formal BBB complaint response, Monro Inc. confirmed that the caliper bolt had not been properly secured and acknowledged filing an insurance claim for resulting rim damage — an implicit admission of negligence. I am filing this complaint because an improperly assembled brake system — specifically a missing caliper bolt — represents a serious and potentially fatal safety hazard. If this is a pattern of negligence at Monro locations, other consumers may be at risk. BBB Complaint Case #XXX is on file documenting Monro's formal response and admission. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN,FUEL/PROPULSION SYSTEM — Filed 04/20/2026

My 2020 Subaru Ascent struggles to retain power when accelerating, especially from stopping and especially when the fuel is low. The vehicle stalls or loses some power when trying to accelerate. The check engine light is not on and there is no other indication that there is a problem with the vehicle. I have discussed it thoroughly with my mechanic and we both think it sounds like a fuel pump issue. He looked at the other Subaru recalls and thinks my vehicle should be included in the other Subaru fuel pump recall (NHTSA ID Number: 21V587000). Does my vehicle qualify for this fuel pump recall? Thank you.

STRUCTURE,UNKNOWN OR OTHER,VISIBILITY/WIPER — Filed 02/26/2026

Water intrusion occurred inside the vehicle, resulting in extensive mold contamination throughout the interior, including the seats, front and rear carpets, and a child’s car seat. The source of the water intrusion has not been identified. The vehicle was taken to an authorized Subaru retailer, which confirmed in writing that water was present inside the vehicle and that mold was covering interior surfaces, including the child’s car seat. The only diagnostic test performed was a car wash to check for a sunroof leak, which did not replicate the issue. The retailer indicated that further diagnostic work would require significant interior disassembly and cleaning at the owner’s expense before the source of the leak can be determined. The manufacturer was contacted regarding this issue and declined assistance, citing “lack of required maintenance.” The specific maintenance and its relationship to the water intrusion have not been identified, and the source of the leak has not yet been diagnosed. The retailer also stated that technicians would not enter the vehicle due to the extent of the mold contamination. As a result, standard recall repairs have not been performed while the vehicle remains in this condition. A dealership technician also documented in a recorded inspection that water was present beneath the carpet, that the source of the leak could not be identified without further disassembly, and that the extent of mold contamination created an unsafe working environment. This condition creates a potential health and safety concern due to mold exposure inside the passenger cabin, particularly for a child occupant. In addition, excessive interior moisture has caused window fogging, which may impair visibility while driving. No warning lights or prior indicators were observed before the issue was discovered. The problem has been confirmed by a Subaru retailer. The vehicle remains available for inspection.

ENGINE,LANE DEPARTURE,BACK OVER PREVENTION — Filed 02/26/2026

I was driving and I got check engine light and all safety features disabled while I was in the freeway, luckily I was able to drive to nearby Subaru dealer for inspection and I found out that there was a recall on the engine for this vehicle and when I contacted the manufacturer they asked me to take it for diagnostics and I did that at a Subaru retailer, but the case manager told me that this recall is being completed for the previous owner of the vehicle and cannot help me with anything, which was never disclosed when I was buying the vehicle.

POWER TRAIN — Filed 02/16/2026

Vehicle: 2020 Subaru Ascent (Build Date: March 2020) Component: Power Train – Automatic Transmission – Hydraulic Pressure Sensor / Wiring Harness The vehicle developed a flashing "Transmission Service" warning and check engine light. It was inspected by a certified technician at Lithia Reno Subaru. Diagnostic scan identified multiple transmission-related codes including P0137, P0700, P2096, P1867, P0867, P2723, and P0841. The technician documented the root cause as: "Found pressure sensor leaking oil through all harnesses." According to the dealership diagnosis, the transmission hydraulic pressure sensor failed and allowed transmission fluid to migrate into the vehicle's electrical wiring harness system. Fluid traveled through the transmission harness and continued into the bulkhead and engine harnesses, contaminating multiple electrical systems. Due to the extent of contamination, the dealership determined that all three harnesses must be replaced. The repair estimate is approximately $8,933. Transmission fluid entering the wiring harness can disrupt communication between the transmission control system and other powertrain components. This electrical contamination can cause erratic transmission operation or sudden loss of propulsion while the vehicle is in motion, increasing crash risk. Subaru has issued recalls and service bulletins involving CVT transmission and hydraulic pressure sensor failures in earlier Ascent vehicles using the same drivetrain. My March 2020 vehicle appears to have experienced the same failure pattern. Despite the documented component failure and extensive wiring contamination, the manufacturer declined to fully cover the repair. I request that NHTSA review this failure mode to determine whether hydraulic pressure sensor seal failures allowing transmission fluid to migrate into wiring harness systems represent a broader defect affecting Subaru Ascent vehicles.

POWER TRAIN,ENGINE — Filed 11/30/2021

Oil Leak(s) (found cam carriers leaking, front timing cover leaking, oil cooler leaking, upper and lower oil pan leaking. recommend engine reseal). Massive oil leaks found in car due to RTV sealant. Subaru uses RTV silicone sealant (formed-in-place gaskets) instead of traditional rubber gaskets for many sealing surfaces (cam carriers to heads, timing cover, oil pans, etc.). Transmission failure at 37,000miles which needed replacement. In dealership service for 52 days at that time. Transmission symptoms continued after replacement. Car hesitates while accelerating making it dangerous to accelerate to speed needed to merge into traffic. Same transmission symptoms occurring now that were present prior to complete transmission failure in 11/2021 that left me in middle of busy freeway with a disabled car. Subaru not taking transmission symptoms seriously. Continuous brush off from service and Subaru. Car is a lemon. Subaru not standing by product. Oil should not be leaking from every orfice of engine.

ENGINE — Filed 02/01/2026

Car has 82,000 miles, has been maintained and requires an engine replacement due to 'Sludge'. Reading a lot of forums that indicate this is a common situation with this make and model and likely due to manufacturer's defects.

POWER TRAIN,VEHICLE SPEED CONTROL,LANE DEPARTURE — Filed 12/31/1969

I have had my lane assist come on by its self a few times, which is very dangerous because it seems to take over and will pull on the steering wheel. I’ve also brought my car back to the dealership a handful of times to have it hooked up to a computer and also someone ride with me because the car will either hesitate to accelerate or stutters and doesn’t seem to want to go when I am between 20-30 miles an hour. Other times when I’m at a light or stop sign it hesitates also. I was told there was nothing wrong with it and they reprogrammed to transmission but it didn’t help at all.

UNKNOWN OR OTHER — Filed 06/18/2025

Although the NHTSA form does not include a transmission category, this complaint concerns a critical transmission-related defect in my 2020 Subaru Ascent, which caused oil migration into the wiring harness and contamination of the Engine Control Module (ECM). This complaint concerns a critical transmission-related defect in my 2020 Subaru Ascent. The vehicle has been inoperable since June 2025 due to a failure of the transmission secondary pressure sensor. This failure caused oil to migrate into the wiring harness and ultimately contaminated the Engine Control Module (ECM), rendering the vehicle undrivable. Authorized Subaru dealership Huberger Subaru in Colorado Springs documented the following: - Replacement of the transmission secondary pressure sensor - Replacement of the engine wiring harness - Check engine light returned after repair - Confirmed oil contamination of the ECM Despite repeated repairs and part replacements, the vehicle remains out of service for over seven months, with no confirmed timeline for resolution. Subaru of America has not provided meaningful updates or a clear repair plan, and corporate representatives have failed to respond to emails and phone calls. The extended downtime and lack of repair constitute a safety concern, as the vehicle could fail while in use under certain conditions. Additionally, $400 was improperly withdrawn from my account in July 2025 for rental reimbursement during the warranty repair period and has not been refunded. I am seeking prompt resolution, including repair or replacement of the vehicle, reimbursement for the rental charge, and any appropriate actions from Subaru to address this safety-related defect.

ENGINE,FUEL/PROPULSION SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 02/23/2024

On Friday evening, February 23, 2024 , I pulled onto my driveway and came to a complete stop before driving into the garage . I reached up and hit the garage door remote. When the door began to go up I took my foot off the brake. Instead of creeping up the driveway the car took off like a proverbial "bat out of hell" It was as if I had pushed the accelerator compltely down.to the floor board. The brakes had no effect. I smashed through the garage door,. The car jumped a six inch concrete step up, obliterated the garage cabinets and pushed the contents of the cabinets and garage wall into our family room.The car came to a rest just outside our family room. My son opened the door to the garage and yelled out to me "Are you okay" Because the engine was still racing he said "Get your foot off the accelerator' My reply was I DON'T HAVE MY FOOT N THE ACCELERATOR". I then tuned the ignition off and the ordeal was over.. It appears that the engine continued to recieve fuel irregardless of the position of the accelerator., the automatic braking system failed miserably and the the forward collision warning was malfunctioning. I am waiting for the insurance company to remove the car from the garage and do a structural assessment.. Because there may be serious structual damage I want the insurance company to remove the vehicle less the second floor collapses onto the garage. My son was on the couch just seconds before the wall "exploded". The couch was moved eight feet across the room. If a piece of debris came through the windsield I also might have been injured. The potential for serious injury to others in another set of ircumstances also scares me. The malfunction came without warning. The damages will be in the tens of thousands of dollars. I am blessed that no one was injured or killed.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 10/16/2023

Reporting a serious incident with my 2020 Subaru Ascent at 21k miles. On October 16th, a burning plastic smell and white smoke from the floorboard forced an immediate stop; I had to call the fire department for safety. The vehicle's battery has been replaced thrice, and the radio system frequently resets. Despite a Subaru recall fix in February meant to prevent such issues, the problem persists, raising major safety concerns. With 20+ years in electrical engineering, I've noted consistent electrical issues with this car. I urgently request NHTSA intervention for an immediate and thorough investigation, holding Subaru accountable for ensuring vehicle safety.

AIR BAGS — Filed 08/19/2022

The contact's wife owns a 2020 Subaru Ascent. The contact stated that while his wife was driving at an undisclosed speed, the vehicle was stopped in traffic when a semi-trailer collided with another vehicle, causing that vehicle to crash into the front end of her vehicle. It resulted in a four-vehicle collision. On impact, the contact's wife hit her head on the steering wheel. The air bags were not deployed upon impact. The contact's wife received medical attention for her head injury. A police report was filed. The vehicle was towed to the contact's residence and was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,000.

AIR BAGS — Filed 03/05/2022

The contact owned a 2020 Subaru Ascent. The contact was driving approximately 35 MPH on a highway when the contact's husband lost consciousness causing him to crash into a truck. As a result, the event leads to a 4 vehicle collision. The driver was transported via ambulance to the hospital where it was confirmed that there were no injuries. The other occupants in the other vehicles did not sustain any injuries. A police report was filed. The air bags did not deploy. The vehicle was towed to an impound lot. The vehicle was destroyed. The manufacturer was not notified of the failure. The failure mileage was 30,000. Case # [XXX] Goodman. Good morning this is a picture of my car and as it can be seen the airbags on either side did not deploy. Police report # is [XXX] date of accident and report was 3/5/2022. Thank you for your attention in this matter [XXX} and [XXX] Goodman (XXX) XXX-XXXX.

AIR BAGS,SERVICE BRAKES,FORWARD COLLISION AVOIDANCE — Filed 11/20/2021

Sudden unwanted rapid acceleration toward a building from parking lot causing head on collision: - Manual brakes failed - Automatic brakes did not engage - Airbags did NOT deploy after hitting an immovable object head on at least twice - Driver seatbelt did not lock - Starlink was not activated / notified - No collision warning was sounded (moot) Both driver and front passenger were severely injured and taken by ambulance to ER.

AIR BAGS,FORWARD COLLISION AVOIDANCE — Filed 11/29/2020

I WAS IN AN ACCIDENT 11/29 AT 9:45PM WHERE I HIT A COW. I WAS DRIVING 55 ON A STRAIGHT HIGHWAY THAT I'M VERY FAMILIAR WITH. THE COW WAS STANDING IN THE ENTIRE LANE OF TRAVEL AND I WAS ABLE TO VEER INTO THE OTHER LANE SLIGHTLY AND TOOK THE IMPACT ON THE RIGHT SIDE WHERE I DID NOT HAVE ANY PASSENGERS. THE SUBARU WAS TOTALED AND I'M NOW HAVING SEVERE WHIPLASH SYMPTOMS. I AM REPORTING THIS AS THE AIRBAGS DID NOT DEPLOY AND EVERYONE WHO HAS SEEN THE VEHICLE SAYS THEY THINK THEY SHOULD HAVE. ADDITIONALLY, I DO NOT REMEMBER MY COLLISION ALERTS BEEPING NOR THE SUBARU BRAKING FOR ME WHICH HAVE WORKED IN THE PAST. I ONLY REMEMBER HITTING THE COW AND THEN BEING COMPLETELY STOPPED WHERE WE HAD THE IMPACT.