2015 Volvo XC60 Complaints

ENGINE — Filed 05/16/2026

Engine blew up while my daughter was driving due to excessive oil consumption. Issue known by Volvo but we bought the car in 2023 and the 8year warranty recall was just about to expire and we knew nothing about it. Very dangerous

VEHICLE SPEED CONTROL,ENGINE — Filed 07/03/2025

Component/System that failed: The engine (T5 Drive-E) experienced sudden loss of propulsion and entered reduced engine performance mode. The vehicle is currently available for inspection and was towed to an authorized Volvo dealer following the incident. How safety was put at risk: On July 3, 2025, while driving approximately 75 mph on a crowded interstate highway in rural Ohio with cruise control engaged, the vehicle suddenly and without warning lost propulsion. Traffic included semi-trucks and other vehicles, with limited shoulder availability. The sudden loss of acceleration at highway speed created an immediate risk of rear-end collision and left the vehicle unsafe to operate. Confirmation or reproduction: Prior to the failure, in July 2024 at approximately 92,000 miles, I reported abnormal oil consumption to an authorized Volvo dealer and raised a known Volvo service advisory related to oil consumption in the T5 Drive-E engine. The dealer acknowledged the advisory but refused testing, stating the vehicle did not meet Volvo’s internal threshold. After the failure, a service agent acknowledged that this issue is known to occur in this model at approximately this mileage. Inspections: The vehicle was serviced at an authorized Volvo dealer in Bethesda, Maryland just days prior to the incident. Following the failure, the vehicle was towed to an authorized Volvo dealer in Columbus, Ohio. Volvo Cars USA has not repaired the vehicle and denied a goodwill request. Warnings or symptoms prior to failure: There were no warning lamps or messages prior to the loss of propulsion. The engine warning light and a “Reduced Engine Performance” message appeared only after power was lost.

POWER TRAIN,ENGINE — Filed 08/20/2025

The vehicle shakes and engine abruptly shuts off even after a new tune up

ENGINE,FUEL/PROPULSION SYSTEM — Filed 02/15/2023

02/15/2025 I received a letter for oil consumption recall that was dated on 02/03/2023. Appointment was made same day I received the letter on 02/15/2023 and appointment couldnt be set sooner then 02/23/2023 which is the date the Oil consumption was done at Volvo of Bellevue. They changed the oil and sealed it and had me drive it 1000 miles, they said I didn't have an oil consumption problem and I disagreed because I told them I have to put in oil all the time. They said it has exceeded the 8yr or 100K miles of the extended warranty of the vehicle which ever comes first. I argued it had less then 100K miles when I got the letter on 02/15/2023 and the appointment couldnt be set til 02/23/2025 and Volvo of Bellevue said not to worry about it and they would take care of the recall. But after they had me pay for the oil change they said it exceeded the 100K miles and 8 yrs age of the vehicle. I argued the letter was sent to me after the vehicle was 8 years old and the avg miles of 12K was over 100K miles and I argued this was a known problem with Volvo but they kept on selling these vehicles knowing these vehicles have oil consumption problems. They refused to fix the car unless I paid them Thousands and thousands and thousands of dollars. I trusted what they told me that there was no oil consumption and in less then 7K miles later my engine smoked from their oil change and there was no oil in the vehicle as the engine had consumed all the oil and my car sat in my driveway for 22 months and I replaced many parts and still car wouldn't run. I took it back to Bellevue Volvo on 07/23/2025 to see what was wrong with the vehicle and they said the pistons were bent.

EQUIPMENT — Filed 05/22/2025

The contact owned a 2015 Volvo XC60. The contact stated that while driving on a main road at 25 MPH, when a message was displayed on the instrument panel that stated "Engine Performance Degraded" and the vehicle experienced a significant reduction in automotive power, the contact proceeded to pull over and a few moments later smoke was emitted from the front end of the vehicle, the contact immediatley exited the vehicle and shortly afterwards the vehicle was engulfed in flames. The contact mentioned that the vehicle was serviced at the dealer prior to the fire. The origin of the fire was unknown. The vehicle was unoccupied during the fire. The location of the fire was the front passenger side of the engine compartment. The fire department arrived to extinguish the fire. A fire department report was filed. A police report was not filed. The vehicle was destroyed. The manufacturer was not notified of the failure. The approximate failure mileage was 108,000.

ENGINE — Filed 05/04/2025

My engine always continues to break down even after changing engine twice.

Chest Clip, Buckle, Harness — Filed 02/02/2025

Chest clip is magnetized to assist with closing the clip - my clip does not stay latched shut, pops open at a slight push. I have another one of these seats, manufactured at a later date, and the chest clip needs the buttons pushed to open, so I know this is incorrect. Chicco does not feel the need to replace the seat, said they will send me a new retainer clip. If there was an option to attach a video to this complaint, I would.

ENGINE AND ENGINE COOLING,EQUIPMENT — Filed 11/05/2024

The contact owns a 2015 Volvo XC60. The contact stated that every three weeks an oil change was performed on the vehicle. The contact stated that low oil level or oil empty messages were displayed. The vehicle was taken to the dealer who confirmed that the vehicle was consuming 15-quarts of engine oil every 6,000 miles driven. The dealer determined that oil was leaking into the pistons. The dealer stated that the pistons and piston rings needed to be replaced. The contact learned of an extended warranty coverage under NHTSA ID Number: 10234800 (Equipment). The vehicle had not been repaired. The manufacturer was made aware of the failure. The manufacturer confirmed that the vehicle was not covered under NHTSA ID Number: 10234800 (Equipment) extended warranty coverage due to the vehicle exceeding the mileage limitations. The approximate failure mileage was 111,000.

ENGINE — Filed 07/14/2024

Volvo mechanics claim the engine seized due to alternator pulley failure, however, at the time of the event, the engine showed no oil on the dipstick despite having added multiple quarts of oil over the last three months. Volvo has issued an extended warranty letter to customers due to excessive oil consumption, but Volvo failed to provide this letter for this vehicle. I’ve checked Volvo databases for engines matching this extended warranty and confirmed the engine is in fact covered under this extended warranty. Due to Volvo’s failure to communicate this problem, my daughter continued to drive this vehicle until it completely lost power in high speed traffic on I-95 nearly causing an accident and stranding her on the side of the interstate for several hours. Upon arriving at the cite of this incident, I notice there was no low oil warning light illuminated on the dash, so I double checked oil dipstick and added at least two quarts of oil. Unfortunately the engine had already seized at this point and the vehicle was inoperable.

ELECTRICAL SYSTEM — Filed 04/17/2024

Vehicle failed to start after short trip (<5 miles) with no electrical power present. Jump started from another car after approximately 1/2 hour. Drove car to home, car stalled in driveway again with no electrical power. Replaced 5 year old battery car started fine then stalled on road during test drive while approaching an intersection and suffered loss of all electrical power including inoperative hazard flashers. Transmission went into park and car could not be moved out of active traffic lane. Car towed to repair shop where cracked fuse at positive battery terminal found (see photos attached). Repair shop contacted a Volvo dealer and was informed they typically see a couple vehicles a week for same issue.