2024 Toyota Tundra Complaints

ENGINE — Filed 10/05/2026

While driving, engine seized. Truck only has 33,700 miles and has been maintained regularly.

UNKNOWN OR OTHER — Filed 10/01/2026

Subject: NHTSA Safety Complaint: Sudden Engine Seizure and Loss of Motive Power – 2024 Toyota Tundra (Recall 25V767 Alignment) To Whom It May Concern, I am writing to formally lodge a critical safety complaint regarding a life-threatening mechanical failure. On XXX, while driving at highway cruising speeds under normal operating conditions (no towing or payload), my vehicle suffered an abrupt, complete internal engine seizure and a total loss of motive power. Simultaneously, the instrument cluster displayed a "Pull over to level ground, oil hot" thermal alert, indicating an acute, systemic mechanical breakdown. This failure sequence directly aligns with NHTSA Recall 25V767 (Toyota Recall 25TA14 / 25TB14), which addresses permanent main bearing destruction caused by manufacturing debris left inside the V35A engine block. My local dealer, [XXX] Toyota, intends to process this repair under an extended warranty. I strongly reject this classification. Because this catastrophic failure perfectly matches the technical parameters and safety risks of an active federal campaign, it must be handled strictly under the purview of the federal recall framework. I request that NHTSA document this event to ensure Toyota is held accountable under its recall mandate. Sincerely, [XXX] [XXX] [XXX] | [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE AND ENGINE COOLING,EXTERIOR LIGHTING — Filed 10/01/2026

The contact owns a 2024 Toyota Tundra. The contact received notification of NHTSA Campaign Numbers: 26V320000 (Engine and Engine Cooling) and 25V322000 (Exterior Lighting); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 14,900.

ENGINE AND ENGINE COOLING — Filed 11/30/2024

The contact owns a 2024 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 26V320000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that while driving or accelerating from a complete stop, the vehicle hesitated for 5–6 seconds before accelerating as intended, with a ticking sound coming from the engine. Additionally, the contact saw puddles of oil on the garage floor, and there was an abnormal burning oil odor coming from the vehicle. Several dealers and the manufacturer were notified of the failure by phone; however, a diagnostic test was denied, and the contact was advised to wait until parts for the recall repair were available to repair the vehicle. The failure mileage was approximately 9,000.

ELECTRICAL SYSTEM,SEAT BELTS — Filed 12/10/2025

Front seat belt alarm randomly goes off indicating that the seatbelt is not buckled. This occurs randomly at times 3-5 time a day or days without incident. I feel my safety is at risk because the vehicle does sense that the driver or passenger is buckled. Does this have an impact on other safety features like the airbags deloying? If there are no direct safety impacts, there is also the impact of it distracting the driver and causing an accident. The problem is so random that the dealer has not reproduced it. However, I have video evidence of it occurring and Toyota still does nothing. Inspected only by Toyota during service. No- not regarding specifically this issue but the truck also has numerous other electronic glitches to say.

TIRES — Filed 09/01/2026

The contact owned a 2024 Toyota Tundra equipped with Falken Tires, Tire Line: Wildpeak A/T3WA, Tire Size: 265/60/R20, DOT Number: [XXX]. The contact stated that all four tires were prematurely worn, with the steel belts visible. The manufacturer was notified of the failure and stated that the tread wear failure was characteristic of the type vehicles due to the factory alignment configuration, allowing for the abnormal wearing of the tires. The dealer was notified of the failure but declined to assist. The contact stated that the TPMS warning light was illuminated. The contact was notified by the manufacturer that there was a TSB for the failure; however, the vehicle was not included in the repair. The vehicle failure mileage was 38,000. The tire failure mileage was 28,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING,ELECTRICAL SYSTEM,ENGINE — Filed 09/19/2026

On Saturday, XXX, while driving on [XXX] toward [XXX], our 2024 Toyota Tundra (VIN: [XXX]) lost power and stalled at highway speeds with the warning: "Ignition On / Engine Off – Stop in a safe place." I made an emergency lane change with 6 vehicles trailing closely. After smoke expelled during restart attempts, Toyota Roadside towed the truck to Goldsboro Toyota at 5:15 PM. On Monday,XXX, Goldsboro Toyota exhibited negligent, misleading treatment. A receptionist falsely claimed they "ordered a new engine" for the recall and refused to release the truck to Midlands Toyota near our home in [XXX]. Despite written instructions on the intake form, we waited 7 hours with no update. On Friday, XXX, Toyota Corporate contradicted the dealer, confirming no technical remedy or engine currently exists for active federal Safety Recall 25TA14 (NHTSA [XXX]). This catastrophic engine failure created an extreme safety hazard that severely triggered my wife’s diagnosed ADHD and depression (Eggshell Plaintiff Doctrine). The dealer’s refusal to release our truck also disrupted my work during a critical corporate shareholder transition. Under the federal Magnuson-Moss Warranty Act and state breach of warranty laws, we demand a Full Manufacturer Repurchase (Buyback): 1. Full payoff of our remaining loan balance to our lender. 2. Complete refund of all out-of-pocket payments: down payment, all $824 monthly payments, sales taxes, and county fees. 3. Full reimbursement for direct expenses and tax penalties. 4. Non-economic cash settlement for severe hardship, safety risks, and aggravated emotional distress. 5. 100% coverage of all statutory attorney’s fees as required by law. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN — Filed 09/20/2026

I was driving when the car suddenly lost power and speed. The accelerator stopped working properly. Immediately, the check engine light came on for the first time on the instrument panel, along with the "Stop Parking" alert. I immediately called for a tow truck to take me to the nearest Toyota dealership.Toyota employees informed me that the transmission is damaged and needs to be replaced. I acknowledge that my 2024 Toyota Tundra has 100,000 miles.and that the factory warranty only covers up to 60,000 miles.But for such an expensive truck, it’s impossible for the transmissions to have a lifespan of only 100,000 miles.

ENGINE — Filed 09/06/2026

When I was driving the engine failed . I have a 2024 hybrid, they are fixing the engine and parts but my frustration is 2024 gas tundra had a recall on the engine and they got a whole new engine with extra warranty , and I'm the first hybrid to have engine fail and since they haven't put a recall out I only get 1 year warranty and they are just replacing the parts not the whole engine . I'm concerned it can happen again past the one year warranty . They need to put out a recall on the hybrids too

POWER TRAIN,ENGINE — Filed 06/20/2026

On XXX6, while driving on the highway at approximately 89 mph and 36,714 miles, the engine misfired and the vehicle began shaking. The check engine light started flashing and a "reduced power, visit dealer" message appeared, along with a loss of motive power. The vehicle was taken to an authorized dealer on XXX at 37,032 miles. The dealer's repair order documents stored diagnostic trouble codes for random misfires, and states that freeze frame data confirmed misfires on cylinders 3, 4 and 5 at 89 mph and 2700 rpm in direct injection mode. Despite this, the repair order was closed as "no issue found." No repair and no further diagnosis was performed. The dealer stated the condition could not be duplicated after driving the vehicle and idling it for about an hour. The vehicle is subject to an open safety recall for machining debris in the engine (NHTSA 25V767, manufacturer 25TB14), for which no remedy is available. The recall summary lists engine knocking, rough running, no-start and loss of motive power as symptoms, and instructs owners experiencing symptoms to contact their dealer. When contacted, the dealer stated the manufacturer is still developing a remedy and that the vehicle can either wait indefinitely or be picked up as is. The defect remains undiagnosed and unrepaired. The vehicle is available for inspection. The safety concern is a sudden loss of motive power at highway speed, which is the same risk identified in the manufacturer's own recall filing. No remedy has been made available more than ten months after the recall was filed. Video of the failure as it occurred, showing the check engine light flashing and the loss of power: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE AND ENGINE COOLING,EXTERIOR LIGHTING — Filed 06/18/2025

The contact owns a 2024 Toyota Tundra. The contact received notifications for NHTSA Campaign Numbers: 25V322000 (Exterior Lighting) and 25V767000 (Engine and Engine Cooling); however, the parts to perform the recall repairs were unavailable. The contact stated that while driving 60 MPH, the vehicle shuddered and vibrated abnormally and lost motive power, with the check engine warning light illuminated. The contact restarted the vehicle and drove to the dealer for diagnosis; however, the dealer was unable to determine the cause of the failure. The contact stated that the torque converter, transmission, and rear differential were previously replaced to stop the shuddering and vibration while accelerating; however, the failure persisted. The contact stated that the manufacturer failed to repair the vehicle within a reasonable amount of time. The manufacturer was notified of the failure. The failure mileage was 20,000.

ENGINE AND ENGINE COOLING,EXTERIOR LIGHTING,BACK OVER PREVENTION — Filed 08/21/2026

The contact owns a 2024 Toyota Tundra. The contact stated that while driving approximately 40-45 MPH, the radio started blinking, and the vehicle lost power and stopped in the middle of the road. The contact was able to restart the vehicle; however, there was a burning odor, and white smoke was coming from the HVAC system and the engine compartment. The contact turned off and exited the vehicle and the smoking stopped. The contact called the local Police to assist with directing traffic while waiting for towing assistance. The vehicle was towed to the dealer. The dealer attempted to return the vehicle to the contact after 3 weeks without confirmation of the diagnostic results or any repairs. The contact stated that the vehicle had been taken to the dealer before the failure had occurred to be repaired under NHTSA Campaign Numbers: 25V767000 (Engine and Engine Cooling), 25V322000 (Exterior Lighting), 26V038000 (Back Over Prevention); however, the dealer failed to complete the recall repair because there was not enough mechanics to perform the repairs. The manufacturer was informed of the issue. The failure mileage was approximately 26,000.

ELECTRICAL SYSTEM — Filed 04/09/2024

Awaiting 13 months for safety remedy for NHTSA RECALL NUMBER 25V322. NO INFORMATION FROM MANUFACTURER NOR CAR DEALER. NO ONE HAS ANY INFORMATION REGARDING TIMETABLE FOR SAFETY REPAIRS.

ENGINE — Filed 09/05/2026

* 2024 Toyota Tundra Limited non hybrid TRD Off Road with 43k miles with catastrophic engine failure with no warning. Started as a very slight ticking sound while doing about 60 mph level to slightly downhill. * I could only hear it with very light throttle input (between 2 and 5%). Past 5% and at 0 pedal there was nothing. This went on for about 1 minute then it started to get significantly louder and more noticeable with throttle input and while starting to go uphill. * Shortly after it started catastrophically knocking with dash saying loss of power and oil pressure. * I get it stopped and it immediately shut down on its own. Due to very little warning I was forced to pull over on a right curve of a highway potentially putting my family and as well as passing traffic in danger. * Engine leaking oil. Couldn’t find anything obvious where the oil was coming from. After doing some research it seems like the front and main crank seals started leaking. More noticeable on the rear seal. This was a dangerous situation because oil was leaking on the hot exhaust and could have cased a fire on the side of a highway. * The Toyota dealer has possession of the vehicle for repairs. They have not stated if it is possible to be available for inspection. * The dealer has inspected the vehicle and is in the process of ordering a replacement engine.

ENGINE — Filed 09/05/2026

Engine stalls or hesitates when taking off from a stop. When taking off from a stop the Truck will hesitate after the accelerator is pushed and not move forward. This hesitation causes me to push the accelerator more trying to get the Truck to move. When the truck does move it then lunges forward I assume because I continue to push the accelerator more trying to get the Truck to move. The engine in this Truck is also being recalled in Non Hybrid Models because they are seizing up. This is the exact same engine in the Hybrid and should be under the same recall for the engine seize defect.

ELECTRICAL SYSTEM,EXTERIOR LIGHTING — Filed 05/01/2025

I am the owner of a 2024 Toyota Tundra. My vehicle is subject to open NHTSA Recall No. 25V-332, for which I received notification. It has now been over a year since this recall was issued, and no remedy has been made available to me. I have contacted my Toyota dealership and was told the remedy parts are not yet available' or 'no timeline could be provided. This unresolved recall leaves my vehicle in a condition that Toyota itself has identified as an unreasonable safety risk. The prolonged delay in providing a free remedy, as required under the National Traffic and Motor Vehicle Safety Act, is my basis for this complaint. I am requesting that NHTSA investigate Toyota's compliance with recall remedy timelines and follow up on the status of parts/software availability for this recall.

ENGINE — Filed 02/02/2026

I am writing to formally express my concern regarding my 2024 Toyota Tundra, VIN [XXX], and the engine recall involving certain 2024 Tundra vehicles. I am very concerned about the possibility of engine damage or failure related to machining debris and the potential for loss of power while driving. This is a major safety concern, especially considering the vehicle is relatively new. I would like Toyota to confirm whether my VIN is included in the recall and provide a clear explanation of the required repair or inspection process. If my truck is affected, I am requesting that the recall repair be completed as soon as possible at no cost to me. I would also like confirmation regarding whether Toyota will provide a loaner or rental vehicle if my truck must remain at the dealership for an extended period, particularly if an engine replacement is required. Please document this complaint and provide me with a written response explaining the next steps and expected resolution. Thank you, [XXX] Vehicle: 2024 Toyota Tundra VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 05/03/2026

The contact owns a 2024 Toyota Tundra. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the short block engine needed to be replaced. The vehicle was repaired. The contact researched and became aware of an unknown recall; however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.

ENGINE — Filed 08/24/2026

Total engine failure in v35a at 65- 70 mph which dealer has confirmed was due to main bearing failure. Inability to accelerate vehicle in heavy traffic lead to extreme unsafe situation. No warning lamps came on until after the vehicle completed stopped running. Both the manufacturer and the NHTSA are well aware of the continued problems with these engines and the unsafe failure. The only warning ‘hybrid system malfunction “( which has nothing to do with dealer performed diagnostic of metal in oil pan failed main bearing) came on after the truck was inoperable.

VISIBILITY/WIPER — Filed 03/22/2025

My Toyota Tundra's windshield spontaneously cracked while I was sitting at a stop in the vehicle. The crack started below the hood line and there are huge number of Tundra owners having the same issues with Tundras manufactured from 2022 - 2026. Toyota refused to acknowledge the issue but it is widespread on the internet.

EXTERIOR LIGHTING,VISIBILITY/WIPER,BACK OVER PREVENTION — Filed 09/13/2025

My 2024 Toyota Tundra 1794 Edition, VIN [XXX], is subject to Toyota Safety Recall 25TA06, Interim 25TB06, NHTSA Recall 25V322, concerning reverse lamps that may become inoperable. The recall was announced in May 2025, but a repair remedy has still not been made available for my vehicle. The truck is primarily used for family transportation, including trips and nighttime driving. I experienced a minor, low-speed property-damage incident while reversing in a poorly lit garage area. Visibility behind and beside the vehicle was limited, and the truck contacted a garage-door support column before the garage lighting came on. The incident caused minor cosmetic side damage. There were no injuries, no structural damage, no police report, and no insurance claim. I previously advised Toyota that I had experienced an issue related to the recall. Toyota opened Customer Experience Case [XXX]. Toyota offered to keep my truck at a dealership indefinitely and provide alternate transportation until a remedy became available, but it could not guarantee a comparable Tundra 1794 or provide an estimated repair date. Toyota later opened repurchase review Case [XXX]. I promptly provided the requested documentation, but despite repeated telephone and email follow-ups, Toyota has not provided a meaningful review timeline, vehicle inspection date, or final determination. My primary complaint to NHTSA is the extended period without an available safety remedy and the continuing risk to owners operating affected vehicles. I respectfully request that NHTSA review the adequacy and timeliness of Toyota’s recall remedy process for this defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM,STRUCTURE,ENGINE — Filed 02/24/2026

The vehicle while parked and not running on our driveway burst into flames and had large fire and explosions that burned the vehicle front half completely. the whole engine compartment burned and melted and destroyed the vehicle. No warning lights, no issues. Just burst into flames and destroyed the vehicle.

FUEL SYSTEM, GASOLINE,ELECTRICAL SYSTEM — Filed 07/10/2025

The contact owned a 2024 Toyota Tundra. The contact stated while the vehicle was parked in front the detached garage, the vehicle caught on fire and the incident was caught on the neighbor's camera at 4:31 AM. The neighbor then informed the contact of the incident. The contact noticed that the vehicle had caught on fire and the fire was mainly coming out of the gas pillar area. The contact stated that the entire vehicle had burned to the ground. The fire was extinguished by the fire department. A fire department report was filed. No police report was filed. There was no injury sustained. The vehicle remained at the scene and was in the process of being totaled by the insurance company. The dealer was notified of the failure and provided vehicle rental assistance. The manufacturer was notified of the failure and informed the contact that it would take up to 30 days for a field investigator to inspect the vehicle. Additionally, the contact was informed that it could take up to 45-60 days to determine whether there was liability. The failure mileage was approximately 13,900.

AIR BAGS,FORWARD COLLISION AVOIDANCE — Filed 05/24/2025

Hit a deer going 53mph, and the air bags did not deploy. Truck dashboard said that air bags were deploying, and then that they had deployed, but the air bags never deployed. The emergency braking and collision warning system all worked fine.

SUSPENSION — Filed 09/01/2024

This Toyota Tundra, equipped with the specially designed air bag rear suspension, for towing, is incapable of towing anything on U.S. roads, particularly U.S, Interstates crossing our country... where a very large portion of these interstates are rutted, like a washboard, caused by over-weight trucks and the weather... and these rutted or rippled interstate roads last sometimes for hundreds of miles at a time... from western Ohio to Montana, easily 75% of the roads are in this condition. The truck is a complete hazard, and extremely dangerous to the driver and anyone else on the highway. It is dangerous to the highest degree and should not be allowed on any U.S. highway. The rear airbag suspension is controlled by a computer, this computer constantly levels the truck, and there is no way to over-ride this system/computer program. So, the truck is constantly trying to level itself. Note, this adaptive air-bag suspension is sold by Toyota as the ultimate towing machine, six years in Toyota design... yet, it is totally incapable of towing on U.S. highways, unless, of course, the roads are new and black top and totally smooth. So, this is what happens, every time the truck hits a bump, the computer tries to level the truck... when towing a trailer, in this case a 30 foot Airstream, the tounge weight is 950 pounds — so with every bump the tounge of the trailer slams down 950 pounds on the back of the truck, and the truck desperately tries to level itself. This creates some sort of synergistic response between the truck and the trailer, and the truck and the trailer start rocking back in forth in a very violent manner, and when you let off the gas and slow down, it becomes even more violent, and extremely difficult to keep on the road and in your lane... not to say, what it does to the driver, who is slammed around the cabin. This suspension was clearly designed on a computer, and never road-tested on U.S. highways and interstates in the north... It is a disaster.