2016 Volkswagen Golf Complaints

AIR BAGS — Filed 04/27/2026

I am reporting a severe safety system failure regarding the airbag deployment force on a 2016 Volkswagen Golf SE. The vehicle was involved in a collision where the frontal/side air bag safety systems engaged. While the impact speed was moderate, the airbag deployment was violently disproportionate, resulting in severe, direct injuries to the occupant rather than providing the intended safety cushioning or protection. The force of the deployment appeared heavily uncalibrated, acting as a primary source of trauma rather than an emergency restraint. In contrast, the secondary vehicle involved in the identical impact matrix sustained similar property damage but experienced a completely stable, non-injurious environment with no air bag enaged at all. I am requesting that NHTSA review this incident against existing vehicle data logs for 2016 Volkswagen Golf models to determine if there is an active trend of excessive pyrotechnic deployment force or uncalibrated SRS module sensors.

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM — Filed 09/19/2025

The EPC light has luminated 3 times in the last several months. The vehicle stutters and will not accelerate past 25 MPH. Shutting off the engine and restarting it clears the light and vehicle drives normally. The check engine light does not illuminate and no OBDII codes are stored. Manual states to take vehicle to authorized dealership for diagnosis if light stays illuminated.

FUEL/PROPULSION SYSTEM — Filed 04/23/2025

I was driving my vehicle on the highway when a driver stopped me and warned me that my vehicle was leaking a huge amount of gasoline. I had a technician inspect the car to see if it might be a fuel line, the technician told me the fuel.lines were good and there were no signs of the gas coming from the lines and no cracks on the tank either. I received a letter from Volkswagen about the recall and I researched it and it says that if that is the problem the car would be leaking gas and it was dangerous as an ignition might cause a fire. I towed my vehicle to the Volkswagen here in Laredo after calling and speaking to someone from service and told yes I could bring it in and the recall part would be replaced free but I would have to leave the vehicle there. When I arrived they told me I would have to pay a diagnostic of 185 dlls and the repair. Which was not what I was told when I called earlier. So I had to pay again to have the vehicle removed from the premises without having the recall part changed.

FUEL/PROPULSION SYSTEM — Filed 11/25/2024

Car began spraying fuel upon turning the key in the ignition. Recall work pertaining to the suction jet pump was recently performed and is the only likely cause of this issue. Car did not leak when fuel pump was disengaged. Very lucky that issue occurred in a parking lot while not moving and did not lead to a fire or crash.

ENGINE,FUEL/PROPULSION SYSTEM — Filed 10/25/2024

My EPC light began to appear randomly in early 2024. I received a recall notice on the gear shift trim around the same time, so called Jack Ingram VW in Montgomery to schedule a time for them to fix it (and also ensure they had the part). I asked them to also check on why the EPC light was coming on. Brought in my car on 2/28/24. Service Dept then tells me they weren't sure what was causing the EPC light to come on, and they didn't have the gear shift trim part. They quoted me a lot of work to do, which I wasn't prepared financially to have completed. EPC light continued to appear at random. Each time it did, my car would shake and it would feel like I was losing control of the vehicle. I received another recall notice for the suction jet pump inside the fuel tank. When I called Jack Ingram VW to schedule this work, I asked if this had anything to do with my EPC light coming on. They weren't sure. The recall work for both the suction jet pump inside the fuel tank and the gear shift trim were completed on 8/28/24. Car worked fine until about a month later and the EPC light came on again. Called another VW mechanic in Montgomery (Powell's Automotive) to see if they can fix it. On 9/20/24 they replaced battery, spark plugs, ignition coil, and did an oil change. Worked great until [XXX] when my engine failed and left me stranded in the road. There were no warning lights prior to the engine failing. Could not restart car. Had it towed to Powell's who could not fix it, then to Jack Ingram VW. I asked them if this had anything to do with the recall work that was done. They said this would be the first if it was. They told me the in tank fuel pump needed replacing. Work completed 10/25/24. How can they work on the suction jet pump inside the fuel tank and not get a diagnostic that the in tank fuel pump was failing? I've already paid a lot of money to try to resolve the issue, and my EPC light is still coming on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL SYSTEM, GASOLINE — Filed 07/01/2024

The contact owns a 2016 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while starting the vehicle, there was an abnormally strong fuel odor inside the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the fuel tank suction jet pump had failed, causing damage to the fuel tank. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 36,018. VIN tool confirms parts not available.

FUEL SYSTEM, GASOLINE — Filed 02/15/2024

The contact owns a 2016 Volkswagen Golf. The contact stated there was fuel leaking from the charcoal canister. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 41,000.

FUEL/PROPULSION SYSTEM — Filed 05/23/2024

We are unable to fill up the gas tank due the recall issue. The dealership says we can bring it in and they will repair but at this time we would have to pay for the repair. VW has not come up with a fix for the recall problem at this time. This problem has rendered our vehicle not drivable. What is the recourse? Fuel also leaks out when trying to fill the gas tank. It could start a fire.

FUEL/PROPULSION SYSTEM — Filed 04/24/2024

My vehicle is leaking fuel. I have been unable to drive it for a few weeks due to the recall not having an approved repair. The dealership did not offer me any solution other than to pay for the repair out of pocket. This has been a known issue since February and no remedy is available from Volkswagen.

FUEL/PROPULSION SYSTEM — Filed 04/01/2024

When refueling, the gasoline spills out and can't fill the tank. Took the car to the dealer and they are asking for 2,500$ for repair.