2022 Toyota Tacoma Complaints

STRUCTURE — Filed 01/01/2024

2022 Tacoma paint peeling on all doors. Manufactured 1 months after current paint recall 23TE08 for 2016-2022 Tacomas. Quoted $7,000 for new paint job by Maita Toyota in Sacramento Ca and Toyota Corp only offered me $2500, which I declined. This is stupid!

FUEL/PROPULSION SYSTEM — Filed 09/01/2026

Car has difficulty starting and at times won't start in hot weather. Was taken to the dealer and was diagnosed as a bad low pressure fuel pump. Had codes stored for low pressure fuel pump.

STRUCTURE — Filed 07/27/2026

My 2022-Toyota Tacoma has a paint peeling issue that is known to Toyota. My particular model was manufactured in Mexico with a paint code of 040. I have paint peeling in my engine compartment and on several fenders. Toyota has indicated on several websites that this has been an ongoing issue with models between 2016-2022. I took my vehicle to the ELK Grove, CA Toyota Dealership. The Service Manager said this has been an ongoing issue with my particular white (040) paint color. The Service Manager took several pictures. They instructed me to take my vehicle to their dealership collision center. I went to that facility, more pictures were taken and after setting me up for a repair paint job they instructed me that my VIN was not apart of their Customer Care program? I strongly feel that Toyota is now treating me unfairly and that my 2022-Tacoma should be repaired accordingly.

FUEL/PROPULSION SYSTEM — Filed 07/20/2026

Long crank start. Loss of power. Stalling. Priming fuel system 3x before cranking results in normal start. Suspect low pressure fuel pump failure 115k km/ 70k miles

TIRES — Filed 05/19/2026

Component/system: Rear tires — traction and wet-weather grip performance. Tires are available for inspection upon request. Tire size: 265/70R16 Four BFGoodrich Trail-Terrain T/A 265/70R16 112T all-season tires were purchased new and professionally installed at a retail warehouse tire center in August 2025. The vehicle is a 2022 Toyota Tacoma. Approximately nine months after installation, both rear tires began exhibiting severely degraded traction during heavy rain conditions on paved roads. On at least one occasion, the rear of the vehicle broke loose during a normal turn at low to moderate speed in heavy rain, resulting in a near-loss-of-vehicle-control incident. The front tires, from the same set and installation, did not exhibit the same level of traction loss during the same conditions, suggesting the failure is concentrated in the rear axle tires. Safety risk: The rear tire traction failure created a sudden and unexpected vehicle handling instability on a public road. The near-loss-of-vehicle-control incident posed a direct risk of collision to the driver and other road users. Dealer/service confirmation: The problem has not yet been confirmed by a dealer or service center — a tire center inspection appointment is scheduled. Results will be available following that appointment. Manufacturer/police/insurance inspection: The vehicle and tires have not yet been inspected by the manufacturer, police, or insurance representatives. Warning symptoms prior to failure: No warning lamps, messages, or audible warnings appeared prior to or during the traction loss event. The failure occurred without any prior indication of a problem. Tread wear appeared visually normal at the time of the incident. Assessment: The BFGoodrich Trail-Terrain T/A is marketed and sold as an all-season tire suitable for wet road conditions. The tire's performance in heavy rain is inconsistent with that representation and appears to constitute a safety defect. Multiple independent tire testing sou

TIRES — Filed 05/19/2026

Component/system: Rear tires — traction and wet-weather grip performance. Tires are available for inspection upon request. Tire size: 265/70R16 Four BFGoodrich Trail-Terrain T/A 265/70R16 112T all-season tires were purchased new and professionally installed at a retail warehouse tire center in August 2025. The vehicle is a 2022 Toyota Tacoma. Approximately nine months after installation, both rear tires began exhibiting severely degraded traction during heavy rain conditions on paved roads. On at least one occasion, the rear of the vehicle broke loose during a normal turn at low to moderate speed in heavy rain, resulting in a near-loss-of-vehicle-control incident. The front tires, from the same set and installation, did not exhibit the same level of traction loss during the same conditions, suggesting the failure is concentrated in the rear axle tires. Safety risk: The rear tire traction failure created a sudden and unexpected vehicle handling instability on a public road. The near-loss-of-vehicle-control incident posed a direct risk of collision to the driver and other road users. Dealer/service confirmation: The problem has not yet been confirmed by a dealer or service center — a tire center inspection appointment is scheduled. Results will be available following that appointment. Manufacturer/police/insurance inspection: The vehicle and tires have not yet been inspected by the manufacturer, police, or insurance representatives. Warning symptoms prior to failure: No warning lamps, messages, or audible warnings appeared prior to or during the traction loss event. The failure occurred without any prior indication of a problem. Tread wear appeared visually normal at the time of the incident. Assessment: The BFGoodrich Trail-Terrain T/A is marketed and sold as an all-season tire suitable for wet road conditions. The tire's performance in heavy rain is inconsistent with that representation and appears to constitute a safety defect. Multiple independent tire testing sou

STRUCTURE — Filed 04/20/2026

Known manufacturing defect which results in paint flaking off and exposing bare metal to the body. This will eventually result in corrosion and structurally compromise the safety of occupants inside the cabin. This is a known defect which the manufacturer has set an arbitrary cut-off for production date despite the issue ongoing beyond the limit of their recall dates.

POWER TRAIN — Filed 04/18/2026

Coolant bypass duct leaking at just 52,000 miles. Part is made of plastic and is a very common problem.

STRUCTURE — Filed 02/01/2026

The 2016-2022 White double cab Toyota Tacomas have a known paint flaking/peeling issue. On 2/1/2026 while drying my truck after its wash, on the driver’s rear door by the window rubber trim my paint was flaking off. On 2/2/26 I spoke with an agent at Toyota Corporation (but she was on the Lexus side) about my issue and was told my VIN was not part of the Customer Support Program 23TE08 and she didn’t know of Tacomas paint failure. On 2/3/26 I spoke with another agent at Toyota Corporation (this time Toyota side) about my issue and she knew about the paint issue but told me that my VIN was not part of that program. I told her that my paint flaking/peeling issue was the same issue that Toyota was having on their 2016-2022 and mine is a 2022 Tacoma. The Location of my paint flaking/peeling issue the same place where other white Tacomas were experiencing the same problem. It’s a know problem and Toyota needs to fix my paint issue but they seem to not want to extend to include my VIN. I’m frustrated with the fact that my truck only has 35,132 miles at the time of me writing this complaint and spent well over $45,000 for a truck that’s 4 years old for the paint to fail.

UNKNOWN OR OTHER — Filed 01/30/2026

Sunroof window exploded and shattered the whole glass

STRUCTURE,UNKNOWN OR OTHER — Filed 11/05/2025

I am requesting executive-level review and assistance regarding a documented paint failure on my 2022 Toyota Tacoma, finished in paint code 040 (Super White). Toyota has informed me that my VIN is not included in Customer Support Program #XXX. However, this determination does not align with the physical condition of my vehicle, which exhibits the same defect described in that program. The paint on the upper door frame surrounding the driver’s side rear cab window is actively peeling, with bare metal exposed. This is not cosmetic wear, environmental damage, or owner neglect. It is a manufacturing paint failure, occurring in a non-wear area and consistent with issues documented on other 2022 Tacoma vehicles with Super White paint. Exposed metal presents legitimate concerns regarding corrosion, long-term durability, and diminished resale value—none of which should occur on a vehicle of this age. Toyota’s reputation for quality is the reason I purchased this truck, and this experience has been both disappointing and frustrating. I am requesting that Toyota acknowledge the defect based on physical evidence, not solely VIN eligibility criteria, and provide a fair resolution, including inspection and repair or repainting of the affected area. I respectfully ask that this matter be escalated for review and resolution consistent with Toyota’s commitment to customer satisfaction and product quality. Sincerely, [XXX] Owner, 2022 Toyota Tacoma Toyota Brand Engagement Center Reference # 251105002053 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN — Filed 01/08/2026

Transmission blew at 40200 miles under normal driving conditions going approximately 30/35 mph

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM — Filed 08/22/2025

G

STEERING,UNKNOWN OR OTHER — Filed 12/07/2023

Power steering pump was replaced at 33000 miles 12-7-23. Timing chain seal leak, engine was pulled at 37700 miles 6-19-24. Power steering pump leaking again at 45500 miles 1-3-25. White paint peeling at 45500 miles 1-3-25. Toyota said $1100 for new Power steering pump that is 12500 miles old. They will not cover white paint peeling in 3 areas.

AIR BAGS — Filed 03/05/2025

The contact owns a 2022 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, another vehicle failed to stop at a red light. Consequently, the other vehicle collided with the vehicle on the passenger's side door and front quarter panel, sending the vehicle careening and nearly tipping over before coming to a complete stop. The air bags did not deploy. No warning lights were illuminated. The vehicle was towed to the dealer, who submitted a request to the manufacturer to have an engineer inspect the vehicle. The engineer reviewed the incident recorder and informed the contact that the air bags did not deploy because the occupancy sensor did not detect a passenger. The contact disputed the findings, stating that her son was occupying the passenger seat and had been wearing a seat belt at the time of the collision. A police report was filed, and injuries were reported. The contact was transported to an area hospital by EMT and treated for back pain. She later followed up with her primary care physician and neurosurgeon who located a tear just below where a previous surgery was performed stating that the tear was not present as of her most recent evaluation before the accident. The contact stated that she previously had back surgery to repair and/or remove discs L3, L4, and L5. The manufacturer was notified of the failure, and a case was opened. The contact was later informed by the manufacturer that there was no data from the incident recorder on the date of the collision. The failure mileage was 24,000.

AIR BAGS,SEAT BELTS — Filed 02/20/2023

A txdot road work crew had traffic stopped on the highway. We were last in a row of traffic when a distracted, driver, traveling near full highway speed rear-ended us. The truck automatically connected us to an agent who called 911. The message screen showed 2 warnings which said seatbelt malfunction and airbag malfunction. My husband and I both sustained injuries from the forward force against the seat belts to his abdomen and my shoulder, both of which required surgical repair. The airbags did not deploy. The truck was a total loss. A police report was filed but I do not have a copy.

AIR BAGS — Filed 05/01/2024

The contact owns a 2022 Toyota Tacoma. The contact stated that while driving through an intersection at approximately 25 MPH; another vehicle who ran the red light T-boned the contact's vehicle on the passenger side. The air bags did not deploy upon impact. The contact sustained pain in her back and was treated by her doctor for a torn disk. A police report was filed. The vehicle was initially towed to an independent body shop and was later towed to the dealer where it remained in their possession. The manufacturer was notified of the failure and was given a case number. The vehicle had yet to be repaired. The failure mileage was approximately 24,000.

AIR BAGS — Filed 11/15/2024

Wife was in an front end accident driving approximately 35mph hit another vehicle on the side and the airbags didn't deploy.

POWER TRAIN — Filed 07/07/2024

The contact owned a 2022 Toyota Tacoma. The contact stated that while her son was driving at an undisclosed speed, upon reaching his destination, shifting the vehicle into the park position, and exiting, the vehicle began to roll away. The driver was unable to stop the vehicle, and as a result, the vehicle rolled off the roadway, coming to a complete stop at the bottom of a 25-foot embankment. The vehicle's location required specialized recovery, and upon extracting the vehicle, the recovery specialist confirmed that the shifter was shifted into the park position. All air bags were deployed. No warning lights were illuminated. The vehicle was towed to a towed yard and deemed a total loss by the contact's insurance provider. A police report was not filed, and no injuries were reported. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 41,000.

AIR BAGS,FORWARD COLLISION AVOIDANCE — Filed 05/03/2024

I hit an elk on the road. The elk came in direct impact with the front of my truck. No air bags deployed despite the force of the significant frontal impact. There had been no warnings or messages leading up to this that the airbags were not functional, nor was I notified that these airbags were part of any recall. To my knowledge, they are not. The vehicle is currently at a collision center for estimate preparation for the insurance company.

AIR BAGS — Filed 12/21/2023

I was driving on the highway and a semi truck hit my car from behind, pushed my car and I hit the car in front of me. I was doing around 55 mph when thee truck hit me.The airbags did not deploy. but the airbag light was lit up on the cluster. Later I received a message through the toyota app about a malfunction on my car's airbag system, that I have to contact the dealership to get it fix.

AIR BAGS — Filed 11/17/2023

I was crossing through a major intersection. I had the green light so I proceeded in a forward direction. A vehicle traveling west on Hwy 24, ran the red light and struck me in the drivers door. His estimated speed was the speed limit at 35 mph. None of the airbags deployed in my vehicle. The curtain airbag on the drivers side, nor the airbag from the steering wheel. deployed. I hit my head on the drivers side window resulting in a small cut to the side of my head about an inch long, and a contusion on the side and upper part of my head. I did not require medical attention There were no warning lights on my vehicle indicating there was a problem

SERVICE BRAKES — Filed 01/22/2023

(HSA/Auto Vehicle Hold) Upon backing out of a heated garage onto a flat, lightly snow-covered asphalt driveway, a light to medium brake apply to test out surface conditions was done, and little to no sliding was observed. Upon reaching a conclusion that it was likely safe to proceed, vehicle was shifted into reverse and upon nearing the crest of a 14% grade on a residential driveway (asphalt), brakes were lightly applied (similar pedal force to the "test"), then released once grade was almost crested. The vehicle had been shifted into neutral and clutch was released prior to applying the brakes. It seemed as if the brake pressure from the light apply was not released, and wheels remained locked causing loss of control. ABS did not activate, and steering input had little/no effect. Vehicle slid off of driving surface and struck a tree, causing damage to rear bumper, tailgate, and rear left quarter panel (no visible frame damage). Upon safely bringing the vehicle back onto the driveway surface (bottom of driveway, ~5-9% grade), a second test to see if brake pressure was trapped was performed. The vehicle was allowed to roll to ~3mph, same light pedal force as before was applied and the brake pedal was released (in neutral with clutch released). The vehicle skidded to a stop with no signs of ABS or stability control activation (no lamps, etc), and about 2s later, a clicking sound was heard from the engine bay and the vehicle began rolling freely again with foot still off the pedal. No warning lamps ever illuminated, nor were any messages or functional notifications. No throttle input was given after the vehicle was shifted out of reverse.

AIR BAGS,SEAT BELTS — Filed 08/15/2022

The truck was rear ended on 8/15 by a car going 45 miles per hour at a stop light. The air bag sensor went on and air bag did not deploy. It DID NOT deploy when it should have. Both passenger and driver seatbelt did not lock. They DID NOT LOCK. That sensor is also on. Was contacted by dealer after they were notified air bag went off when it did not go off and should have gone off. Seatbelts did not lock on impact causing injury. Car is not drivable due to these sensors and life saving features not working. Sensors are on. Insurance company says car can not be driven it is unsafe. Both driver and passenger went to emergency room. It is our sons car who is in college in Colorado.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL — Filed 03/20/2022

The contact owns a 2022 Toyota Tacoma. The contact stated that while parked outside his residence and while depressing the brake pedal, the vehicle accelerated on its own. The contact stated that vehicles steering wheel had locked and he was not able to stop the vehicle , causing him to crash into his neighbors home. The contact stated that no warning lights had illuminated at the time the failure occurred. The contact stated that the police was contacted and a police report was filed. There were no injuries reported. The contact stated that the police then had the vehicle towed to a tow yard. The contact stated that he then contacted the manufacturer who advised him that would contact him within 72 hours. The contact stated that he had not contacted the dealer. The failure mileage was 3,500.