2025 Toyota 4Runner Complaints

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM,EXTERIOR LIGHTING — Filed 10/01/2025

The contact owns a 2025 Toyota 4Runner. The contact stated that the message “Headlights On” was erroneously displayed. The fuel gauge indicated 71 percent. Additionally, the 12-volt charging system malfunctioned with the message “See the Dealer” displayed. Several unknown orange warning lights were illuminated. The vehicle was restarted, and the warning lights turned off. The window on the passenger’s side was violently shaking. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure, but an undisclosed software was reprogrammed. The vehicle was taken back to the local dealer, where it was diagnosed and determined that the fuel pump was replaced. The vehicle was repaired. The dealer was contacted and informed about a diagnostic test. The manufacturer was contacted, and a claim was filed. The failure mileage was unknown.

UNKNOWN OR OTHER — Filed 07/13/2026

The driver’s side window rattles in its tracks when open 2-3”, and when all the way down. Any rough roads will induce the rattle. Toyota master technician has confirmed the rattle in my vehicle and a new 4Runner, which displays the same problem. It appears to be a defective design.

UNKNOWN OR OTHER — Filed 06/13/2026

Traveling on highway with no other cars anywhere around. Going 80 mph on an 80 degree day when sun roof on 2025 Toyota 4 runner exploded. Sun roof was closed at the time, but could have had devastating consequences if it had been open. Toyota rep did not take a look at the broken glass to check for imperfections or manufacturing issues, just told us we needed to make an insurance claim.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 05/22/2026

We were traveling north on hwy 23 in southern Minnesota pulling a 5000 lb trailer in the rain and it was windy. When the road split to 4 lane I stepped on the gas to speed up from 55 to 65 and the vehicle studderd and lost all power. Many warning lights cam on and I think it said stop within .3 miles. We pulled to the side of the road and basically coasted to a stop. It was on hybrid power. We called the nearest Toyota dealership and they suggested restarting the vehicle and see if we could make it to them. The engine did restart still with all the warnings on and we were able to drive it to the dealer being really gentle with the throttle. They pulled codes and it was intake related. They removed the air filter and it was dripping wet. The raised intake ingests water when it's raining and if it's working hard enough it pulls it through the filter into the intake and causes the vehicle to suddenly lose power which could possibly cause a accident. I am also concerned about water pulling dirt with it into the motor and causing damage. I have driven the vehicle in the rain since this happened but not pulling a trailer and really working it and so far it hasn't shut down on me yet but I've pulled the filter and it was wet. I have brought this issue to my dealer but they said they are not aware of a problem. I will attach a video of the wet filter I pulled from the air box after driving in a rain storm and a video of the warning lights that appeared. I don't think the dealership I took it too has any records of it because it was just after closing and they used a handheld scanner. They just dried our filter off and cleared the codes.

UNKNOWN OR OTHER — Filed 06/12/2026

Purchased used car from champion motorsports. I was handed a clean carfax report and was told the sunroof had no issues. 8 days later the seal around the sunroof came off and allowed water into the car. I scheduled a repair and brought it to passionauto body. On June 16th they notified me the car was unsafe to drive due to two support brackets being cutout and not replaced. After some research Toyota of calumet city had top coverage in some service notes. Car was also brought back to the shop on December 15th 2025 due to the sunroof not closing. Of course there were no notes on the service ticket.

AIR BAGS — Filed 06/08/2026

The contact owned a 2025 Toyota 4Runner. The contact stated that while driving at an undisclosed speed, the contact observed a large piece of debris in the roadway. The contact stated that traffic ahead was maneuvering erratically to avoid the debris, causing the contact to lose control of the vehicle. As a result, the vehicle left the roadway, struck several trees, and then collided with a brick wall. The contact stated that the air bags failed to deploy during the crash. A police report was filed. The contact sustained injuries to the leg, arm, and back and was transported to a local emergency room for medical treatment. The contact stated that surgery might be required due to the nerve injuries sustained in the crash. The vehicle was towed by the insurance company and was deemed a total loss. The contact believed that the failure may have been related to an improper repair for a battery replacement previously performed by the dealer. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 9,500.

VISIBILITY/WIPER — Filed 05/24/2026

While driving my 2025 Toyota 4Runner in rainy conditions, the vehicle’s stamped hood channels act as a reservoir, trapping and pooling large volumes of standing water. Upon braking or decelerating—even at low, around-town speeds—the pooled water surges forward off the front nose of the hood onto the windshield. The vehicle's forward aerodynamics catch this massive sheet of water and instantly launch it backward across the entire windshield, causing total and sudden loss of forward visibility. This creates an unpredictable, immediate crash hazard that catches the driver completely off guard, as the windshield wipers cannot clear the sudden volume of water fast enough to maintain a safe view of the road. This occurs around town driving (25mph to 45mph) and highway speeds (60mph - 70mph). I understand you can turn the wipers on high, but it catches you off guard when it happens.

POWER TRAIN,ENGINE — Filed 11/01/2025

The contact owns a 2025 Toyota 4Runner. The vehicle lost motive power while attempting to access the freeway on three occasions. The reduced power mode message was displayed. The vehicle was taken to the local dealer, and initially they were unable to determine the failure. The vehicle was taken to the local dealer again, where it was diagnosed that the sensor needed to be cleaned. The vehicle was repaired, but the failure persisted. The manufacturer was contacted, and a case was open. The failure mileage was approximately 11,000.

UNKNOWN OR OTHER — Filed 01/15/2026

I am reporting a suspected manufacturing defect involving the exterior paint on my 6th generation Toyota 4Runner. The paint appears to be abnormally thin and is showing premature wear, including chipping and surface irregularities, under normal driving conditions. This vehicle has not been subjected to any abnormal environmental exposure, misuse, or neglect. The condition developed much earlier than expected for a new vehicle and raises concerns about inadequate paint application or quality control during manufacturing. While this issue is cosmetic in nature, it may lead to long-term structural concerns such as corrosion if the underlying metal becomes exposed. Additionally, this concern appears to be reported by multiple owners of the same generation vehicle, suggesting a potential pattern rather than an isolated case. I am requesting that this issue be documented and reviewed for possible investigation if additional complaints are received.

UNKNOWN OR OTHER — Filed 04/11/2026

Driving 70 mph on a cloudy 73° day around 6:30 pm no cars immediately around me on I45. I heard a loud gunshot to the point I ducked in my car. Immediately pulled over walked around the car. My Sunroof exploded upwards. Took to Longo Toyota on Monday at 7am. Upon arrival they thought it would be covered under warranty. They brought in a specialist to evaluate and they can’t prove it but something must have hit it and they are denying warranty. The glass moved upward and was shattered but intact upon initial inspection. Upon online review this is a known problem w Toyota but one that needs to be addressed in a bigger scale as this could have caused an accident just from the sound alone or if the sunroof cover had been open glass raining down on passengers and driver.