2023 Chevrolet Tahoe Complaints

ENGINE — Filed 09/27/2026

I was picking my Tahoe up after a replacement on the blown motor was complete. (L87) I started it and immediately knew something was wrong. I reported it to the service advisor and the response was there were no warning lights so it must be fine. I asked them to sit in my car and they agreed it was not running right. They took it back and replaced a sparkplug that was causing the #2 cylinder to misfire. Almost 3 months later I was driving on the freeway when my Tahoe felt like it was going to stall. Again I had no warning lights appear. The diagnostics showed the same #2 cylinder misfiring caused by another sparkplug issue. This is all within 2,500 miles on a brand new engine.

ENGINE — Filed 02/03/2024

First occurrence was 2/03/24 check engine light came on felt stumble in engine continued driving to get home set up appt with dealership. They codes P318C and P318F were present numerous things were checked and found excessive crank shaft end play, removed oil pan and found thrust bearing in bottom of pan broken into pieces. GM authorized engine replacement. The vehicle had 4,603 miles on it. Repairs were completed and vehicle picked up 03/12/24 Second occurrence was 05/28/26 while driving at interstate speeds heard squeaking noise then knocking sounds coming from engine was able to make it home and had vehicle towed to dealership the next day. This time no codes but was determined to be defective engine and was replaced again mileage on vehicle this time was 33,521 miles I started using the 0w/40 oil as soon as recall came out actually before I received information in mail I am hearing rods rattling at start up now until oil pressure picks up on the latest engine installed but it still is running at present time.

POWER TRAIN,ENGINE,FUEL/PROPULSION SYSTEM — Filed 10/02/2026

While traveling on I-684 at highway speed, my 2023 Chevrolet Tahoe with 43,000 miles suddenly shut off without warning and automatically shifted into neutral. I had a complete loss of propulsion. As a car guy who has been following the GM 6.2L engine recall issue, I suspected it could be that. I was traveling in the left lane and had to carefully coast across active lanes of traffic to reach the shoulder. My wife and two young children were in the vehicle, and the sudden loss of propulsion created a significant risk of collision. There were no warning illuminations, messages, or other symptoms that I observed prior to the failure. The vehicle was subsequently towed to my Chevrolet dealer for diagnosis and is available for inspection upon request. As confirmed by the dealer, the engine completely seized causing the loss of propulsion. I will also share, about 1 year ago after the GM recall was issued, I took my truck back to the dealer. They cleared the engine for the propulsion issue, changed the oil for 0W40 and changed the oil fill cap in line with GM recall standards.

UNKNOWN OR OTHER — Filed 03/01/2023

Since the vehicle was new in 2023 we have had constant issues with the park aid cameras. One of the mirrors goes out all the time, the infotainment image flickers pick or is just straight black with a red x and no camera image that you can’t even escape out of to get back to the vehicle controls when your back in drive. I had it to the dealer about 6 months after I bought it and allegedly threw everything at it including the kitchen sink. Worked for awhile and then started again. Had it back to the dealer nov of 25, kept it for 4 months, replaced a camera and it’s been broken since I picked it up intermittently.

POWER TRAIN,ENGINE — Filed 09/26/2026

* Lifter bores and camshaft. yes * The vehicle started to shake and started sending out alerts for multiple problems while we were driving on the interstate * Yes. Bale Chevrolet estimated approx. $10,000 repair bill * No. It's currently at the dealership * As the car began to shake we started receiving numerous warnings, but not prior to the shaking.

POWER TRAIN — Filed 06/20/2026

[XXX] Diagnose on XXXX vehicle shudder dealer stated felt some tire vibration. Back to the dealer in August same issue. Tahoe shudder and misfiring first seen by [XXX] chevy of [XXX] on XXX stated it the DFM and its very pronounced. There is no correction that can be made to change this shudder. XXX service transmission, not able to shift soon warning light came on while driving down the road multiple times. Dealership stated caused by low voltage charged battery and sent me on my way. went back and GM had them to check battery over again and again and they finally replaced my battery. XXX back in the shop at Bentley Chevrolet Florence AL. kept 2 weeks. Stated shudder is a normal operation from the GM tech. also received a misfire code as it clearly is missing while at idle it almost acts as if its going to go dead at a red light. tach case # XXXBentley tech stated that GM reviewed data their response was this is a normal operating condition. This vehicle has only 23,000 miles its a 2023 Tahoe z71 and still under the powertrain warranty, but they refuse to fix the misfire acting like its going to go dead at a red light. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN — Filed 09/19/2026

I am filing this safety complaint regarding the sudden and unexpected transmission failure of my 2023 Chevrolet Tahoe at approximately 110,000 miles. My transmission failed without any warning, creating a serious and frightening safety concern. There was no advance indication that I was about to experience a major mechanical failure. A transmission failing unexpectedly creates the potential for an extremely dangerous situation, particularly when traveling at highway speeds, navigating intersections or driving in heavy traffic. I purchased this vehicle brand new and have consistently had it serviced at Bergstrom Chevrolet of Madison. My maintenance history includes approximately 20 dealership visits between January 2023 and July 2026. Despite this extensive service history, the transmission failed less than four years after I purchased the vehicle. I am extremely concerned that such a critical component could fail without warning. An unexpected transmission failure can put the driver, passengers and surrounding motorists at risk, particularly if the vehicle suddenly loses its ability to accelerate or maintain speed. The Chevrolet dealership diagnosed the transmission failure and provided an estimate of approximately $7,500 for replacement. I contacted General Motors to report the failure and request assistance. GM denied my request solely because the vehicle had exceeded its warranty mileage. When I asked whether the decision could be appealed, I was told no appeal was available. My primary concern is the safety implications of this unexpected failure. I believe this incident warrants investigation to determine whether other owners of 2023 Chevrolet Tahoes may be at risk of experiencing similar transmission failures without warning. I am requesting that NHTSA review this incident and determine whether a potential transmission safety defect exists.

ELECTRICAL SYSTEM — Filed 09/11/2026

My vehicle received a software update which has caused my OnStar (safety) option to malfunction and has stopped working properly. There is an active recall for some vehicles but for some reason my specific year is not listed as one of the years for recall but has the exact issue.

POWER TRAIN — Filed 08/17/2026

Water pump failed. The part is on back order with an ETA of October 29. Vehicle is currently at the dealership. I received no alerts before failure.

ENGINE — Filed 08/28/2026

I am submitting this complaint regarding my 2023 Chevrolet Tahoe equipped with the GM 6.2-liter V8 engine. VIN: [XXX]. At approximately 40,000 miles, the original engine experienced a major failure and was completely replaced by a Chevrolet dealership under warranty. I have now driven fewer than 10,000 miles on the replacement engine and am experiencing a very similar engine-related problem again. The vehicle is currently back at the Chevrolet dealership being inspected and repaired. This is extremely concerning because the original engine failed at only approximately 40,000 miles, and the replacement engine has developed a similar problem after fewer than 10,000 miles. The GM 6.2-liter V8 has been the subject of numerous reported engine problems and complaints, and I believe this repeated failure warrants NHTSA’s attention. I am concerned there may be an underlying or recurring defect affecting these engines that has not been adequately addressed. I am also concerned about the potential safety implications of an engine or valvetrain failure while driving. An unexpected loss of power or significant mechanical failure could create a dangerous situation, particularly at highway speeds or in traffic. I can provide dealership documentation showing the original engine replacement, the mileage at which it occurred, and the current repair visit. This documentation establishes that the vehicle has experienced significant engine-related problems twice within a relatively short period, including a similar problem with the replacement engine after fewer than 10,000 miles. I respectfully request that NHTSA document this complaint and review whether there is a broader pattern of premature or repeated failures involving the GM 6.2-liter V8 used in 2023 Chevrolet Tahoe vehicles and whether further investigation or corrective action is warranted. Replacing the original engine did not resolve the issue, as the replacement engine has now developed a similar problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 06/24/2025

The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and was unable to restart. The message "Engine Overheating - Stop Driving Immediately" was displayed. The vehicle was towed to the dealer, who determined that the engine had failed, and the engine was replaced. The manufacturer was notified of the failure by phone. The failure mileage was 32,295.

ENGINE — Filed 08/20/2026

We were driving on the highway and the engine started making a ticking noise and AFM light came on. Took the car to the dealership for inspection and they said the lifter had collapsed and it would cost $1000 to tear the engine down to see if the camshaft was damaged. Asked for the estimate to replace camshaft and lifters and they quoted $10,000.

ENGINE — Filed 09/14/2026

Our Tahoe was included in the recall. The dealership inspected it, found no issue at the time, and told us to switch to a different oil viscosity, which we did. This vehicle has only ever been serviced at a Chevrolet dealership. On August 20th, while driving on the highway, the engine shut off without warning and we had to coast to the shoulder. We attempted to restart it several times, but the engine would not hold an idle. After shutting off all accessories, including the A/C and radio, the vehicle finally started. We brought it back to the dealership for inspection, and once again they could not find any issue. Today, September 14, 2026, we heard loud clanking coming from the engine. We pulled over immediately and had the truck towed to the dealership. At this point, we believe the engine is no longer serviceable and will need to be replaced. We do not believe the change in oil viscosity is an adequate fix for the 2022 to 2024 6.2L engines covered under the GM recall, including the one in our Tahoe. An engine dying without warning at highway speed is a serious safety hazard, and we were fortunate it didn't end in a collision.

ENGINE — Filed 09/03/2026

The contact owns a 2023 Chevrolet Tahoe. The contact stated there was a misfire in the engine, with the engine warning light illuminated. The message “Collision Mitigation System Off” was displayed. There was a burning odor coming from the vehicle after the failure. The vehicle started shaking abnormally. The vehicle was taken to the local dealer, where it was diagnosed and determined that the lifter and crankshaft needed to be replaced. The contact purchased a rebuilt engine, and the engine was replaced at another service center. The failure mileage was approximately 82,000.

ENGINE — Filed 06/10/2026

Hard shudder when driving between 45 to 50 mph and when you decelerate around 12 to 15 mph. Inspected at Lond Lewis Chevrolet stated and now being inspected by Bentley Chevrolet due to Lond Lewis Chevrolet doing absolute nothing. Tahoe has 23,000 miles currently. Bought new one owner always serviced as should.

ENGINE — Filed 09/07/2026

1 week and 1 day later we are stranded again on the side of highway going full speed in our Tahoe. We took it to two different certified Chevy dealerships and they gave us a vague resolution and this issusr is not fixed at all. Our engine is locking up on us at full speed on the highway. This vehicle has 83,000 miles on it and we’ve maintained this vehicle very well.

UNKNOWN OR OTHER,ENGINE,FUEL/PROPULSION SYSTEM — Filed 08/29/2026

We were driving full speed down the highway and the vehicle completely shut down steering wheel locked and we were stranded for six hours. Turns out the dealer said it was just the battery and they fixed the grounding of the battery. I’m sorry but I’m not satisfied with this response. I’m scared to drive this vehicle.

ENGINE,FUEL/PROPULSION SYSTEM,FORWARD COLLISION AVOIDANCE — Filed 08/27/2026

A couple weeks ago, the truck suddenly started running rough and the front collision avoidance system failure message displayed. Immediately took it to the dealership. Computer read out showed #7 fuel injector failed. Repaired and was fine. Yesterday, 8/27/26, same thing happened again. Immediately went to the dealership. Now #4 fuel injector failed. Service manager just called and states that Chevrolet does not have that injector and on backorder with no date of expected delivery. No other Chevy dealer has #4 fuel injectors either. Tells me that there is an overwhelming demand for fuel injectors that indicates a defect. Meanwhile, the truck is out of service and GM is not addressing the issue to replace all the defective injectors.

ENGINE AND ENGINE COOLING — Filed 08/28/2026

The contact owns a 2023 Chevrolet Tahoe. The contact stated that the vehicle was taken to a dealer, where the NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling) remedy was completed with an oil change and oil cap replacement. Approximately three months later, while the contact's wife was driving approximately 45 MPH, the engine stalled. The driver was able to coast to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the engine had failed. The engine was replaced. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 22,000.

POWER TRAIN — Filed 10/01/2025

I am writing to express my disappointment with how the L87 engine recall was handled on my 2023 Chevrolet Tahoe. I purchased this vehicle for approximately $82,000 and brought it to Kunes Chevrolet in Lake Geneva multiple times for scheduled maintenance. During my first visit after learning of the recall involving potential connecting rod and crankshaft defects, I specifically asked when my vehicle would be inspected and repaired. I was repeatedly told that I would receive additional information in the mail and that I would be contacted when repairs became available. Over the course of several oil change visits, I continued to ask about the recall. Each time, I received essentially the same response. During my most recent visit, I was informed that when the recall procedure became available, the dealership would listen to the engine with a stethoscope and then determine whether the vehicle required repairs or only a switch to a heavier oil viscosity. As a customer who invested $82,000 in a full-size SUV, I found that response extremely disappointing. The recall concerns involve engine components that could potentially lead to catastrophic engine failure. Being told that the solution may simply be listening to the engine and installing thicker oil did not inspire confidence in the long-term reliability of the vehicle. Ultimately, my confidence in both the vehicle and the handling of this recall deteriorated to the point where I no longer felt comfortable taking long trips with my family. I made the difficult decision to trade the vehicle in less than two years after purchase, resulting in an approximately $26,000 financial loss. I believe customers who invested significant amounts of money in these vehicles deserved clearer communication, a more proactive response, and a solution that restored confidence in the product. Unfortunately, my experience left me with serious trust concerns regarding both this recall process and General Motors' customer commitment.

UNKNOWN OR OTHER — Filed 01/01/2026

ONSTAR module does not work. GM dealership claims the hardworking malfunctions and needs replacement for $800. Onstar is advertised as a safety feature that is now unable to be used.

STEERING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING — Filed 08/31/2025

My 2023 Chevrolet Tahoe LS has experienced repeated service issues within the first year of ownership. The vehicle has been in the repair shop five separate times and out of service for approximately five months total. Due to extended repair periods, the mileage remains extremely low. A primary concern involved the steering system. The steering wheel was noticeably off-center while driving straight, requiring continuous correction to maintain proper lane position. Steering-related components were inspected and replaced. There were no warning lights present at the time. However, improper steering alignment raised safety concerns regarding vehicle tracking and stability. The vehicle has been inspected and repaired by authorized service providers. I am submitting this complaint to determine whether this reflects a broader safety-related issue with this model year.

ELECTRICAL SYSTEM,ENGINE — Filed 09/03/2024

The contact owns a 2023 Chevrolet Tahoe. The contact stated that soon after purchasing the vehicle, the vehicle's lane assist feature would be active with no other vehicles in the contact vehicle's vicinity. The contact also stated that multiple other electrical defects would occur such as the backup camera activating while in drive(D), the instrument panel intermittently going blank, and various other defects. The vehicle was taken to the dealer on multiple occasions where they failed to duplicate the failure. The contact then stated that while driving at 80 MPH, the instrument panel went blank. The contact attempted to pull the vehicle over; however, an unknown turn-off of the vehicle warning message appeared on the instrument panel as a warning chime was also emitted from the vehicle. The contact then stated that the vehicle then came to an abrupt stop where the engine and brakes seized, while traveling at 34 MPH. Due to the failure, the contact was taken to the hospital where they were treated for whiplash, inflammation in the neck and spine, 7 bulging discs in the spine, and pain in various parts of the body. The vehicle was towed to a dealer where it was diagnosed with engine failure; the vehicle's engine was replaced under warranty. Despite the repair, the contact refused to take possession of the vehicle as they did not feel safe driving the vehicle. The manufacturer was notified of the failure and a case was filed; the contact had yet to receive any assistance from the manufacturer. The failure mileage was approximately 15,000.

AIR BAGS,FORWARD COLLISION AVOIDANCE — Filed 11/21/2024

Vehicle 1 pulled out into Vehicle 2s lane and cut them off causing Vehicle 2 to slam on the breaks causing My vehicle ( Vehicle 3 ) to collide into the back of vehicle 2. No emergency breaking a-curd and no airbags deployed durring contact at rate of speed of 45-60MPH. Total damage to Vehicle 2 rear end and total damage to vehicle 3 front end.

ELECTRICAL SYSTEM,SERVICE BRAKES — Filed 01/15/2024

Bought new and there was a brake pad sensor message immediately that we took it to the dealer several times for and nothing was done other than clearing the code and giving it back. Was in accident 1/24 and it was found that there was a frayed/damaged wire in the break module and break pad sensor that I feel could have led to the accident