2019 Toyota Tundra Complaints

UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE — Filed 07/20/2026

The Forward Recognition Camera on my 2019 Toyota Tundra has suffered an internal failure. The vehicle was inspected by an authorized Toyota dealership, which diagnosed and documented:"FOUND INTERNAL FAULT IN FORWARD RECOGNITION CAMERA." The failed component is available for inspection. This camera is a critical safety component that supports forward collision warning, automatic emergency braking, and other driver-assistance systems. Because of this internal failure, the vehicle's ability to detect potential hazards may be reduced or disabled, leaving the driver without safety features that were designed to help prevent or mitigate crashes. This failure places not only the occupants of my vehicle at risk but also other motorists, pedestrians, and cyclists sharing the roadway. The condition was reproduced and confirmed by an authorized Toyota dealer. The dealer determined that the camera itself had internally failed and requires replacement. The failure was not attributed to an accident, impact, misuse, modification, or outside damage. It was diagnosed as an internal fault of the camera assembly. Prior to diagnosis, warning messages and safety-system malfunction alerts appeared on the vehicle, indicating that the driver-assistance systems were not functioning properly. These warnings prompted me to seek service. The dealership subsequently confirmed the internal camera failure. I am concerned that this component failed under normal operating conditions in a relatively modern vehicle and that other Toyota Tundra owners may be experiencing the same defect. A safety-critical camera system should not experience an internal failure that disables key crash-avoidance technologies. I am requesting that NHTSA investigate whether this defect is affecting other 2019 Toyota Tundra vehicles and determine whether corrective action, including a recall, is warranted. The dealer diagnosis specifically states:"FOUND INTERNAL FAULT IN FORWARD RECOGNITION CAMERA."

FUEL/PROPULSION SYSTEM — Filed 09/24/2026

The fuel pump and the fuel pump control module system failed. Before the failure, I drove my 2019 Toyota Tundra on XXX from [XXX] to [XXX] with no prior check engine light warning. It was parked for all 3 days at a campground in [XXX]. However, on XXX the vehicle would not start. The truck ignition was moved to the RUN position and then the check engine light came on, which was the first notification of a potential problem. So, I attempted to start the vehicle, there was a crank but not a start incident. The ignition was moved back to the OFF position. I'm also an experienced mechanic, so I lifted the hood to diagnose the issue and search where the malfunction was occurring. I inspected the battery, all the fuses, the relays controlling the fuel pump, and the fuel pump control module. Using a Voltmeter Tester, the battery had a full charge. The relays and the fuses were also replaced with no success in starting the vehicle. The fuel line was disconnected from the fuel rail so I could verify if fuel was getting to the engine. The truck ignition was again moved to the RUN position and then the Start Position with NO success of fuel getting to the fuel rail. The vehicle was then towed to a local auto shop and the problem has been reproduced only by Crawford Auto Repair shop in [XXX]. The auto mechanic mentioned two error codes were presented: 1. The fuel pump 2. The fuel pump control module. Thankfully, there was no immediate risk to my family's safety but it could have occurred while driving back through the [XXX] mountains on our way home. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM — Filed 12/31/1969

We had just exited the interstate when my Toyota Tundra stopped. We had it towed to the closest Toyota dealer. We had to have fuel pump replaced. They said the previous year Tundra was recalled for this issue, but ours was not. I just found out that some of the 2019 models had been recalled for this issue. They said my VIN was not recalled. That does not make sense. It was the same problem, same year, just at a different plant. Now we are having other fuel issues and the dealer says it all stems from the replacement of the pump, which we had to pay out of pocket. If we had not just exited the interstate it could have caused a major accident.

ELECTRICAL SYSTEM,EXTERIOR LIGHTING — Filed 03/15/2026

The contact owns a 2019 Toyota Tundra. The contact stated that while parked for 5-10 minutes, the contact noticed a burning plastic odor, and upon looking up moments later, the contact noticed flames coming from the driver's side headlight, and the flames were 6 inches above the headlight. The contact started extinguishing the fire with water bottles. The contact drove to a water hose, which the contact also used to extinguish the fire. The contact sustained minor smoke inhalation. No police report was filed. The contact was able to drive to the nearby residence. The contact related the failure to NHTSA Campaign Number: 21V688000(Exterior Lighting, Electrical System), which included the VIN. The manufacturer was notified of the failure and sent a field inspector, who inspected the vehicle and informed the contact that the inspection report would be completed on the same day; however, the manufacturer would follow up with the contact within 45-60 days. The contact followed up with the manufacturer three days later and was provided with the same information. The dealer was not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 100,500.

FUEL SYSTEM, GASOLINE — Filed 02/09/2026

The contact owns a 2019 Toyota Tundra. The contact stated that while starting the vehicle, the engine sounded rough. The check engine warning light was illuminated. The vehicle was turned off and failed to restart. The vehicle was towed to an independent mechanic, where the ECU was reset; however, the failure reoccurred. The mechanic referenced NHTSA ID Number: 20V682000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 104,000.

FUEL/PROPULSION SYSTEM — Filed 12/11/2025

My toyota tundra is having issues with the fuel pump. It is saying I am using e85 fuel when that is not the case. As a result I am having issues with cold start. There are recalls however I am being told that my truck is listed among them despite having the same issue.

FUEL SYSTEM, GASOLINE — Filed 12/19/2025

The contact owns 2019 Toyota Tundra. The contact stated that while attempting to start the vehicle, the vehicle failed to respond immediately. The contact stated that while driving 40 MPH and depressing the accelerator pedal, the vehicle stalled, and approximately thirty seconds later the vehicle worked as intended. A dealer was contacted. The vehicle was taken to a dealer and was diagnosed and determined that the fuel pump needed to be replaced, and codes were in the recall. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 20V682000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was 80,000.

UNKNOWN OR OTHER — Filed 12/31/1969

I bought this car in January 2019, and even though it had 210 miles, they sold it to me as new. I think they did something illegal because I have the purchase contract and they didn't put that information there. They put 10 miles and I didn't notice at the time. Also, I have the window sticker and it says the car comes standard with a remote key for entry, and the dealer removed it to make it without one. I'm ashamed I didn't report this sooner. It must be a form of consumer theft, something they only do to protect themselves.

ELECTRICAL SYSTEM,SERVICE BRAKES — Filed 08/18/2025

Intermittent message displaying "Trailer Brakes Disconnected" while towing. Trailer lights continued to operate even while message was displayed. On average trailer connected and disconnected every 2-3 minutes

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 07/24/2025

Keep getting the messages "Trailer brake error, if towing come to a stop with manual controls" And "Pre-collision system malfunction" The messages go away usually after restarting the vehicle but eventually comes back on

STEERING — Filed 07/17/2025

I had to have the steering rack assembly replaced in my vehicle due to a leak. This is one of the complaints and a recall but I never got a notification.

UNKNOWN OR OTHER — Filed 06/03/2025

The built-in navigation system in my 2019 Toyota Tundra is dangerously outdated and cannot be updated over-the-air (OTA). Recently, it misrouted me into a remote, unfamiliar area with no cell service and incorrect road data. If I hadn’t had enough fuel, I could have been stranded in potentially life-threatening conditions. Toyota continues to install these systems with outdated maps and no OTA functionality, while presenting them as part of a reliable, intelligent driving experience. This is not a minor tech issue—it is a safety failure. Drivers are led to trust a system that cannot be trusted. I want to be clear: this experience has completely changed how I view Toyota as a brand. What seemed like a small, fixable flaw turned into a moment of genuine danger. That moment told me everything I needed to know about Toyota’s priorities—and Toyota is no longer in my future because of it. I urge NHTSA to investigate this as a potential recall-level issue. A navigation system that actively misleads the driver and offers no timely updates is not just broken—it’s hazardous.

SERVICE BRAKES, HYDRAULIC — Filed 03/01/2020

The contact owns a 2019 Toyota Tundra. The contact stated that while replacing the shocks, the contact noticed that the shocks were oily. The vehicle was taken to the local dealer for warranty repair, and the contact was informed that the brake pads on the rear axle were soaked with oil. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 30,000.

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM — Filed 01/01/2025

The contact owns a 2019 Toyota Tundra. The contact stated while driving at an undisclosed speed on several occasions, the vehicle stalled. There was no warning light illuminated. The vehicle failed to restart and was towed to the dealer on two occasions. The dealer diagnosed that the fuel pump had failed and needed to be replaced; however, the fuel pump part #770200C170 was on backorder. The dealer reprogrammed the fuel pump system twice as temporary repairs; however, the failure persisted. The contact stated while driving 35 MPH, the vehicle stalled. There was no warning light illuminated. The contact was unable to pull over to the side of the road. The vehicle failed to restart and was towed to the residence, where it was diagnosed by a mobile mechanic. The mechanic diagnosed that that the fuel pump was burned, causing the electrical connector part #9098010844 to burn and melt. The dealer was contacted and informed the contact that the electrical connector part had been discontinued. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the factory warranty. The failure mileage was approximately 102,000.

FUEL/PROPULSION SYSTEM — Filed 03/14/2025

Truck shut off while driving fuel pump connector in the tank was melted and could have started a fire. Was told my tundra doesn’t fall under the recall but is having the same problem

FUEL SYSTEM, GASOLINE — Filed 01/15/2023

The contact owns a 2019 Toyota Tundra. The contact stated while attempting to start the vehicle at the residence, the contact stated that the engine was shaking abnormally. No warning lights were illuminated. The contact stated that a dealer was contacted. The vehicle was taken to a dealer where it was diagnosed and determined that the fuel pump needed to be replaced, and that the electrical fuel module needed to be reset. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 20V682000 (FUEL SYSTEM, GASOLINE). The manufacturer was notified of the failure and opened a case. The failure mileage was 117,000.

ENGINE,FUEL/PROPULSION SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 01/15/2025

Having fuel pump issue. Car stalls very badly and pre collision light and engine lights start flashing. Severe jumping by car driving down the road. When accelerating the car has no acceleration and hesitates very badly.

FUEL/PROPULSION SYSTEM — Filed 12/05/2024

When refueling this vehicle, gasoline will flow out of the filler tank onto the ground and will shoot out onto the person filling the truck up. Have had the charcoal canister replaced twice and this has not fixed the problem for any length of time. Dealer claims that vent tubes are getting clogged up but cannot explain how or why they are plugged up. Last repair lasted one week before fueling issues showed up again. The gas shooting out of the filler hose onto people standing nearby and onto the ground is an extreme fire and explosion issue and is an environmental issue. This problem seems to be a common issue based on internet search for Toyota Tundra refueling issues. There has been a service bulletin published by Toyota on this issue. I have been having this problem for over 2 years.

EXTERIOR LIGHTING — Filed 11/20/2024

Factory installed OEM LED HEADLIGHTS: While driving in WET SNOW and SNOW conditions, headlights get covered in snow and visibility is greatly reduced to almost zero.

AIR BAGS — Filed 10/10/2024

The contact owned a 2019 Toyota Tundra. The contact stated that while driving at approximately 45 MPH, an oncoming vehicle did not obey a stop sign and proceeded to crash into the rear driver's side of the contact's vehicle. As a result, the contact lost control of the vehicle and crashed into the platform of an 18-wheeler. No air bags deployed. No warning lights were illuminated. The vehicle was towed to his residence. A police report was filed. The vehicle was deemed destroyed by the insurance company. The contact who was the driver sustained severe back pain and an injured left knee pending further treatment at a clinic. The front passenger sustained bruising to the left arm and back pain but did not seek medical attention. The rear passenger sustained bruising to the right arm and back pain but did not seek medical attention. The other vehicle occupants did not sustain injuries. A dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 75,000.

AIR BAGS — Filed 04/21/2023

The contact owns a 2019 Toyota Tundra. The contact stated that while driving approximately 75 mph, a 2008 Lincoln struck the rear passenger side of her vehicle which caused her vehicle to tail spin and crash into the guardrail. The vehicle continued to tailspin. The air bags did not deploy. All the warning indicator lights were flashing after the crash. The contact sustained a laceration on the neck, a bruised hip, and leg pain and was provided medical attention at the hospital. A police report was filed. There were no reported fires. The vehicle was towed to a towing lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 80,000.

UNKNOWN OR OTHER — Filed 12/04/2022

We were driving down an unpaved road at 8 mph in 4WDh in our 2019 Toyota Tundra when I heard a couple popping sounds from inside the car. Then it stopped. I opened the passenger side door to get out and check on the truck, and flames were pouring out under the engine. There were 3 of us in the car. We immediately got out and tried to pour water and throw sand on the fire. It grew very quickly, so we ran away. The car was immediately engulfed in flames like something out of a movie with black smoke going high into the air. Within 5-10 minutes, the truck was totally gone. There were no warning signs/lights other than the 2 pops and then fire/explosion. We are very lucky we did not die. We bought it brand new. It was the first new car we’ve ever owned. It was impeccably cared for. We always brought it to the Toyota dealership in Eugene, OR for service. It was there about a month prior to the explosion. During that visit, they replaced the battery as well as dealt with the halogen light recall. Other things were more routine maintenance. We are in shock and do not want this to happen to others. We also do not know what our next steps are, but we wanted your agency to be aware of this issue. The local dealership said it must have been a car defect or bad workmanship at our last service. Either way, it was terrifying.

ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 07/06/2021

Intermit message "Trailer disconnect " message causing the trailer braking system to fail when attached to truck. Truck brakes are used to stop trailer at unsafe distances. Several trailers were used to verify. I have attached the fix but Toyota says its warranty issue. This is a "safety" issue. I had my 3 year old son in the truck when i had to apply the brakes and couldn't stop in enough time. The truck brakes could not handle the weight of the trailer hence why the trailer brakes were needed. Please prevent a death.

AIR BAGS — Filed 09/13/2020

I WAS DRIVING DOWN THE ROAD ON THE FREEWAY WHERE THE SPEED LIMIT WAS 75 MPH. WHILE DRIVING MY PASSENGER SAID I PASSED OUT, FLOORED THE GAS PEDAL AND JERKED THE STEERING WHEEL TO THE LEFT. I THEN DROVE THROUGH THE MEDIAN AND INTO ONCOMING TRAFFIC REACHING 90 PLUS MPH, MISSING TWO CARS, AND JUMPING A 4 FOOT BARBED WIRE FENCE WITHOUT TOUCHING THE FENCE. I CONTINUED INTO THE DESERT UNTIL MY PASSENGER WAS ABLE TO PUT THE TRUCK IN PARK HITTING A FEW TREES AND BUSHES ALONG THE WAY. I THEN WOKE UP WHEN PARAMEDICS AND FIRST RESPONDERS WERE ALREADY THERE. ME AND THE PASSENGER WERE BOTH WEARING OUR SEATBELTS AND MY PASSENGER DID NOT AQUIRE ANY INJURIES. I HAD A SIEZURE TO CAUSE THE ACCIDENT AND HAVE HAD MULTIPLE ONES SINCE THEN A MONTH AGO. THE FRONT OF MY TRUCK WAS MANGLED AND THE FRAME WAS BENT IN TWO PLACES. THE ISSUE IS I SUFFERED 4 FRACTURES IN MY SPINE TOP OF THE LUMBAR AND BOTTOM 3 OF MY THORASIC. I AM CURIOUS AFTER TALKING TO THE MECHANIC WHO LOOKED OVER MY TRUCK AS TO WHY MY AIRBAGS DID NOT DEPLOY DURING THE ACCIDENT. IN SUMMARY I WAS IN AN ACCIDENT THAT TOTALED MY TRUCK, AND THE AIRBAGS DID NOT DEPLOY AND I SUFFERED MULTIPLE SPINAL FRACTURES.

POWER TRAIN — Filed 08/05/2019

VEHICLE PARKED ON BOAT LAUNCHING RAMP 25-30% SLOPE CONCRETE SURFACE WITH 24 FOOT ALUMINUM TRAILER IN TOW; BOAT OFF TRAILER, TRUCK FACING AWAY FROM WATER, TRAILER CLOSEST TO WATER. SUNNY, RAMP WAS DAMP, WITH SOME WOOD AND AQUATIC VEGETATION ON RAMP. VEHICLE WAS IN 2 WHEEL DRIVE. AFTER UNLOADING BOAT USING A LAUNCH CORD AND PULLING BOAT ONTO RAMP, DEPRESSED BRAKE AND MOVED SHIFTER FROM DRIVE TO PARK. PARK ENGAGED AND STEPPED FROM VEHICLE WHEN TRUCK BEGAN TO ROLL BACKWARD. LUNGED INTO CAB, SAW SHIFTER WAS NOW IN NEUTRAL! WAS ABLE TO REACH SHIFTER AND ATTEMPTED TO PUT INTO PARK. GEAR SHIFT MOVED TO PARK BUT VEHICLE CONTINUED TO ROLL AND I HEARD AN AUDIBLE CLICKING FROM TRANSMISSION AREA. TRUCK (AND ME) CONTINUED BACKWARD INTO LAKE, ALMOST DROWNED BUT FOR HELP OF A GOOD SAMARITAN ON SHORE. WHEN TRUCK RECOVERED IT WAS IN PARK, WRECKER OPERATOR HAD TO MANUALLY BYPASS THIS TO LOAD ON FLATBED. MY PRIOR 2019 TUNDRA CREW CAB DID SAME THING I CANNOT BELIEVE THIS HAPPENED. IN 2007 ON YOUR SITE SOMEONE REPORTED SAME TUNDRA ISSUE UNDER CONTROLLED CONDITIONS. SOMETHING IS WRONG WITH THIS TRUCK'S TRANSMISSION. NEVER HAPPENED UNDER ANY OTHER CIRCUMSTANCES BUT I ASSURE YOU IT IS GOING TO RESULT IN SOMEONE DYING I ALMOST DID. BOTH CLAIMS HANDLED BY USAA INSURANCE, DATE OF ACCIDENT MONDAY, 5 AUG,