2022 Chevrolet Suburban Complaints

ENGINE — Filed 07/07/2026

Driving down XXX going back home was driving normal when suv shut off on freeway with no warning what so ever i was 12 hours away from home almost crashed into bridge side wall was stranded on side of freeway with my whole family n my new born baby in the heat motor locked up per dealer 74k miles had to pay tow truck n a rental to get back home INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN — Filed 04/07/2026

I own a 2022 Chevrolet Suburban with approximately 115,000 miles. While driving, the check engine light illuminated and the vehicle suddenly entered limp mode. The transmission lost normal operation, including reverse gear, significantly limiting the vehicle’s ability to operate. The failure occurred without warning and created a potential safety concern because the vehicle could no longer respond normally to driving conditions. The vehicle was inspected by a Chevrolet dealership, where technicians diagnosed a failed transmission control valve body and confirmed the valve body required replacement. I paid to have the repair completed. After the repair, I learned that GM issued Special Coverage N242454441 for certain 2021-2022 Chevrolet Suburban vehicles equipped with the same transmission. The bulletin describes premature transmission control valve wear that can cause a service engine light, reduced engine performance, harsh shifting, and requires replacement of the transmission control valve body. My vehicle experienced the same failure and required the same repair, but my VIN was not included in the covered population. I contacted GM before authorizing the repair and requested assistance, but my request was denied because my VIN was not included in the special coverage. I am submitting this complaint because my vehicle experienced the same transmission valve body failure identified by GM despite not being included. I request that NHTSA document this failure and determine whether additional vehicles equipped with the same transmission should be included in any current or future safety investigation.

FUEL/PROPULSION SYSTEM — Filed 06/15/2026

Vehicle was recalled for loss of propulsion.Pico test was done ,changed oil.6,000 miles later engine locked up on freeway.Engine is in for replacement.2022 suburban 6.2 liter 66,000 miles

POWER TRAIN — Filed 05/15/2026

UNKNOWN TRANSMISSION ISSUES MENTIONED IN OTHER RECALLS FOR SAME PERIOD/MAKE MODEL AS LISTED YET MY VIN was not, as a mother 4 little ones I need my vehicle to perform as it was design to, the cost for this repair is over 6,000.00 I have already invested over 40,000 since I brought it. I feel they ought have included my car on this recent recall they had to have known this problem was of their why else would there recalls. I still must pay monthly for a vehicle that does perform as it should. This impacts my ability to provide for the needs of my children. I hope relief is on the way.

ELECTRICAL SYSTEM — Filed 06/14/2025

The telecommunications module for vehicle GPS and OnStar emergency services failed after a factory software update. Now the vehicle has no GPS location, information emergency OnStar services or the ability to access vehicle Telematic via cell signal or an app. Dealer refused to cover the item under the 36 month bumper-to-bumper warranty leaving the consumer stuck with a $2000 cost just to have GPS in the vehicle and maintain contact with emergency services through OnStar.

ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES — Filed 07/01/2025

The contact owns a 2022 Chevrolet Suburban. The contact stated that the vehicle was taken to the local dealer for painting services. Upon retrieval of the vehicle, the service drive assist message was displayed. The doors failed to lock. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. Additionally, the contact contacted a lawyer. The failure mileage was approximately 28,000.

POWER TRAIN,UNKNOWN OR OTHER — Filed 03/21/2026

While driving down the high way with the check engine light on, a message appeared on the screen and said “unable to shift soon. Service transmission immediately.” After driving a few more miles the vehicle shifted to neutral, and then as soon as I got on the shoulder of the highway and slowed to approximately 5 mph, the vehicles wheels locked up and the car jerked aggressively into park. This exact issue has occurred multiple times while driving. It is unsafe to drive the vehicle.

POWER TRAIN,WHEELS — Filed 04/12/2026

Having reviewed online your safety recall number N252536750, I am experiencing the same issue (right rear wheel occasionally locks when starting from a standstill and turning right). It only lasts about 1 or 2 seconds while accelerating. However, when I discussed this with my Chevrolet Dealer, I was told that according to the VIN for my 2022 Suburban 3.0L Diesel, I am not part of that recall. I plan to take it to the Chevrolet Dealer very soon for more analysis. However, I wanted to bring this to your attention, as it could be hazardous. I have not gotten any dash warning messages. Thank you.

ENGINE — Filed 01/05/2026

My 6.2L engine failed on 1/6/26 due to a OEM bearing issue. The vehicle was inspected and engine had to be replaced after the recall and service were done. The vehicle stalled while doing 30 mph on a local road. No warning lights or problems were observed or detected prior to the incident.

ENGINE — Filed 04/17/2026

6.2l engine was losing power in Oct 2025. Took to dealership to address L87 recall. Oil change was completed and recall was closed. In March 2026, vehicle lost full power while driving on highway with other traffic. Vehicle was towed to dealership. Battery replaced. April 2026, vehicle lost power again on highway with traffic. Vehicle towed back to dealership. Both incidents inbolved children in the car and the vehicle was unresponsive and two crashed were narrowly avoided. GM notified. Case No.XXX This is related to NHTSA Recall Query XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)