2022 Volkswagen Atlas Cross Sport Complaints

ENGINE — Filed 04/23/2026

I am filing a safety complaint regarding my 2022 Volkswagen Atlas Cross Sport, VIN: [XXX] The vehicle was purchased new in October 2021. Volkswagen issued Recall 13i4 / NHTSA Campaign 22V-753 for certain Atlas Cross Sport vehicles due to an engine connecting rod/connecting rod bearing manufacturing defect that can cause engine failure, loss of motive power while driving, and potential safety risks. My vehicle was inspected by an authorized Volkswagen dealer under Recall 13i4 in 2023. I was told the recall condition was not present and the recall was marked completed. On or about [XXX], the vehicle developed the exact issue covered by Recall 13i4. I brought it to an authorized Volkswagen dealer, and the dealer confirmed that the failure is the same engine connecting rod/connecting rod bearing issue identified in the recall. The required repair is engine replacement. Volkswagen is refusing to reopen or reauthorize the recall repair because the recall was previously marked completed after the 2023 inspection and because the factory warranty expired in October 2025. I am now being told I may be responsible for the engine replacement cost, even though the dealer has confirmed this is the exact safety defect covered by the recall. I believe this is a failed or inadequate recall remedy. The 2023 inspection did not permanently remedy the defect and appears to have missed a latent manufacturing issue that has now manifested. This is not a normal out-of-warranty mechanical failure. It is the specific safety-related defect Volkswagen reported to NHTSA. I am asking NHTSA to review whether Volkswagen’s Recall 13i4 remedy process is inadequate, especially for vehicles that passed the initial inspection but later develop the same covered engine defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

EXTERIOR LIGHTING — Filed 04/13/2026

The daytime running light on the passenger side is out. The entire headlight assembly and bumper have to be removed to repair this. It will cost 1400 to repair. This is a safety issue and should be covered by Volkswagen.

ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL,ENGINE — Filed 03/04/2026

Description of Fault This vehicle exhibits a recurring, intermittent failure of the electronic throttle control system. Three distinct symptom patterns have been observed: 1.Throttle non-responsive at stop-start (approx. monthly/bi-monthly): After coming to a complete stop (e.g. at a traffic light), pressing the accelerator pedal produces no engine response. The vehicle will not move. Switching the ignition fully off and performing a cold restart resolves the issue immediately. 2.Throttle failure while vehicle was in motion (Wednesday, March 4, 2026): While my wife was driving the vehicle, the throttle stopped responding entirely mid-journey. The accelerator pedal produced no engine response while the vehicle was moving at speed. This is a direct and serious safety hazard. As with other incidents, switching the ignition fully off and performing a cold restart resolved the issue. 3.Erratic/hypersensitive throttle response on inclines: On slight uphill gradients, a light press of the accelerator pedal produces a disproportionately strong acceleration response, suggesting inconsistent signal output from the accelerator pedal position sensor (APPS). Safety Concern The occurrence of complete throttle loss while the vehicle was in motion — experienced by my wife on March 4, 2026 — is a serious safety defect. A driver who loses throttle response at highway speed, on a merge, or when crossing an intersection is at significant risk of collision. I am formally documenting this concern so that it is part of the vehicle's permanent service record.

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM — Filed 02/13/2026

Got the PCV valve repaired on February 13th and on February 18th the EPC light came on. The 2022 Volkswagen Atlas was taken to dealership and said the charge air inlet and the diverter valve leaking oil. Recommended to replace the turbo diverter valve and the charge air inlet seal at this time and re-testing the turbo. My car is shutting off when sitting at a light and car only has 52, 294 mileage

STEERING,UNKNOWN OR OTHER — Filed 09/01/2025

Vehicle shimmies/shakes when braking of speeds over 50 mph. It is currently at the VW service center and was informed the Electro-Mechanical Steering gear needs to be replaced. The repair tech also said that he wasn't sure when the part would be in and he has a few others on backorder for repair as well.

ELECTRICAL SYSTEM,UNKNOWN OR OTHER,VISIBILITY/WIPER — Filed 01/16/2026

Rear camera, back over prevention system malfunction. Rearview camera image does not display, fails to meet Federal Motor Vehicle Safety Standard number 111, “Rear Visibility.” This happened after the PODS repair was made. Local VW dealer is requiring a diagnostic fee though the problem started immediately after it was serviced.

FORWARD COLLISION AVOIDANCE — Filed 01/12/2026

when I got in my car the display showed that my driver’s door was open, but it wasn’t. When I tried to put it in drive, the car had an awful beeping sound and wouldn’t go into drive unless I released the emergency brake button. Once I came to a stop the car would automatically go into park and wouldn’t not proceed unless I released the emergency brake again. I did look up if there was a recall and there was back in February 15, 2023. I would like to bring it to Volkswagen for it to be fixed and not have to pay for it as I have only owned the car since October of 2025.

EXTERIOR LIGHTING — Filed 08/01/2025

There has been no incident with my car. The DRL on the drivers side stopped working and wasn’t my fault. The price to replace the light is absolutely unheard of. I have owned three Volkswagens and loved all three but this is very disappointing. The car only has 40,000 miles on it. I don’t feel like this should’ve happened this soon.

EXTERIOR LIGHTING — Filed 10/17/2025

The front light led bulbs died. First it was the driver side at 53k miles, now the passenger side. The car has less than 55k miles. The price for the repair is outrageous. $2,000 for just ONE led bulb change. I’ve seen forums and many, many WV Atlas have the same problem. WV should be responsible for this. $4,000 total for two light bulb replacements! It’s insane!

ELECTRICAL SYSTEM,UNKNOWN OR OTHER — Filed 08/15/2025

Initially, my Atlas would not auto-start with the key fab. When I returned to my vehicle, the lights flashed, it gave a battery warning, then I was able to start the vehicle. However, several lights on the dashboard cycled through, radio/center console was non-responsive, and I could not get my car to park. Eventually, I had to use the emergency break to park it. We jumped the vehicle and it did start again. However, very shortly thereafter it lit on fire and there were visible flames under the hood. We called the fire department, put the fire out with water and an extinguisher. Then we had the vehicle towed to the dealership. Its been more than 2 months since this incident and no work has been started. Volkswagen corporate sent an engineer out to inspect my car (confirmed by the dealership that they did visit) but still no work has begun. My car is still covered under the original manufacturer warranty. We bought brand new and have owned the vehicle for less than 4 years. VW Customer Care line has been "close due to an all day employee meeting" since last week. The dealership has no information about my car.