2020 Subaru Outback Complaints

WHEELS,ENGINE,FUEL/PROPULSION SYSTEM — Filed 07/14/2026

The warning lights on our 2020 Subaru Outback have lit intermittently for the past 2 years. When bringing the vehicle into the dealer for service and oil changes, this was reported. Recently the TPMS light began to light intermittently. Tire pressure was checked and adjusted but the problem persisted. When we brought the vehicle in for service, it turned out that all tire pressure sensors needed to be replaced BUT the service techs identified other problems that surfaced JUST AS THE CAR WAS NOT COVERED BY WARRANTY - the most serious being an oil leak caused by FAILURE OF CAM CARRIER SEALS. This caused a dangerous condition where oil was leaking onto the engine and into the spark plugs. I find it odd that this EXPENSIVE issue was not discovered sooner. Subaru and only Subaru has been servicing this vehicle since new and they should have caught it.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 05/24/2026

What component or system failed or malfunctioned, and is it available for inspection upon request? - Car fire, originating under the hood. Unknown if vehicle is available for inspection. Last reported by Insurance company to be at IAA; [XXX]; PH#: [XXX]. How was your safety or the safety of others put at risk? - Car fire began while in the car after moving through an intersection with a stop light. Four of us in the car, ages raging from [XXX] old. Fire quickly spread; however, we were able to exit the car without injury. Has the problem been reproduced or confirmed by a dealer or independent service center? - NO, car was totaled and Subaru, NA Consumer Advocacy agent assigned claims that the vehicle is no longer available for inspection. Both insurance company (Travelers Auto) and Subaru, N.A. consumer advocacy group made aware of our concern as to why the vehicle caught fire. One or both demonstrated nonchalance of this concern. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? - YES - Just prior to the start of the fire, the vehicle stalled and cut-off with CHECK ENGINE LIGHT. Also, we smelled an unusual exhaust at the time prior to, and at the time of the cut-off. This occurred at the intersection of where the car caught fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER — Filed 06/30/2026

Vehicle stalled out, stopped and promptly caught fire.

POWER TRAIN — Filed 05/08/2026

My transmission has started to fail. The check engine light came on the error code read p0867, transmission fluid pressure. Other lights came on as well because it tripped the rest of the sensors because of the CVT failure. This seems to be a common problem in Subarus

POWER TRAIN — Filed 04/10/2026

I was reversing out of a residential driveway onto a county highway when the I had a complete loss of movement. Shortly after the total loss of power, the CEL illuminated. If I had been on the highway, the driveway is near a blind curve, I would've been sitting in the road with no way to move putting me in a dangerous situation. The transmission failed at right at the end of the driveway so I was able to put it in neutral and move the vehicle by hand. There were no symptoms or warning lights prior to the failure. I had it towed to the nearest dealership where they diagnosed a complete transmission failure and recommend a complete transmission replacement.

ENGINE — Filed 03/24/2026

Vehicle: 2020 Subaru Outback Onyx/Limited/Touring XT (2.4L Turbo FA24) Component: Engine Lubrication / Oil Pan Sealant I am reporting a manufacturing defect involving the engine oil pan seal on the 2020 Subaru Outback 2.4L Turbo. Upon inspection of fluid accumulation at the transmission joint, a Subaru dealership diagnostic confirmed that the engine oil pan seal has failed. The dealership noted that engine oil is leaking and being forced rearward by airflow while the vehicle is in motion, saturating the transmission assembly. Technician Admission: The service department at the Subaru dealership explicitly stated that this is a "known manufacturing issue" with the FA24 engine series. Financial Concession: To acknowledge the nature of this premature failure, the dealership waived the $185 diagnostic fee, resulting in a $0 invoice (attached). Inadequate Coverage: Despite the dealership’s admission and a repair quote exceeding $1,100 (file is attached), Subaru has not yet issued a recall or extended warranty for this specific 2020+ turbo application, though similar issues with RTV sealant have plagued the brand’s newer engine platforms. The technician confirmed that the leak is significant enough that oil is traveling the length of the transmission. This presents a potential fire hazard if oil contacts high-temperature exhaust components (such as the turbocharger or catalytic converter) and contributes to environmental contamination. This is the Turbo (XT) model. Turbochargers generate much higher heat, which makes an oil leak significantly Subaru National Customer Service has advised me to file this complaint with the NHTSA. I am requesting that the NHTSA investigate the frequency of oil pan seal failures on the 2020+ 2.4L Turbo (FA24) engine to determine if a mandatory recall or extended warranty (similar to past CVT or engine seal settlements) is warranted to protect consumers from the high cost of a documented manufacturing flaw.

BACK OVER PREVENTION,FORWARD COLLISION AVOIDANCE — Filed 03/18/2026

I was parking my car slowly until it suddenly accelerated. I hit a wall and car got totaled.

POWER TRAIN — Filed 02/03/2026

I'm writing to request assistance with my recall. This recall was first reported to the local dealership over one year ago. They have had me take the car back 4 times for inspection. Since that time as the problem has proceeded to get worse, which will now cost even more to repair, and increase the likelihood of the transmission damaging other parts of the drivetrain. Now I just received notification that they will not perform the recall as my vehicle doesn’t qualify. It has the problem of transmission slipping which is what the recall is for. I saw the pictures they took that looked exactly like the problem specified. I do not have $7000 dollars plus to fix the transmission. I can’t sell the car because the VIN will show the recall (which I’m sure they will try to just remove). All they have done is waste my time for the last year to do what? Gather enough evidence to try and get out of the recall?

FUEL/PROPULSION SYSTEM — Filed 02/13/2026

No warning lamps or messages. A driver in a pickup truck behind me came up close and signaled me to pull over. He got out of his truck, ran up to my window and yelled to me "get out of your car, it is on fire". I was completely unaware of any problem. I got out and could see fire coming from under the front of the car. We moved away and he called 911.

POWER TRAIN — Filed 12/28/2025

On December 28, 2025, my 2020 Subaru Outback lost the ability to engage any gear (Drive, Reverse, or otherwise) while maneuvering at low speed to make a U-turn. The vehicle became inoperable immediately and was towed to the dealer. The dealer confirmed via text and written estimate that there was no external damage, the failure was internal to the CVT transmission, and the transmission requires replacement. This vehicle has approximately 90,023 miles. The failure occurred under the mileage and age range covered by Subaru CVT warranty extensions for similar vehicles. Subaru of America reviewed the case and denied coverage, citing VIN exclusion and prior service gaps that predated my ownership. The vehicle is currently inoperable and presents a safety risk due to loss of propulsion. I am reporting this to NHTSA because it may indicate a systemic defect in CVT transmissions on this model year Outback.