2020 Tesla Model 3 Complaints

UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE — Filed 07/16/2026

Car was sitting at a red light while in Full Self Driving (supervised). The screen showed at least four red lights. Suddenly the car started to move forward while the lights were still red. I was able to stop it from going further. This has happened before and I reported it then. If I had not had my foot near the brake pedal the car might have just run through the light.

STEERING,VEHICLE SPEED CONTROL,SERVICE BRAKES — Filed 07/11/2026

On July 11 at approximately 6:47 a.m., I was operating my Tesla Model 3 on Interstate 65 in Hart County, Kentucky, with Full Self-Driving (FSD) engaged during normal highway travel. Approximately one hour earlier, I had departed a highway rest area after sleeping from the previous day’s travel. Rain developed during the trip, but I observed adequate visibility, apparent roadway traction, and I was not impaired. I was traveling in the far-right lane of a three-lane interstate. The posted speed limit was approximately 70 mph; however, FSD limited the vehicle to approximately 65 mph and displayed warnings indicating that the higher speed was unavailable. While FSD remained engaged, the system initiated a lane change from the far-right lane into the center lane. After entering the center lane, the vehicle began displaying repeated warning messages and FSD disengaged multiple times. I attempted to locate settings related to the warnings on the touchscreen but could not identify an available adjustment. During the third disengagement, I perceived that the vehicle continued braking without releasing while steering resistance increased significantly. The steering wheel then rotated abruptly, and I was unable to regain normal directional control before the vehicle departed its intended travel path and struck a concrete median. The collision caused personal injuries and substantial vehicle damage. I have not been able to reproduce the condition. The incident was investigated by the Kentucky State Police. Based on the sequence of repeated FSD warnings, disengagements, continued braking, and abrupt steering behavior, I believe this event warrants investigation. I request that NHTSA review the vehicle’s Full Self-Driving logs, telemetry, Event Data Recorder (EDR) data, steering and braking commands, diagnostic records, and software history to determine whether a vehicle or software malfunction contributed to the collision. Almost like someone had control, into the wall -KM

SUSPENSION — Filed 07/11/2026

Suspension defects, control arm noise, vibration, .

STEERING,LANE DEPARTURE — Filed 06/16/2026

On XXX at approximately 5:00 PM, I was driving my 2020 Tesla Model 3 on [XXX] from [XXX] toward [XXX], with Tesla FSD engaged. Near the area where the center divider begins/ends, the vehicle crossed the double yellow/divider area and entered the opposing traffic lane. There was no oncoming traffic at that moment, so there was no crash, but this created a serious potential head-on collision risk. The car also did several hard jerks that aggravated my neck and back that it has been consistently doing for a long time which cause worse ongoing headaches. The system/component that malfunctioned was Tesla FSD/Advanced Driver Assistance, including lane keeping/steering behavior. The vehicle is available for inspection upon request. My safety and the safety of others were put at risk because the vehicle moved into the lane for oncoming traffic. I had to intervene and no longer feel safe using FSD. I have reported unsafe FSD behavior to Tesla multiple times before, but the issue has not been resolved. Tesla service has previously listed the concern as “FSD not working properly/test drive required” and/or general diagnosis, but I have not received a clear written resolution explaining why the vehicle crossed into the opposing lane or how Tesla will prevent this from happening again. There were no warning lamps or messages that I recall before the vehicle crossed into the opposing lane. If Tesla has vehicle logs or telemetry for the incident, I request that they be reviewed. I am reporting this because the vehicle may repeat this unsafe behavior and create a head-on collision risk. The car continues to behave unsafely and erratically. i have a log of some of the incidents. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM,EXTERIOR LIGHTING — Filed 04/02/2026

The wiring in my trunk harness was severed due to the repeated opening and closing of my trunk. This caused my reverse lights to fail and my trunk latch to stop working. This issue is part of a known recall: Campaign 21V-00D. Tesla attempted to fix the issue in 2023 but the poor repair did not work. I took my Tesla to the dealer and they refused to remedy the issue unless I would pay $1300. I persuaded them to lower the feet to $300 but still feel that I should not pay anything because this issue was due to the recall.

SUSPENSION — Filed 01/01/2025

The contact owns a 2020 Tesla Model 3. The contact stated that while driving at an undisclosed speed, there was a clinking sound coming from the front of vehicle. No warning lights were illuminated. The contact stated that the dealer was contacted, and a repair was pending on the lower lateral link. The contact stated that the VIN was not included in NHTSA Campaign Number: 21V835000 (Suspension). The contact associated the failure with the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

UNKNOWN OR OTHER,LANE DEPARTURE — Filed 06/22/2026

Subject: Tesla HW2 FSD – Advertised Safety/Autonomy Features Not Provided Description: I am reporting an issue regarding my 2020 Tesla Model 3 equipped with Hardware 2 (HW2) and Full Self-Driving (FSD) package. Although the vehicle is listed and sold as “FSD capable,” Tesla has stopped providing FSD software updates for HW2 vehicles. My vehicle is stuck on FSD version 12.6.4 and cannot receive newer versions (v12.7, v12.8, v13, etc.). Tesla continues to advertise FSD as an evolving safety and autonomy system, but HW2 vehicles are no longer receiving the required updates to maintain or improve safety functions. This results in: • Safety-related features not being updated • Autonomy features advertised at purchase not being delivered • OTA updates being discontinued without notice • Tesla refusing to provide a hardware upgrade path (HW3) despite FSD being purchased on this VIN This creates a safety concern because the vehicle is operating with outdated perception and driving models while newer vehicles receive critical improvements. Tesla has not provided a remedy, timeline, or alternative solution. I request NHTSA to investigate Tesla’s failure to provide advertised and safety‑related FSD functionality for HW2 vehicles. Vehicle Info: 2020 Tesla Model 3 Hardware: HW2 FSD purchased on VIN (previous owner) Purchased used in July 2023 Current FSD version: 12.6.4 (no further updates)

SUSPENSION — Filed 02/16/2026

This was not an incident. Instead I’d like to report it as a design flaw. I discovered low speed noise and got it fixed at Tesla service center. Upper control arms and lower control links have both been replaced at ~70k miles and the cost to repair was over $2k at Tesla service center in Feb 2026. Later in May 2026 Tesla published a service bulletin acknowledging this is a design flaw

ELECTRICAL SYSTEM — Filed 12/01/2025

The screen (which controls all functions of the vehicle) starts to go haywire. It's almost like there is a phantom touching the screen and pressing buttons. The screen will start zooming in and out - changing your navigation destination. The air controls will turn on full blast and then you are unable to shut them off because the screen will not respond. It becomes a giant distraction to the driver (imagine a screen that large malfunctioning) and tesla does not think this is a safety issue. We reported it to them. They couldn't replicate the issue (is what they told us and then let us know it was out of warranty and we could just replace the screen to a tune of almost $2000). There are no cracks or issues with the screen itself. I cannot upload the videos as they are too big to share but I can send them to an email address.

FORWARD COLLISION AVOIDANCE — Filed 05/11/2026

Tesla was on Full Self Driving following a curve in the road were traffic lights. Lights were red Car should have stopped but did not. Ran red light with no attempt to stop or slow down.