2021 Ford Ecosport Complaints

SUSPENSION,WHEELS — Filed 07/03/2026

Unknown how it happened. After parking noticed back driver side tire was tilted. Took picture next morning under car to see that the cross arm was broken in half. Car was not drivable and was towed to a Ford dealership Seems like arm just snapped without notice.

ENGINE — Filed 07/18/2026

Oil low pressure,oil pump is not working

ENGINE — Filed 09/01/2025

Manufacturer has delayed repaired vehicle under campaign 23V905. Loss of use / unable to use this unsafe vehicle. It has been at the dealership and supposedly awaiting parts since September 2025. Manufacturer’s customer service people cannot provide additional details around delivery dates. Customer service both at the dealership and manufacturer have been polite; however, the dealer has provided no remedy or assistance and the manufacture’s customer service line has admitted to providing misinformation that caused additional financial hardship in order to dispose of a call. At this point, we would welcome any reasonable remedy from the Ford Motor Company in order to either repair and remunerate.

STEERING,SERVICE BRAKES,ENGINE — Filed 03/23/2026

Safety Recall 23S64 was completed on my 2021 Ford EcoSport on approx. Oct 19, 2025. After ~15,000 miles, the same system failed again on [XXX], causing loss of power and loss of braking assist. Fredericktown Pettus Ford diagnosed shredded timing belt material, drained the oil, and removed the catalytic converter (placed in trunk). They were respectful and tried to order a replacement engine, but Ford Motor Co. blocked their access to the system. The vehicle has now been out of service for over 3 months, and we have paid for two ~100‑mile tows because Ford refused to authorize repairs or provide a loaner/rental after a second engine failure. On June 18 the car was towed to Bommarito Ford, who falsely accused us of “destroying the car” and removing the catalytic converter, despite written confirmation from Pettus Ford that THEY removed it during diagnosis. Bommarito refused recall work, claimed the car was “out of warranty,” and ordered us to remove it from their lot or face storage fees. Ford Corporate opened cases [XXX] and [XXX]. The second rep was rude, accusatory, did not return calls, and repeated false claims. Ford denied coverage using a 12k‑mile parts warranty, even though this is a federal safety recall. Ford Corporate also misidentified the owner and listed my vehicle incorrectly as a “Ford Edge.” After notifying Ford Executive Office, Tier 2, the Missouri Attorney General, and legal counsel, Pettus Ford’s access to Ford’s system was suddenly restored. Pettus Ford continued to help, but Ford still refused to authorize the repair. We have now towed the car back to Pettus Ford in Fredericktown, MO. We have been without a vehicle for nearly 4 months and have spent significant time and money on towing. Ford only began to respond after the Missouri Attorney General complaint and after Ford Corporate threatened legal action instead of providing assistance. Pettus Ford has been the only party acting professionally throughout this:INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE — Filed 03/20/2026

Engine failed after repair of15000 miles with same break down The dealership did not clean out shredded timing belt and the second belt was shredded

POWER TRAIN,ENGINE — Filed 06/04/2026

Car had an interim engine placed in March 2024, for Ford recall 23S64. Then car stalled again in May 2026, took in it to have it checked and they repaired the engine and replaced the catalytic converter as per Ford recall 23S64. We replaced at our cost ther cam sensors. 7 days after picking up the vehicle, it shut down in the middle lane of the Southfield Freeway causing a safety issue to me and those around me. One the vehicle was safely on the side of the road thanks to some construction workers, I called for a tow. After 30 minutes I tried to start the car and it did not start. After 40 minutes the car started AAA and I was able to get it to Dean Seller Ford if Troy. They refused to check the work the did week prior and are saying that they can not test it until we replace the battery and starter. You don't need those to visually inspect. I do not feel the car is safe to drive at this point as it is a huge safety risk to myself and drivers around me

SERVICE BRAKES, HYDRAULIC,AIR BAGS — Filed 05/27/2026

The contact owned a 2021 Ford EcoSport. The contact stated that while driving approximately 25-30 MPH, the vehicle ahead applied the brakes. The contact then depressed the brake pedal; however, the brakes were inoperable, causing the vehicle to rear-end the vehicle in front. The contact further stated that the parking brake was applied but was also inoperable. The contact stated that the vehicle sustained front-end damage, including impact to the center of the bumper, radiator damage, and hood intrusion into the engine compartment. The other vehicle sustained damage to the trunk and rear bumper. The airbags did not deploy, and no warning light illuminated before or during the incident. The vehicle was towed to the contact's residence and was later towed to a junk yard. The vehicle was deemed a total loss by the insurance company. No injuries were reported. The dealer was contacted, but the vehicle was not diagnosed or repaired. The Ford App indicated that during and after the crash, the app alerted that there was an issue with the vehicle; however, it could not be tested since the vehicle was totaled due to the failure not being covered by the manufacturer. The manufacturer was not notified of the failure. The approximate failure mileage was 98,000.

ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,FUEL SYSTEM, GASOLINE — Filed 03/12/2026

The contact owns a 2021 Ford EcoSport. The contact stated that while driving at unknown speeds, the vehicle stalled. The vehicle restarted after 20 minutes. The Check Engine warning light was illuminated. The "Charging System Failed" message was displayed. The vehicle was previously taken to the local dealer for NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) recall repair. The vehicle was taken back to the local dealer, where it was diagnosed with needing the EVAP purge system replacement. The vehicle was repaired; however, the Check Engine warning light illuminated while leaving the dealer. The vehicle was taken to the same dealer, who informed the contact that a diagnostic test was needed, and that there was no warranty coverage. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 60,688.

STEERING,POWER TRAIN,ENGINE — Filed 05/22/2026

Manufacturer issued a recall with no remedy. The vehicle stalled and loss power will I was driving on the highway in June 2025. The vehicle was taken to an authorized dealership for a safety recall regarding this issue. The manufacturer and dealership held my vehicle for 11 months to complete the repair. However, just 5 days after receiving the vehicle back, the engine shut off again while I was driving. The vehicle stalled while driving at approximately 25mph on a highway exit. There was no warning prior to the engine shutting off. The vehicle remains unremedied and unsafe to drive. The manufacturer has failed to repair the defect within a reasonable timeframe, keeping the vehicle out of service for nearly a year.

ELECTRICAL SYSTEM,ENGINE,FUEL/PROPULSION SYSTEM — Filed 05/22/2026

After having to have my vehicle towed to & held by the dealership for a total of 3 months altogether over the course of two separate engine rebuilds due to a national recall on faulty oil pump parts, my vehicle's check engine light came on & gave a message that there was an issue with the emissions system. I am now experiencing multiple engine system faults EVERY SINGLE TIME I refuel my vehicle where my engine will not start until after 10+ attempts & now that the weather is hotter, I'm also experiencing engine system faults while driving in town & on the highway where the engine completely shuts down & I lose all power, including steering power, while I'm driving! The system instructs me to put the car in park, turn the key to the off position & restart the vehicle WHILE I'M STILL TRYING TO MANUEVER TO SAFETYWITH ZERO POWER IN THE MIDDLE OF THE ROAD/HIGHWAY! I was almost hit by other vehicles multiple times! This vehicle is my only source of transportation but it is wholly dangerous & totally unsafe to drive!