2020 Toyota Sienna Complaints

AIR BAGS,UNKNOWN OR OTHER — Filed 06/18/2026

We had our van parked on a driveway with a front facing slope, we had hard rains went we where going away there was water coming out of the seat belt on the passenger side and the panel above the window was stained down to the window support where the air bag is. I've been reading reports as far back as 2008 we have a 2020, went taken to the dealer they want 1000 to 2700 to remove the head liner and try to fine the problem, which what was reported didn't help. The dealer recommended to not park with the front of the van facing down hill if rain is forecast, my problem is that Toyota has not been required to fix the leaks. I'm calling my local dealership tomorrow about are leak.

POWER TRAIN — Filed 05/07/2026

My Toyota sienna is a 2020, has 83,000 miles and has recently been squealing when I accelerate. I took the van to a local body shop and they said it seems to be my transmission. I called Toyota immediately and they knew that the transmissions were faulty and that they would try to work with Toyota to get it fixed. There is no way I can pay 9k for a new transmissions because they put in faulty ones.

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM — Filed 04/01/2026

The vehicle is a 2020 Toyota Sienna. While driving, the engine suddenly shut off without warning, creating a dangerous situation and loss of power. This occurred while transporting children, increasing the safety risk. A mechanic inspected the vehicle and diagnosed a failure of the low-pressure fuel pump. The problem appears intermittently — sometimes the vehicle runs normally, and other times it stalls or loses power. The check engine light has turned on and off. This issue matches the known defect related to the Denso fuel pump recall affecting many Toyota vehicles from similar model years. However, my VIN is not included in the recall. This is a serious safety concern because the engine can shut off unexpectedly while driving, which could lead to an accident. I believe this vehicle may have the same defective component as those included in the recall, even though it is not currently listed. The issue has been confirmed by an independent mechanic and the vehicle is available for inspection if needed.

UNKNOWN OR OTHER — Filed 04/11/2026

cable broke on sliding door and unable to open or access cabin on that side. turned off power to door and still unable to force door open making it difficult to unlatch car seat on that side. safety hazard in accident or rollover

STRUCTURE — Filed 10/10/2025

The power sliding door assembly failed, and the driver side rear sliding door was bound shut, and could not be opened. Disabling the power door system did not resolve the issue. The cable for the power door mechanism was hanging below the rear vent windows; but for some reason the door still would not open. I ultimately with a lot of gentle force was able to get the door open enough to see the retract side of the cable was bound up, and was able to cut it with wire cutters, and ultimately get the door to work normally as a non-powered manual sliding door. Since the original NHTSA BULLITIN on this was published in 6/2019 before my 2020 Sienna was manufactured, and Toyota did not change the mechanism until the 2021 model redesign, I believe that RECALL should be extend to all 2019 and 2020 vehicles. This seems dangerous that the door does not default to manual operation in error.

POWER TRAIN — Filed 05/12/2025

"I've owned the vehicle for five years, and recently I started hearing a whining noise coming from the transmission. After doing some research, I discovered that I'm not alone in experiencing this issue. The dealer told me that the transmission itself is the problem and recommended replacing the entire transmission. However, a second opinion suggested that this kind of noise isn't normal. I'm worried about safety because, although it's just a whine right now, I fear it could fail unexpectedly. I have a child in a wheelchair, and ensuring my vehicle's safety is very important to me."

POWER TRAIN — Filed 08/02/2025

A catastrophic failed automatic transmission; UA80E of Toyota Sienna 2020 at 85,000 miles. It occurred while I've been driving downhill. No warning lights, not overheating, no diagnostic ODB code, no other indications prior to the failure. Failure created a substantial safety risk for myself, my four passengers and other road users. Sudden loss of transmission function could lead to potential dangerous situation. Minivan was towed to the nearest Toyota dealer where transmission assembly was confirmed for replacement.

VISIBILITY — Filed 08/29/2024

In August of 2024, we noticed the drivers side rear view mirror had come loose from it's external housing and was only tethered by wiring that was for mirror movement, defrosting and blind spot awareness. In order for it to be safe to use, we had to duct tape it so that it would not move. Unfortunately, the mirror continues to loosen and has to be retaped frequently. We took it to our dealer (McGovern Toyota) in Portsmouth, NH 0n 23 September 2024 and were told that it could not be fixed but had to be replaced and were quoted an amount of $2025.29 .We were also told that the part was on national backorder and may take a few weeks to arrive. Due to the astonomical cost of replacement, I tried to find other solutions and contacted other dealers and body shops but was told it had to be replaced and could not be fixed. I brought the car into another dealer, nearby (Ira Toyota) in Saco, Maine and they also said it had to be replaced and quoted an amount of $1937.70.I asked them to order the part, which they too, said was in national backorder. I contacted our automobile insurance company (AMICA) who agreed to cover the part and labor and issued a check for $1,420.60. Every month, I would call the dealer and every month I was told that Toyota estimated a delivery within a month, but that month would come and go with no part. For the last several months, I have been in touch with TOYOTA and their "brand engagement advocate" named Julie has reviewed our concern and also has stated that the part will be available by the end of the months of February, March, April, May, June and now July. I have written emails to TOYOTA expressing my dissatisfaction and now have a vehicle which is unsafe to drive due to the instability of the mirror and a vehicle which will not pass inspection (according to the dealer). I feel TOYOTA is lying about the parts actual availability and being disingenuous to what was a loyal customer. I am at a loss what to do next.

ELECTRICAL SYSTEM — Filed 09/01/2024

The contact owns a 2020 Toyota Sienna. The contact stated that while his wife was driving at an undisclosed speed, the pre collision, lane assist, and air bag warning lights illuminated on the instrument panel. The vehicle was taken to a dealer and a fuse in the ECU (Electronic Control Unit) was replaced; however, the contact stated that approximately 10 days later, the failure recurred. The vehicle was taken back to the dealer where the vehicle remained for almost two weeks. The contact was informed that the wiring harness needed to be replaced; however, the wiring harness was on backorder. The manufacturer was notified of the failure, but no additional assistance was provided. The contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 60,000.

STRUCTURE — Filed 08/11/2024

Hinge rust on fuel door causing it to break and not let rear passenger door auto open (because switch won't make up) hinge is very weakly built