2016 Subaru WRX Complaints

ELECTRICAL SYSTEM — Filed 08/11/2022

The Seconary Air Injection pump stayed on for days. Burnt a hole in the side, relay possibly damaged, and now setting off other components and computers.

UNKNOWN OR OTHER — Filed 03/01/2024

Driving and a loud explosion, sound, like a gunshot then a ton of pinging. The sunroof exploded and glass flew down my car and chipped a bunch of paint.

POWER TRAIN — Filed 04/27/2023

While driving, the clutch became stiff and unusable. Ultimately the car could not be shifted resulting in using a lower gear than normal to limp the car to safety. The car had to be towed to a mechanic. During the repair the mechanic identified that the cause of the failure was the clutch fork pivot ball punched through the stamped steel clutch fork. Looking online this seems to be a common failure since aftermarket re-designed parts are offered. I feel this is a manufacturer defect which resulted in the clutch failure and a 2500.00 repair. This car is only 7 years old with 67K miles on it. The clutch fork should not have failed catastrophically at this point in the car's life.

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM — Filed 12/14/2022

I PURCHASED A 2016 SUBARU WRX (PREMIUM) USED FROM A SUBARU DEALER IN ALBANY, NY WITH UNDER 26K MILES FOR APPROXIMATELY $25K IN 2018. ON A DRIVE IN DECEMBER 2022 I EXPERIENCED HESITATION AND/OR STUTTERING UNDER LOAD OR WHEN ATTEMPTING TO ACCELERATE, AND CAR BEGAN GETTING VERY HOT, AND CLOSE TO OVERHEATING, AND THE ENGINE WAS KNOCKING LOUDLY. AFTER TURNING ENGINE OFF AND THEN RESTARTING, THE KNOCKING (INTENSITY) WAS NOT AS NOTICEABLE AS THE INITIAL INCIDENT. INITIALLY I REPLACED ALL COIL OVER PLUGS, AS CYLINDER #4 INITIALLY WAS REPORTING A MISFIRE CODE AFTER THE CHECK ENGINE LIGHT CAME ON. THIS APPEARED TO RELIEVE THE MISFIRE BRIEFLY, BUT THE ISSUE IMMEDIATELY RETURNED, THIS TIME WITH PISTON #3 REPORTING MISFIRES AND ALSO EXHIBITING SIGNS OF A POSSIBLE FAILED RINGLAND, WITH OIL SEEPING PAST RINGS (ON TO / IN SPARK PLUG) CAUSING THE ENGINE TO RUN VERY POORLY. PRESENTLY UPON STARTUP WHITE SMOKE COMES FROM EXHAUST OUT THE TAILPIPE AND THE ENGINE IS HESITATING AND/OR MISSING, RUNNING POORLY AND I FEEL IT CANNOT BE DRIVEN SAFELY WITH THE DIMINISHED PERMORMANCE OR COMPLETE LACK OF ABILITY TO ACCELERATE NORMALLY LIKE A MOTOR VEHICLE SHOULD. I HAVE ENGAGED A MECHANIC TO INSPECT THE ENGINE, BUT HAVE NOT YET PROCEEDED WITH INSPECTION/REPAIRS DUE TO THE CLASS ACTION LITIGATION. CURRENT MILEAGE IS: 73563. THIS CAR HAS AN FA20 ENGINE.

ELECTRICAL SYSTEM — Filed 02/22/2023

I have faulty rear lights and a faulty rear view camera. According to MotorSafety.org there is currently a recall for this exact issue for WRX’s from 2015-2021. https://www.motorsafety.org/subaru-recalls-wrx-cars-over-faulty-rear-lights-rearview-camera-issue/

ELECTRICAL SYSTEM — Filed 12/30/2022

recurring battery drain, which has happened before. subaru dealer replaced the battery for the same reason less than 2 years ago. now it needs it again. car is inoperable as is.

ENGINE — Filed 10/01/2022

Started having issue with the engine making loud rattle noises and oil pressure was not consistent. Upon further investigating I removed the oil pan and removed the oil pickup. The oil pickup screen was full of RTV sealant causing the oil pickup to struggle with maintaining proper oil pressure and flow to the engine. I ended up having to change my timing belt tensioners because one went bad. Probably because of low oil pressure or RTV was sucked into oil galleys and caused it to malfunction. My car sounds a little better now but I believe I also have a light amount of rod knocking. If I kept driving the car, This could have led to catastrophic engine damage and caused my car to stall while traveling on public roads. I later researched if others have seen this issue and it appear to be a common issue in with Subaru and Toyota vehicles using the FA20DIT engine. These engine already have small enough rods, they don't need to be robbed of oil and cause engine damage because the manufacturer applied too much RTV sealant in assembly. There needs to be a recall on this.

STEERING — Filed 07/15/2022

My power steering one day lost all fluid out of no where. I have this awful sound and go buy new power steering fluid. It’s continuing to leak. I joined a Subaru Wrx/STi group on Facebook and found that this is a reoccurring problem for many Subaru sti owners around the year I have. It sounds faulty and defective and sucks that the customer is stuck paying for these issues instead of Subaru fixing their reoccurring issue with many customers. I baby my car to the highest extent and the power steering should not have just gone out after I parked in my drive way. There is a massive stain now due to the leakage, which is fine. But it’s inconvenient knowing I’ll have to fork up hundreds to over a thousand to get this properly fixed instead of a DIY where it has to do with such an important compartment of the car.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,SERVICE BRAKES — Filed 02/07/2022

ABS, cruise control, and other driving assistance features are disabled while driving at night. I checked for recalls on Subaru WRXs and noticed a recall was issued for the same problems on 2011-2015 models. My vehicle is a 2016 model and demonstrates all the same failures observed from the recall of the 2011-2015 models.

ELECTRICAL SYSTEM — Filed 01/20/2022

Several batteries that have died prematurely, last one only 2 months since last use. Vehicle has refused to start on several occasions, despite the battery being okay. Suspect issues with controller area network.