2024 Toyota Bz4x Complaints

UNKNOWN OR OTHER — Filed 05/21/2026

While operating my 2024 Toyota bZ4X at very low speed on the road , I observed a stationary shipping container directly ahead and applied the brake pedal with maximum force approximately 4 seconds before contact. I held the brake pedal at full pressure continuously. I never touched the accelerator. The vehicle came to what appeared to be a complete stop then continued to advance and made physical contact with the container despite my maintained maximum brake input. The vehicle's own ECU-recorded Freeze Frame Data (retrieved by an authorized Toyota dealer using PCS Data Viewer) confirms the following at the time of the event: Driver brake pedal torque was at sensor saturation (4,048 Nm — the maximum value the sensor can record) for approximately 1.75 seconds prior to impact. Brake hydraulic line pressure peaked at 12.144 MPa and remained above 7.8 MPa throughout that period. Throttle position was 0.0% for the entire recorded interval. All four wheel-speed sensors recorded 0.00 km/h for approximately 2.95 seconds prior to impact. Steering input was effectively neutral; no skid or loss of directional control occurred. The longitudinal accelerometer recorded a peak deceleration spike of -8.97 m/s² at the moment of impact — a value that requires forward velocity and is physically inconsistent with the wheel-speed data showing the vehicle stopped. The Pre-Collision System (PCS) main switch was ON throughout, with no faults, no obstruction flags, and no warning, pre-brake, brake-assist, or auto-brake activation recorded. The Parking Support Brake (PKSB) did not activate. No diagnostic trouble codes were set. In plain terms: with maximum brake pressure applied and zero throttle input, my vehicle continued to move forward into a clearly visible stationary obstacle. The brakes did not maintain authority over the powertrain's creep torque, and no advanced safety system intervened. This indicates a potential defect in the vehicle's brake-override / creep-suppression

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,SERVICE BRAKES — Filed 05/21/2026

The vehicle experienced a sudden, catastrophic brake-by-wire system failure while operating in one-pedal driving (Regeneration Boost mode). While decelerating at a low speed behind an 18-wheeler semi-truck, the vehicle failed to continue slowing down. I immediately depressed the physical brake pedal, but the vehicle completely ignored the foot pressure. The pedal and braking system became completely unresponsive, and the vehicle kept rolling forward uncommanded. Despite keeping the brake pedal fully depressed, the vehicle did not decelerate, resulting in a front-end low-speed collision with the metal rear bumper of the semi-truck. Because the collision occurred at a very low speed, the operator of the commercial truck was unaware of the impact and safely continued driving forward without stopping. The vehicle's brakes entirely refused to re-engage until I frantically pumped the physical brake pedal and cycled/pressed vehicle control power switches. This action seemingly forced the electronic braking modules to reboot or re-establish hydraulic pressure, allowing the vehicle to finally come to a stop. The vehicle was subsequently removed from the active roadway. This is a severe, life-threatening safety defect involving a total loss of electronic brake-by-wire and friction braking application without any mechanical override intervention, presenting an extreme hazard. The vehicle has been towed directly to an authorized Toyota dealership for a comprehensive electronic diagnostic pre-scan of the Skid Control ECU, Electronic Parking Brake system, and 12-volt auxiliary power systems to retrieve the stored DTC fault logs and freeze-frame data.

VEHICLE SPEED CONTROL,FORWARD COLLISION AVOIDANCE,VISIBILITY — Filed 05/05/2026

The car show on the screen a message in regards to the Adaptative Cruise Control Malfunction and it’s showing an orange sign light.. Another problem it’s in regards the AC.. it’s not working

POWER TRAIN,ELECTRICAL SYSTEM — Filed 04/05/2026

The contact owns a 2024 Toyota BZ4X. When pressing the accelerator toelerator pedal to go onto the freeway, the vehicle failed to accelerate and suddenly shifted to neutral. The contact would have to press the brake pedal, the contact would immediately shift the vehicle back to Drive and continue forward. While continuing to drive, the vehicle accelerated. There were no warning lights. The failure had occurred 3 times. When attempting to start the vehicle one day, the vehicle failed to start. The tow company came and provided a jump-start, and then advised the contact to drive carefully, but if it failed to go in reverse. The next morning, the tow company's mechanic came again and confirmed battery failure, then recommended the vehicle be taken to the dealer. The vehicle was towed to the dealer, who stated that the battery had not failed, but had not provided a diagnosis for the failure. The vehicle had not been repaired. The dealer had driven the vehicle back to the contact's home. After the vehicle was returned, the failure occurred again. The manufacturer was informed, and a claim had been filed. The failure mileage was 9,787.

VISIBILITY — Filed 10/01/2025

What component or system failed or malfunctioned, and is it available for inspection upon request? The HVAC system, specifically the electric A/C compressor, has failed. The system produces a loud grinding/buzzing noise and has been diagnosed by authorized Toyota dealerships as requiring full compressor replacement. The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? This failure directly impacts the vehicle’s defrost system, which is critical for maintaining windshield visibility. Reduced or failed defrost capability creates a safety hazard by impairing visibility while driving, increasing the risk of an accident. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been confirmed by multiple authorized Toyota dealerships, including Sheehy Toyota and Mike Calvert Toyota. Both independently diagnosed a failed A/C compressor requiring replacement. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes. The issue has been escalated to Toyota Corporate, and a case manager has reviewed the dealership findings. Documentation has been submitted to Toyota for warranty and goodwill consideration. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. A grinding/buzzing noise began when the A/C system was activated and was formally reported to Sheehy Toyota on October 27, 2025, while the vehicle was under warranty. The issue was not repaired at that time. The condition progressively worsened and resulted in confirmed compressor failure on March 25, 2026.

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 11/12/2025

I LEASED A TOYOTA BZ4X THE PARKING BRAKE LIGHTS AND OTHER LIGHTS COME ON AND OFF WHILE I AM DRIVING AND FOB IS NOT TOUCHED. I TOOK CAR IN TO BE SERVICE FOR REGULAR MAINTENANCE AND WAS TOLD I HAD TO PAY $295 AND I AM UNDER WARRANTY. I WAS SOLD THE CAR BRAND NEW AND I DON'T THINK IT IS. I KEEP HEARING PEOPLE TALKING WHEN THE CAR IS POWERED OFF. I REPORTED THIS SEVERAL TIMES AND WAS IGNORED. MY CAR KEEPS TRYING TO CUT OFF WHILE I AM DRIVING AND THE CAR STARTS SHAKING, ALL THE LIGHTS COME ON THEN GO OFF. I WAS TOLD I COULD GET MY CAR SERVICE ANYWHERE FOR NO CHARGE UNDER WARRANTY. I WAS TURNED AWAY. ITS N BEEN A YEAR AND NO SERVICE CAR HAS NOT BEEN SERVICED AT ALL. I TOOK IT 2 TIMES FOR SERVICE AND THE CAR HAS NOT BEEN SERVICE. IT IS SUPPOSED TO BE NEW.

ELECTRICAL SYSTEM,SERVICE BRAKES — Filed 10/16/2025

The vehicle experienced repeated electrical and brake system malfunctions that pose serious safety concerns. On multiple occasions, the brake pedal became stiff and unresponsive while driving, and the parking brake system failed to engage properly. In addition, the ignition system often failed to start, even when the battery and all power indicators appeared normal. At times, the vehicle’s electrical system completely shut down without warning — causing loss of power functions, dashboard lights, and essential safety controls. These failures occur intermittently and unpredictably, making the vehicle unreliable and unsafe to operate. The issue has been reported to the dealer for inspection, but the problem continues to occur. It appears to be related to the vehicle’s electronic brake control and ignition system. This malfunction places the driver and others at potential risk, especially if the brake system or electrical components fail while the vehicle is in motion.

ELECTRICAL SYSTEM,WHEELS,LANE DEPARTURE — Filed 08/23/2025

I am writing to formally report ongoing issues with my Toyota bZ4X that raise serious safety concerns. The vehicle has been inspected twice by authorized Toyota service centers, and each time I have been told that no problems were found. However, the following issues continue to persist:     1.    Inaccurate Battery Readings: The electric system appears to malfunction regularly. The displayed battery percentage and estimated mileage are inconsistent and unreliable. For example, the battery may indicate a higher percentage while simultaneously showing a drastically reduced range, or vice versa.     2.    Lane Departure Warning Malfunction: The lane departure system activates erratically, sometimes without any lane deviation. At other times, it fails to engage when it should, which compromises the vehicle’s safety features.     3.    Tire Pressure Monitoring System (TPMS) Alerts: Warning lights frequently come on indicating that the tires are losing pressure, even after verifying that tire pressures are within recommended levels. These warnings occur unpredictably and without cause. Despite having the vehicle inspected twice, I have not received a resolution or acknowledgment of any defects. Toyota has stated that nothing is wrong with the vehicle, but the issues are ongoing and continue to impact the car’s drivability and safety. These problems are not only frustrating but also present a potential risk while driving. I am requesting that Toyota take this matter seriously, investigate the root cause of these electrical system malfunctions, and provide a resolution that ensures the vehicle operates safely and reliably.

ELECTRICAL SYSTEM — Filed 03/19/2025

The 12 volt battery does not maintain a charge. I have had it replaced twice. I purchased new January 2025; first battery replaced on March 20, 2025; second battery replaced August 13, 2025. I am currently having the same issue with the battery management system which controls temperature and battery usage. After sitting overnight, I drove my car approximately three miles parked and attempted to use the key fob to secure the vehicle, it failed. I had no problem or indication at the start of my trip. I had to secure the door with my physical key. I returned to the vehicle 15 minutes later and the key fob would not work at all. I accessed the vehicle with the physical key. The alarm was activated upon entry. I tried to use my key fob to get the vehicle to deactivate the alarm system but it would not work. Approximately five minutes later and after several attempts, the alarm stopped and the vehicle was showing ‘Ready’ but ‘No Key Detected’ was flashing on the information screen and vehicle would not change mode from park to reverse or drive. After several attempts of holding the key fob directly over the ‘START/STOP’ button, the car showed ‘ READY’ and I was able to change modes. The vehicle started flashing ‘NO KEY DETECTED’ continuously while I quickly drove back home. I parked in my driveway and made an appointment with Toyota for service. Later in the day, I attempted my key fob again, to no avail. I was able to get the key detected, display showed ‘Ready’ and mode changed. My car does not start (READY) until after several attempts. The dealership advised the battery failed a load test overnight and was replaced (August 15th) After the second replacement my car sat overnight. I drove a few miles to a charging station. I placed the car in ‘My Room Mode’ to have access to the climate control system and radio. The car started flashing ‘low voltage/battery’, I turned off the accessory mode, returned to the dealer, and awaiting resolution. Case filed with NCDS/CDSP.

SEATS,LANE DEPARTURE,VISIBILITY — Filed 08/20/2025

I am very concerned about potential accidents for my self and others driving this vehicle. I have multiple close call accidents because the left view mirror does't have proper view to see cars on left side especially if they are close. The way seat and the side of the vehicle is shaped its very hard to still see manually with head turned to the left rear side. The mirror or the shape or position needs to be changed for safety to prevent accidents.