Nissan Versa Investigations
NHTSA Office of Defects Investigation records
Pedal Operation Interference
On August 11, 2015, Nissan North America, Inc., submitted a Defect Information Report (DIR) describing a condition that may impede the driver's ability to transition quickly and smoothly from the accelerator pedal to the brake pedal in certain model year (MY) 2012 through 2015 Nissan Versa Sedans and MY 2014 through 2015 Nissan Versa Note vehicles (NHTSA Recall No. 15V-507).According to Nissan's DIR, in certain circumstances related to driver foot position and shoe type, the right edge of the driver?s shoe may catch the edge of the center console lower trim panel.Nissan indicated that this condition could cause a slight delay in the smooth transition between the accelerator pedal and the brake pedal which may increase the braking distance; therefore increasing the risk of a crash.Nissan's recall instructs dealers to trim the console panel so that the leading edge is at a greater distance from the driver?s foot.Nissan had previously issued a service campaign (Nissan Campaign ID #P5308; TSB #NTB15-033) on April 16, 2015, to provide the remedy for the same set of vehicles before deciding to change the program to a safety recall.Of the approximately 421,305 vehicles covered by recall 1
Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators us
Reduced Power After Engine Stall
The Office of Defects Investigation (ODI) opened this investigation on March 7, 2024, after receiving twenty (20) consumer complaints and multiple field reports describing reduced power (limp mode) after re-starting the vehicle following a stall on certain 2022-2024 model year (MY) Nissan Versa.  A Preliminary Evaluation was opened to gather information and assess whether the subject vehicles contain a safety-related defect. During this investigation, Nissan explained that certain 2022-2044 MY Nissan Versa vehicles equipped with a manual transmission may, under specific conditions, experience a Malfunction Indicator Light (MIL) along with reduced engine performance following an engine start-up after a stall. In certain conditions, if the vehicle stalls and an engine restart occurs within five (5) seconds, the vehicle will enter a fail-safe mode with limited engine torque. The fail-safe mode helps prevent damage to the engine, a complete loss of motive power, and allows the driver to maintain control of the vehicle. ODI reviewed over 180 incidents where drivers described entering a limp mode following a vehicle re-start after having stalled the vehicle. Review of these incident
About NHTSA Investigations
NHTSA investigations include Preliminary Evaluations (PE), Engineering Analyses (EA), Defect Petitions (DP), and Audit Queries (AQ). Investigations may lead to recalls if defects are confirmed. An open investigation means NHTSA is actively examining the issue.